2009 DODGE JOURNEY cooling

The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing surfaces.
WARNING!
•The warning words “DO NOT OPEN HOT” on
the cooling system pressure cap are a safety pre-
caution. Never add coolant when the engine is
overheated. Do not loosen or remove the cap to
cool an overheated engine. Heat causes pressure to
build up in the cooling system. To prevent scald-
ing or injury, do not remove the pressure cap while
the system is hot or under pressure.
•Do not use a pressure cap other than the one
specified for your vehicle. Personal injury or en-
gine damage may result.
Disposal of Used Coolant
Used ethylene glycol-based engine coolant is a regulated
substance requiring proper disposal. Check with your
local authorities to determine the disposal rules for your
community. To prevent ingestion by animals or children,
do not store ethylene glycol-based engine coolant in open
containers or allow it to remain in puddles on the
ground. If ingested by a child, contact a physician
immediately. Clean up any ground spills immediately.
Coolant Level
Four Cylinder Engines —the coolant bottle provides a
quick visual method for determining that the coolant
level is adequate. With the engine idling and warm to
normal operating temperature, the level of the coolant in
the bottle should be between the “ADD” and “FULL”
lines, shown on the bottle.
MAINTAINING YOUR VEHICLE 443
7

Six Cylinder Engines —the level of the coolant in the
pressurized coolant bottle should be between the
“COLD” and “FULL” range on the bottle when the
engine is cold.
The radiator normally remains completely full, so there is
no need to remove the radiator cap unless checking for
coolant freeze point or replacing coolant. Advise your
service attendant of this. As long as the engine operating
temperature is satisfactory, the coolant bottle need only
be checked once a month. When additional coolant is
needed to maintain the proper level, it should be added
to the coolant bottle. Do not overfill.
Points to Remember
NOTE: When the vehicle is stopped after a few miles
(kilometers) of operation, you may observe vapor coming
from the front of the engine compartment. This is nor-
mally a result of moisture from rain, snow, or high humidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot coolant to
enter the radiator.
If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
•Do not overfill the coolant recovery bottle.
•Check coolant freeze point in the radiator and in the
coolant recovery bottle. If antifreeze needs to be
added, contents of coolant recovery bottle must also be
protected against freezing.
•If frequent coolant additions are required, or if the
level in the coolant recovery bottle does not drop when
the engine cools, the cooling system should be pres-
sure tested for leaks.
444 MAINTAINING YOUR VEHICLE

FLUIDS AND CAPACITIES
ComponentU.S.Metric
Fuel (approximate)
Front Wheel Drive (FWD) Models with 2.4 Liter PZEV Engine 18.5 gal70 l
FWD Models without 2.4 Liter PZEV Engine 20.5 gal77.6 l
All-Wheel Drive Models 21.1 gal79.8 l
Engine Oil with Filter
2.4 Liter Engine (SAE 5W-20, API Certified) 4.5 qts4.26 l
2.7 Liter Engine (SAE 5W-20, API Certified) 5.5 qts5.2 l
3.5 Liter Engine (SAE 10W-30, API Certified) 5.5 qts5.2 l
Cooling System *
2.4 Liter Engine and Single- or Dual-Zone Climate Control System
(Mopar Antifreeze/Coolant 5 Year/100,000 Mile Formula) or equiva-
lent 7.9 qts
7.5 l
2.4 Liter Engine and Three-Zone Climate Control System (Mopar
Antifreeze/Coolant 5 Year/100,000 Mile Formula) or equivalent 9.8 qts
9.3 l
472 MAINTAINING YOUR VEHICLE

Console, Overhead....................... 162
Contract, Service ........................ 489
Converter, Catalytic ...................... 429
Coolant Pressure Cap (Radiator Cap) .......... 442
Cooler, Beverage ........................ 180
Cooling System ......................... 440
Adding Coolant (Antifreeze) .............. 442
Coolant Capacity ...................... 472
Coolant Level ...................... 440,443
Disposal of Used Coolant ................ 443
Drain, Flush, and Refill .................. 441
Inspection ........................... 443
Points to Remember .................... 444
Pressure Cap ......................... 442
Radiator Cap ......................... 442
Selection of Coolant (Antifreeze) ......441,472,474
Temperature Gauge ..................... 205
Corrosion Protection ..................... 452
Cruise Control (Speed Control) .............. 159Cruise Light
........................... 212
Cup Holder ......................... 178,457
Customer Assistance ..................... 487
Customer Programmable Features ............ 230
Data Recorder, Event ...................... 63
Daytime Brightness, Interior Lights ........... 153
Daytime Running Lights ................... 148
Dealer Service .......................... 424
Defroster, Rear Window ................... 195
Defroster, Windshield ................80,286,287
Delay (Intermittent) Wipers ................. 155
Diagnostic System, Onboard ................ 421
Digital Video Disc (DVD) Player ..........234,266
Dimmer Control ........................ 152
Dimmer Switch, Headlight ................. 150
Dipsticks Automatic Transaxle .................... 449
Oil (Engine) .......................... 424
500 INDEX

Air Cleaner.......................... 429
Block Heater ......................... 311
Break-In Recommendations ................ 77
Checking Oil Level ..................... 424
Compartment ......................... 418
Coolant (Antifreeze) ................. 440,474
Cooling ............................. 440
Exhaust Gas Caution ................ 39,79,372
Fails to Start .......................... 310
Flooded, Starting ...................... 310
Fuel Requirements ..................... 368
Jump Starting ......................... 407
Oil ........................... 424,472,474
Oil Change Interval ...............210,225,426
Oil Filler Cap ................. 418,419,420,427
Oil Filter ............................ 428
Oil Filter Disposal ...................... 428
Oil Selection ....................... 426,472
Oil Synthetic ......................... 427 Operation
............................ 77
Overheating .......................... 394
Starting ............................. 307
Temperature Gauge ..................... 205
Engine Oil Viscosity ...................... 427
Enhanced Accident Response Feature .......... 61
Entry System, Illuminated .................. 20
Ethanol ............................... 369
Event Data Recorder ...................... 63
Exhaust Gas Caution ..............39,79,372,439
Exhaust System ....................... 79,439
Express Down Windows ................... 25
Exterior Folding Mirrors ................... 90
Exterior Light Service ..................... 466
Exterior Lights ........................ 81,466
Fabric Care ......................... 454,455
Filler Location Fuel ...................... 372
502 INDEX

FiltersAir Cleaner .......................... 429
Air Conditioning .................... 301,434
Automatic Transaxle .................... 451
Engine Oil ........................ 428,474
Engine Oil Disposal .................... 428
Flashers Hazard Warning ....................... 394
Turn Signal ...................... 81,149,207
Flash-To-Pass ........................... 150
Flexible Fuel Vehicles ..................... 364
Cruising Range ........................ 367
Engine Oil ........................... 366
Fuel Requirements .................. 364,365
Maintenance ....................... 364,367
Replacement Parts ..................... 367
Starting ............................. 367
Flooded Engine Starting ................... 310
Floor Console .......................... 183 Fluid, Brake
........................... 476
Fluid Capacities ......................... 472
Fluid Leaks ............................. 81
Fluid Level Checks Automatic Transaxle .................... 449
Brake ............................ 447,476
Cooling System ....................... 440
Engine Oil ........................... 424
Power Steering ..................... 436,476
Fluids ................................ 474
Fluids, Lubricants and Genuine Parts .......... 474
Fog Light Service ........................ 467
Fog Lights .................... 146,148,207,467
Folding Front Passenger Seat ............... 128
Folding Rear Seat ..................... 141,134
Freeing A Stuck Vehicle ................... 410
Front Wheel Bearings ..................... 451
Fuel ................................. 368
Adding ............................. 372
INDEX 503
10

Towing Vehicle Behind a Motor Home......... 392
Traction .............................. 320
Traction Control ...................... 215,331
Trailer Sway Control (TSC) ................. 335
Trailer Towing .......................... 377
Cooling System Tips .................... 392
Hitches ............................. 381
Minimum Requirements ................. 385
Tips ................................ 390
Trailer and Tongue Weight ................ 384
Wiring .............................. 388
Trailer Towing Guide ..................... 382
Trailer Weight .......................... 382
Transaxle Additives ............................ 451
Automatic ........................ 31 1,449
Autostick ............................ 317
Filter ............................... 451
Maintenance .......................... 449 Operation
............................ 311
Overdrive ........................... 315
Selection of Lubricant ................... 476
Transmission ..................... See Transaxle
Transmitter Battery Service
(Remote Keyless Entry) .................... 25
Transmitter, Garage Door Opener
(HomeLink) ........................... 163
Transmitter Programming
(Remote Keyless Entry) .................... 20
Transmitter, Remote Keyless Entry (RKE) ........ 20
Transporting Pets ........................ 77
Tread Wear Indicators .................... 351
Trip Odometer .......................... 209
Trip Odometer Reset Button .............212,218
Turn Signals ................... 146,149,207,468
UCI Connector ......................... 278
UConnect (Hands-Free Phone) ............93,266
INDEX 517
10