2009 FIAT PANDA replace light

160KNOW
YOUR VEHICLE
SAFETY
CORRECT USE
OF THE CAR
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCYCAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
F0Z0087m
fig. 165
Refer to the tables on the following pages to identify the
protection fuse.
If a general fuse (MEGA-FUSE, MIDI-
FUSE, MAXI-FUSE) cuts in, do not at-
tempt any repair and contact a Fiat Dealership.
WARNING
Before replacing a fuse, make sure the ig-
nition key has been removed and that all
the other services are switched off and/or
disengaged.If the replaced fuse blows again, contact
a Fiat Dealership.
WARNING
Never replace a blown fuse with metal
wires or other recovered material.
WARNING
Never replace a fuse with another of high-
er power: FIRE HAZARD.
WARNING
REPLACING FUSESGENERAL FEATURES fig. 165
Fuses protect the electric system: they cut in (i.e. they
blow) in the event of a failure or improper action on the
system.
When a device does not work, check the efficiency of its
fuse: the filament A must be intact. If it is, replace the blown
fuse with another with the same amperage (same colour).
B undamaged fuse.
C fuse with damaged filament.
To facilitate fuse replacement, use the pliers D hooked
to the fuse-box on the dashboard left-hand side.
135-168 PANDA EN 7-10-2009 14:07 Pagina 160

169KNOW
YOUR VEHICLE
SAFETY
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCYCAR
MAINTENANCETECHNICAL
SPECIFICATIONS
INDEX
CAR MAINTENANCE
SCHEDULED SERVICINGCorrect servicing is essential in guaranteeing a long life for
the car under the best conditions.
This is why Fiat has programmed a series of checks and
servicing operations every 20,000 km.
It is however important to remember that scheduled ser-
vicing does not completely cover all the car’s requirements:
also in the initial run-in period before 20,000 km service
coupon and later, between each servicing interval, ordi-
nary care is still required, such as for example routine
check and topping-up the level of fluids, tyre pressure
check, etc...
CORRECT USE
OF THE CAR
IMPORTANT Scheduled Servicing coupons are specified
by the Manufacturer. Failure to have them carried out may
invalidate the warranty.
Schedule servicing can be carried out by any Fiat Dealership,
at pre-established times.
If during each operation, in addition to the ones pro-
grammed, the need arises for further replacements or re-
pairs, these may only be carried out with the express
agreement of the Customer.
IMPORTANT It is advisable to contact a Fiat Dealership
in the event of any minor operating failure, without wait-
ing for the next service coupon.
If the car is used frequently for towing a trailer, the inter-
val between services should be reduced.
169-190 PANDA EN 7-10-2009 14:14 Pagina 169

●●●
●●● ●● ●● ●●
●●
●
●●●●
●●●●
●●
●●● ●● ●● ●●
(●)(
●)(
●)(
●)(
●)(
●)(
●)(
●)(
●)
●●●
●●● ●● ●● ●●
●●●●
●●●
20 40 60 80 100 120 140 160 180
Thousands of km
Replace air filter cartridge
(every 30,000 km for 1.3 Multijet engine)
Top-up fluids (engine coolant, brakes, windscreen washer, battery, etc...)Check timing belt conditions (1.3 Multijet engine excluded)
Replace toothed timing drive belt (*) (1.3 Multijet engine excluded)Change spark plugs (petrol versions)
Check engine management system operation (through the diagnosis socket)Check gearbox fluid levelChange engine oil and oil filter (petrol versions)Change engine oil and oil filter (Multijet versions with DPF) (**)
Change engine oil and oil filter (Multijet versions with DPF) (**)Change brake fluid (or every two years)Replace pollen filter (or once a year)Check exhaust emissions/smokiness (1.3 Multijet engine)Replace fuel filter cartridge (Green-filter) (1.3 Multijet engine)
(*) Or every 4 years for heavy usage (cold climates, town driving with long idling stops)
Or every 5 years, irrespective of the covered mileage
(**) Engine oil and filter shall be changed when the corresponding warning light turns on (see chapter “Warning lights and Mes-
sages”), or in any case every 2 years.
If the car is used mainly for town driving, the engine oil and filter should be changed every 12 months.
INDEX TECHNICAL
SPECIFICATIONSCAR
MAINTENANCEIN
AN EMERGENCY WARNING LIGHTS
AND MESSAGES CORRECT USE
OF THE CAR SAFETY KNOW
YOUR VEHICLE171
169-190 PANDA EN 7-10-2009 14:14 Pagina 171

Car maintenance should be charged to
a Fiat Dealership. For routine and minor
maintenance operations you wish to carry
out yourself, always make sure you have the prop-
er equipment, genuine Fiat spare parts and the nec-
essary fluids; do not however carry out these
operations if you have no experience.
IMPORTANT – Battery
Check the battery charge once a year, preferably before
at the beginning of winter to limit the risk of electrolyte
freezing.
This check should be carried out more frequently if the
car is used mainly for short journeys, or if it is fitted with
accessories that permanently absorb electricity even with
the ignition key removed, especially in the case of after-
market accessories. If the car is used in hot climates or
particularly harsh conditions it is advisable to check the
level of the battery fluid (electrolyte) more frequently than
specified in the “Scheduled Servicing Programme”.
❒
frequently idling engine or long distance low speed dri-
ving (e.g. taxis or door-to-door deliveries) or in case
of a long term inactivity;
change engine oil more frequently than required on the
“Scheduled Servicing Programme”.
IMPORTANT – Diesel filter
The possibility of topping-up with diesel fuel not comply-
ing with EN 590 European Standard might make it neces-
sary to replace the filter more frequently than indicated in
the “Scheduled Servicing Programme”.
IMPORTANT – Air filter
When the car is used on dusty roads, change the air fil-
ter more frequently than shown on the “Scheduled Ser-
vicing Programme”. If in doubt as to how often the en-
gine oil and air filter should be changed according to how
you use the car, contact a Fiat Dealership.
IMPORTANT – Pollen filter
It is advisable to replace the filtering element more fre-
quently if the car is used in dusty or very polluted places.
Specifically, replace if a lower air flow into the passen-
ger’s compartment is found.
INDEX TECHNICAL
SPECIFICATIONSCAR
MAINTENANCEIN
AN EMERGENCY WARNING LIGHTS
AND MESSAGES CORRECT USE
OF THE CAR SAFETY KNOW
YOUR VEHICLE173
169-190 PANDA EN 7-10-2009 14:14 Pagina 173

177KNOW
YOUR VEHICLE
SAFETY
CORRECT USE
OF THE CAR
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCYCAR
MAINTENANCETECHNICAL
SPECIFICATIONS
INDEX
F0Z0182m
fig. 179
F0Z0107m
fig. 178
ENGINE COOLANT fig. 178 and 179
The coolant level must be checked when the engine is cold
and must range between the MIN. and MAX. marks on the
reservoir.
If the level is low, pour slowly a mixture of 50% deminer-
alised water and 50% PARAFLU
UP
of FL Selenia through
the filler neck A until approaching the MAX. level.
A 50-50 mixture of PARAFLU
UP
and demineralised wa-
ter gives freeze protection to −35 °C.
For particularly harsh climate conditions, a mixture of 60%
PARAFLU
UP
and 40% demineralised water is recom-
mended.
When the engine is hot, take care when
working inside the engine compartment to
avoid burns. Remember that when the engine is
hot, the fan may cut in: danger of injury. Scarves,
ties and other loose clothing might be pulled by
moving parts.
WARNING
Never add any oil with different specifica-
tions than those of the existing engine oil. Used engine oil and the replaced oil filter
contain substances that may be dangerous
for the environment. It is advisable to have
oil and filters changed by a Fiat Dealership where
they will be disposed respecting the environment
and according to law prescription.
169-190 PANDA EN 7-10-2009 14:14 Pagina 177

The engine cooling system is pressurised.
If necessary, only replace the cap with an-
other genuine one or the operation of the system
may be adversely affected. Do not remove the cap
from the reservoir when the engine is hot: dan-
ger of scalding.
WARNING
The engine cooling system uses protective
antifreeze fluid PARAFLU
UP. Use the same
fluid as in the cooling system when topping
up. PARAFLU
UP
fluid cannot be mixed with any oth-
er type of fluid. If this accidentally occurs, do not
start the engine and contact a Fiat Dealership.
Do not travel with the windscreen wash-
er reservoir empty: the windscreen
washer is fundamental for improving visibility.
WARNING
WINDSCREEN/REAR WINDOW WASHER
FLUID fig. 180
To top-up, remove the cap A.
Pour a mixture of water and TUTELA PROFESSIONAL
SC35, in the following concentrations:
30% TUTELA PROFESSIONAL SC35 and 70% water in
summer.
50% TUTELA PROFESSIONAL SC35 and 50% water in
winter.
At temperatures below −20 °C, use undiluted TUTELA
PROFESSIONAL SC35 fluid.
Check level through the reservoir.
fig. 180
F0Z0183m
INDEX TECHNICAL
SPECIFICATIONSCAR
MAINTENANCEIN
AN EMERGENCY WARNING LIGHTS
AND MESSAGESCORRECT USE
OF THE CARSAFETYKNOW
YOUR VEHICLE
178
169-190 PANDA EN 7-10-2009 14:14 Pagina 178

Certain commercial additives for wind-
screen washers are inflammable. The en-
gine compartment contains hot parts which could
start a fire if they come into contact.
WARNING
Prevent brake fluid which is highly corrosive
from coming into contact with painted
parts. Should this occur, immediately wash
with water. Brake fluid is poisonous and highly corro-
sive. In the event of accidental contact, im-
mediately wash the affected parts with water
and neutral soap. Then rinse thoroughly. If swal-
lowed call a doctor straight away.
WARNING
BRAKE FLUID fig. 181
Undo the cap A and check that the liquid contained in the
reservoir is at the maximum level.
Fluid level in the reservoir must not exceed the MAX
mark.
Use the brake fluid shown in the “Fluids and lubricants”
table (see “Technical Specifications”).
NOTE Carefully clean the reservoir cap A and the sur-
rounding surface.
Take great care that impurities do not enter the reservoir
when the cap is opened.
For topping-up, always use a funnel with integrated filter
with mesh equal to or lower than 0.12 mm.
IMPORTANT Brake fluid is hygroscopic (i.e. it absorbs
moisture). For this reason, if the car is mainly used in ar-
eas with a high degree of atmospheric humidity, the fluid
should be replaced at more frequent intervals than spec-
ified in the “Scheduled Servicing Programme”.
fig. 181
F0Z0109m
INDEX TECHNICAL
SPECIFICATIONSCAR
MAINTENANCEIN
AN EMERGENCY WARNING LIGHTS
AND MESSAGES CORRECT USE
OF THE CAR SAFETY KNOW
YOUR VEHICLE179
169-190 PANDA EN 7-10-2009 14:15 Pagina 179

180KNOW
YOUR VEHICLE
SAFETY
CORRECT USE
OF THE CAR
WARNING LIGHTS
AND MESSAGES
IN
AN EMERGENCYCAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
F0Z0135m
fig. 183
F0Z0134m
fig. 182
AIR FILTERREPLACEMENT (petrol versions) fig. 182 and 183
Release the clips A, remove the cover front side B
and extract the filtering element C to be replaced.
Brake fluid is poisonous and highly corro-
sive. In the event of accidental contact, im-
mediately wash the affected parts with water
and neutral soap. Then rinse thoroughly. Call a
doctor immediately if swallowed.
WARNING
The symbol
π
on the container indicates
a synthetic brake fluid, distinguishing it
from the mineral kind. Use of a mineral type flu-
ids will damage the special rubber seals of the
braking system beyond repair.WARNING
The symbol πon the container indicates
a synthetic brake fluid, which is different
from a mineral fluid. Use of a mineral-based flu-
id will damage the special rubber seals of the brak-
ing system beyond repair.
WARNING
169-190 PANDA EN 7-10-2009 14:15 Pagina 180