2009 DODGE CHALLENGER adding oil

MAINTAINING YOUR VEHICLE
CONTENTS
Engine Compartment — 3.5L............. 366
Engine Compartment — 5.7L............. 367
Onboard Diagnostic System — OBD II...... 368
▫Loose Fuel Filler Cap................. 368
Emissions Inspection And Maintenance
Programs............................ 369
Replacement Parts..................... 370
Dealer Service........................ 371Maintenance Procedures................. 371
▫Engine Oil......................... 372
▫Engine Oil Filter..................... 375
▫Engine Air Cleaner Filter............... 376
▫Maintenance-Free Battery.............. 376
▫Air Conditioner Maintenance............ 378
▫Body Lubrication.................... 379
▫Windshield Wiper Blades............... 380
▫Adding Washer Fluid................. 380
7
363

CAUTION! (Continued)
•Your vehicle has been built with improved fluids
that protect the performance and durability of
your vehicle and also allow extended maintenance
intervals. Do not use chemical flushes in these
components as the chemicals can damage your
engine, transmission, power steering or air condi-
tioning. Such damage is not covered by the New
Vehicle Limited Warranty. If a flush is needed
because of component malfunction, use only the
specified fluid for the flushing procedure.
Engine Oil
Checking Oil Level — 3.5L Engine
To assure proper engine lubrication, the engine oil must
be maintained at the correct level. Check the oil level atregular intervals, such as every fuel stop. The best time to
check the engine oil level is about five minutes after a
fully warmed engine is shut off.
Checking the oil while the vehicle is on level ground will
improve the accuracy of the oil level readings. Maintain
the oil level between the MIN and MAX markings on the
dipstick. Adding 1.0 qt (1.0 L) of oil when the reading is
at the MIN mark will result in a MAX reading on these
engines.
CAUTION!
Overfilling or underfilling will cause oil aeration or
loss of oil pressure. This could damage your engine.
Checking Oil Level — 5.7L Engine
To assure proper engine lubrication, the engine oil must
be maintained at the correct level. Check the oil level at
372 MAINTAINING YOUR VEHICLE

regular intervals, such as every fuel stop. The best time to
check the engine oil level is about five minutes after a
fully warmed engine is shut off.
Checking the oil while the vehicle is on level ground will
improve the accuracy of the oil level readings. Maintain
the oil level in the “SAFE” range. Adding 1.0 qt (1.0 L) of
oil when the reading is at the bottom of the “SAFE” range
will result in an oil level at the top of the “SAFE” range
on these engines.
CAUTION!
Overfilling or underfilling will cause oil aeration or
loss of oil pressure. This could damage your engine.
Change Engine Oil
The oil change indicator system will remind you that it is
time to take your vehicle in for scheduled maintenance.
Refer to the “Maintenance Schedule” in Section 8 for
information on this system.
NOTE: Under no circumstances should oil change
intervals exceed 6,000 miles (10 000 km) or six months,
whichever occurs first.
Engine Oil Selection
For best performance and maximum protection under all
types of operating conditions, the manufacturer only
recommends engine oils that are API Certified and meet
the requirements of Chrysler Material Standard MS-6395.
7
MAINTAINING YOUR VEHICLE 373

WARNING!
•Use only refrigerants and compressor lubricants
approved by the manufacturer for your air condi-
tioning system. Some unapproved refrigerants are
flammable and can explode, injuring you. Other
unapproved refrigerants or lubricants can cause
the system to fail, requiring costly repairs. Refer to
Section 3 of the Warranty Information Book for
additional warranty information.
•The air conditioning system contains refrigerant
under high pressure. To avoid risk of personal
injury or damage to the system, adding refrigerant
or any repair requiring lines to be disconnected
should be done by an experienced technician.
Refrigerant Recovery and Recycling
R-134a Air Conditioning Refrigerant is a hydrofluoro-
carbon (HFC) that is endorsed by the EnvironmentalProtection Agency and is an ozone-saving product. How-
ever, the manufacturer recommends that air conditioning
service be performed by authorized dealers or other
service facilities using recovery and recycling equipment.
NOTE:Use only manufacturer approved A/C system
sealers, stop leak products, seal conditioners, compressor
oil, and refrigerants.
Body Lubrication
Locks and all body pivot points, including such items as
seat tracks, door hinge pivot points and rollers, liftgate,
tailgate, sliding doors and hood hinges, should be lubri-
cated periodically with a lithium based grease such as
MOPARSpray White Lube to assure quiet, easy opera-
tion and to protect against rust and wear. Prior to the
application of any lubricant, the parts concerned should
be wiped clean to remove dust and grit; after lubricating
excess oil and grease should be removed. Particular
7
MAINTAINING YOUR VEHICLE 379

attention should also be given to hood latching compo-
nents to ensure proper function. When performing other
underhood services, the hood latch, release mechanism
and safety catch should be cleaned and lubricated.
The external lock cylinders should be lubricated twice a
year, preferably in the Fall and Spring. Apply a small
amount of a high quality lubricant such as MOPAR
Lock Cylinder Lubricant directly into the lock cylinder.
Windshield Wiper Blades
Clean the rubber edges of the wiper blades and the
windshield periodically with a sponge or soft cloth and a
mild nonabrasive cleaner. This will remove accumula-
tions of salt or road film.
Operation of the wipers on dry glass for long periods
may cause deterioration of the wiper blades. Always use
washer fluid when using the wipers to remove salt or dirt
from a dry windshield.Avoid using the wiper blades to remove frost or ice from
the windshield. Keep the blade rubber out of contact with
petroleum products such as engine oil, gasoline, etc.
NOTE:Life expectancy of wiper blades varies depend-
ing on geographical area and frequency of use. Poor
performance of blades may be present with chattering,
marks, water lines or wet spots. If any condition is
present please proceed to clean wiper blades with humid
cloth removing any debris that may be affecting its
function.
Adding Washer Fluid
The windshield washer fluid reservoir is located in the
front of the engine compartment. Be sure to check the
fluid level at regular intervals. Fill the reservoir with
windshield washer solvent (not radiator antifreeze) and
operate the system for a few seconds to flush out the
residual water.
380 MAINTAINING YOUR VEHICLE

Automatic Door Locks..................... 30
Automatic Headlights.................... 120
Automatic Oil Change Indicator............. 162
Automatic Transaxle
Special Additives...................... 394
Automatic Transmission.............259,264,393
Adding Fluid......................393,416
Autostick............................ 268
Fluid and Filter Changes................. 393
Fluid Change......................... 393
Fluid Level Check..................... 393
FluidType ........................... 416
Gear Ranges......................... 259
Overdrive........................... 261
Shifting ..........................259,264
Special Additives...................... 394
Torque Converter...................... 262
Automatic Transmission Limp Home Mode . . 263,267
Autostick............................. 268AxleFluid ............................. 416
Axle Lubrication (Axle Fluid)............... 416
Battery............................... 376
Emergency Starting..................... 356
Jump Starting......................... 356
Keyless Transmitter Replacement (RKE)....... 24
Location..........................357,376
Belts, Seat............................ 37,68
Body Mechanism Lubrication............... 379
B-Pillar Location........................ 293
Brake Assist System...................... 281
Brake Control System, Electronic............. 280
Brake Fluid............................ 416
Brake, Parking.......................... 274
Brake System........................277,389
Anti-Lock (ABS)....................277,280
Fluid Check.......................390,416
Master Cylinder....................... 390
10
INDEX 445

Filters
Air Cleaner.......................... 376
Air Conditioning...................... 236
Engine Oil........................375,415
Engine Oil Disposal.................... 375
Flashers
Hazard Warning....................... 338
Turn Signal...................... 69,122,158
Flash-To-Pass........................... 123
Flat Tire Changing....................... 345
Flooded Engine Starting................... 249
Fluid, Brake........................... 416
Fluid Capacities......................... 414
Fluid Leaks............................. 69
Fluid Level Checks
Automatic Transmission................. 393
Brake.............................. 390
Cooling System....................... 384
Engine Oil........................... 372Power Steering........................ 273
Fluids ................................ 415
Fluids, Lubricants and Genuine Parts.......... 415
FogLights ..........................121,160
Folding Rear Seat........................ 116
Freeing A Stuck Vehicle................... 359
Fuel................................. 316
Adding............................. 321
Additives ............................ 319
CleanAir ............................ 317
Conserving.......................... 172
Ethanol............................. 317
Filler Cap (Gas Cap).................... 321
Gasoline............................ 316
Gauge.............................. 156
Materials Added....................... 319
Methanol............................ 317
Octane Rating......................316,415
Requirements......................... 316
450 INDEX

Transporting Pets........................ 65
Tread Wear Indicators.................... 302
Trip Odometer.......................156,161
Trunk Lid (Deck Lid).................... 34,35
Trunk Release, Emergency.................. 35
Trunk Release Remote Control............... 34
Turn Signals.........................122,158
UCI Connector......................... 217
uconnect(Hands-Free Phone)............... 78
Uniform Tire Quality Grades................ 440
Universal Consumer Interface (UCI) Connector . . . 217
Universal Transmitter..................... 133
Unleaded Gasoline....................... 316
Untwisting Procedure, Seat Belt.............. 41
VanityMirrors ........................... 77
Variance, Compass....................... 176
Vehicle Certification Label................. 323Vehicle Identification Number (VIN)............ 6
Vehicle Loading...................294,323,325
Vehicle Modifications/Alterations.............. 7
Vehicle Storage.......................235,407
Vehicle Theft Alarm (Security Alarm).......... 18
Viscosity, Engine Oil...................... 374
Voice Recognition System (VR).............. 106
Warning Flasher, Hazard.................. 338
Warning Lights
(Instrument Cluster Description)............. 156
Warnings and Cautions..................... 6
Warranty Information..................... 438
Washer, Adding Fluid..................... 380
Washers, Windshield................125,126,380
Washing Vehicle......................... 395
Water
Driving Through...................... 270
Wheel and Wheel Trim.................... 397
10
INDEX 463