2009 CHEVROLET MALIBU engine coolant

(i)Drain, flush, and refill cooling system. This service can
be complex; you should have your dealer/retailer perform
this service. See Engine Coolant on page 5-29 for what to
use. Inspect hoses. Clean radiator, condenser, pressure
cap, and filler neck. Pressure test the cooling system and
pressure cap.
(j)A fluid loss in any vehicle system could indicate a
problem. Have the system inspected and repaired and
the fluid level checked. Add fluid if needed.
(k)If driving regularly under dusty conditions, inspect
the filter at each engine oil change.
(l)Visually inspect belt for fraying, excessive cracks, or
obvious damage. Replace belt if necessary.
Owner Checks and Services
These owner checks and services should be performed
at the intervals specied to help ensure vehicle safety,
dependability, and emission control performance. Your
dealer/retailer can assist with these checks and services.
Be sure any necessary repairs are completed at once.
Whenever any uids or lubricants are added to the
vehicle, make sure they are the proper ones, as shown
inRecommended Fluids and Lubricants on page 6-12.
At Each Fuel Fill
It is important to perform these underhood checks at
each fuel fill.
Engine Oil Level Check
Notice:It is important to check the engine oil
regularly and keep it at the proper level. Failure to
keep the engine oil at the proper level can cause
damage to the engine not covered by the vehicle
warranty.
Check the engine oil level and add the proper oil if
necessary. SeeEngine Oil on page 5-21.
Engine Coolant Level Check
Check the engine coolant level and add DEX-COOL®
coolant mixture if necessary. SeeEngine Coolant
on page 5-29.
Windshield Washer Fluid Level Check
Check the windshield washer uid level in the windshield
washer uid reservoir and add the proper uid if
necessary.
6-8

Recommended Fluids and
Lubricants
Fluids and lubricants identied below by name, part
number, or specication can be obtained from your
dealer/retailer.
Usage Fluid/Lubricant
Engine OilEngine oil which meets GM
Standard GM6094M and displays
the American Petroleum Institute
Certied for Gasoline Engines
starburst symbol. To determine the
proper viscosity for your vehicle’s
engine, seeEngine Oil on
page 5-21.
Engine Coolant50/50 mixture of clean, drinkable
water and use only DEX-COOL
®
Coolant. SeeEngine Coolant on
page 5-29.
Hydraulic Brake
SystemDOT 3 Hydraulic Brake Fluid
(GM Part No. U.S. 88862806,
in Canada 88862807).
Windshield
WasherOptikleen
®Washer Solvent.
Usage Fluid/Lubricant
Hydraulic
Power Steering
System
(if equipped)GM Power Steering Fluid
(GM Part No. U.S. 89021184,
in Canada 89021186).
Automatic
TransmissionDEXRON
®-VI Automatic
Transmission Fluid.
Key Lock
CylindersMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241,
in Canada 10953474).
Hood Latch
Assembly,
Secondary
Latch, Pivots,
Spring
Anchor, and
Release PawlLubriplate Lubricant Aerosol
(GM Part No. U.S. 12346293,
in Canada 992723) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Hood and Door
HingesMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241,
in Canada 109435474).
Weatherstrip
ConditioningWeatherstrip Lubricant
(GM Part No. U.S. 3634770,
in Canada 10953518) or
Dielectric Silicone Grease
(GM Part No. U.S. 12345579,
in Canada 992887).
6-12

Chains, Tire...................................................5-74
Charging System Light....................................3-33
Check
Engine Lamp..............................................3-38
Checking Things Under the Hood......................5-14
Chemical Paint Spotting...................................5-97
Child Restraints
Infants and Young Children...........................1-35
Lower Anchors and Tethers for
Children..................................................1-44
Older Children.............................................1-32
Securing a Child Restraint in a
Rear Seat Position...................................1-52
Securing a Child Restraint in the
Right Front Seat Position..........................1-54
Systems.....................................................1-39
Where to Put the Restraint...........................1-42
Chime Level Adjustment..................................3-92
Cleaning
Aluminum Wheels........................................5-95
Exterior Lamps/Lenses.................................5-94
Fabric/Carpet..............................................5-91
Finish Care.................................................5-94
Instrument Panel, Vinyl, and Other
Plastic Surfaces.......................................5-92
Interior.......................................................5-90
Leather......................................................5-92
Tires..........................................................5-96Cleaning (cont.)
Underbody Maintenance...............................5-97
Washing Your Vehicle...................................5-93
Weatherstrips..............................................5-93
Windshield and Wiper Blades........................5-95
Climate Control System...................................3-20
Outlet Adjustment........................................3-27
Climate Control Systems
Automatic...................................................3-24
Clock, Setting.................................................3-57
Collision Damage Repair..................................7-12
Compact Spare Tire........................................
5-89
Compass.......................................................2-38
Content Theft-Deterrent....................................2-18
Control of a Vehicle.......................................... 4-4
Convenience Net............................................2-51
Coolant
Engine.......................................................5-29
Engine Temperature Gage............................3-37
Engine Temperature Warning Light.................3-36
Surge Tank Pressure Cap.............................5-33
Cooling System..............................................5-28
Courtesy Transportation...................................7-10
Cruise Control................................................3-10
Cruise Control Light........................................3-42
Cupholders....................................................2-50
3

Electrical System
Engine Compartment Fuse Block.................5-102
Fuses........................................................5-99
Instrument Panel Fuse Block.........................5-99
Power Windows and Other Power Options......5-98
Rear Compartment Fuse Block....................5-105
Windshield Wiper Fuses...............................5-98
Electronic Immobilizer
PASS-Key
®III+...........................................2-19
Electronic Immobilizer Operation
PASS-Key
®III+...........................................2-20
Electronic Stability Control................................. 4-6
Electronic Stability Control Indicator Light...........3-35
Engine
Air Cleaner/Filter.........................................5-26
Check and Service Engine Soon Lamp...........3-38
Compartment Overview................................5-16
Coolant......................................................5-29
Coolant Heater............................................2-25
Coolant Temperature Gage...........................3-37
Coolant Temperature Warning Light................3-36
Cooling System...........................................5-28
Drive Belt Routing.......................................6-14
Exhaust.....................................................2-35
Oil .............................................................5-21
Oil Life System...........................................5-24Engine (cont.)
Overheated Protection Operating Mode...........5-36
Overheating................................................5-34
Starting......................................................2-24
Entry/Exit Lighting...........................................3-16
Event Data Recorders.....................................7-18
Extender, Safety Belt.......................................1-32F
Filter
Engine Air Cleaner......................................5-26
Finish Damage...............................................5-96
Flashers, Hazard Warning.................................. 3-6
Flash-to-Pass................................................... 3-8
Flat Tire........................................................5-75
Flat Tire, Changing.........................................5-76
Flat Tire, Storing.............................................5-85
Fluid
Automatic Transmission................................5-28
Power Steering...........................................5-36
Windshield Washer......................................5-38
Fog Lamp
Fog ...........................................................3-15
Folding Rear Seat...........................................1-10
Front Storage Area.........................................2-50
5

Fuel............................................................... 5-5
Additives...................................................... 5-7
California Fuel.............................................. 5-6
E85 (85% Ethanol)........................................ 5-8
Economy Driving........................................... 4-2
Filling a Portable Fuel Container....................5-13
Filling the Tank...........................................5-10
Fuels in Foreign Countries............................5-10
Gage .........................................................3-42
Gasoline Octane........................................... 5-6
Gasoline Specications.................................. 5-6
Fuses...........................................................5-99
Engine Compartment Fuse Block.................5-102
Instrument Panel Fuse Block.........................5-99
Rear Compartment Fuse Block....................5-105
Windshield Wiper.........................................5-98
G
Gage
Speedometer..............................................3-30
Tachometer.................................................3-30
Gages
Engine Coolant Temperature.........................3-37
Fuel..........................................................3-42
Trip Odometer.............................................3-30Garage Door Opener.......................................2-43
Gasoline
Octane........................................................ 5-6
Specications............................................... 5-6
Glove Box.....................................................2-50
GM Mobility Reimbursement Program.................. 7-7
H
Halogen Bulbs................................................5-47
Hazard Warning Flashers................................... 3-6
Head Restraints............................................... 1-2
Headlamp
Aiming .......................................................5-47
Headlamps....................................................3-13
Bulb Replacement.......................................5-47
Daytime Running Lamps (DRL).....................3-14
Delayed.....................................................3-14
Flash-to-Pass............................................... 3-8
High/Low Beam Changer................................ 3-8
On Reminder..............................................3-14
Headlamps Off in Park....................................3-14
Heated Seats................................................... 1-5
Heater...........................................................3-20
Engine Coolant...........................................2-25
Highbeam On Light.........................................3-42
6

Lights............................................................3-13
Airbag Readiness........................................3-31
Antilock Brake System (ABS) Warning............3-35
Brake System Warning.................................3-34
Charging System.........................................3-33
Cruise Control.............................................3-42
Engine Coolant Temperature Warning.............3-36
Flash-to-Pass............................................... 3-8
Highbeam On.............................................3-42
High/Low Beam Changer................................ 3-8
Oil Pressure...............................................3-41
On Reminder..............................................3-14
Passenger Airbag Status Indicator..................3-32
Safety Belt Reminders..................................3-30
Security.....................................................3-41
Tire Pressure..............................................3-37
Loading Your Vehicle.......................................4-20
Locks
Delayed Locking..........................................2-11
Door ..........................................................2-10
Lockout Protection.......................................2-12
Power Door ................................................2-10
Programmable Automatic Door Locks.............2-11
Rear Door Security Locks.............................2-12
Loss of Control...............................................4-12
Lower Anchors and Tethers for Children.............1-44
Lumbar
Manual Controls............................................ 1-4M
Maintenance
Footnotes..................................................... 6-7
Maintenance Schedule
Additional Required Services........................... 6-6
At Each Fuel Fill........................................... 6-8
At Least Once a Month.................................. 6-9
At Least Once a Year.................................... 6-9
Maintenance Record....................................6-16
Maintenance Replacement Parts....................6-13
Maintenance Requirements............................. 6-2
Owner Checks and Services........................... 6-8
Recommended Fluids and Lubricants.............6-12
Scheduled Maintenance................................. 6-4
Using.......................................................... 6-2
Your Vehicle and the Environment................... 6-2
Malfunction Indicator Lamp...............................3-38
Manual Lumbar Controls.................................... 1-4
Manual Seats................................................... 1-3
Message
DIC Warnings and Messages........................3-46
Mirrors
Automatic Dimming Rearview........................2-37
Manual Rearview Mirror................................2-37
Outside Automatic Dimming Mirror.................2-39
Outside Heated Mirrors................................2-40
Outside Power Mirrors..................................2-39
MP3 .............................................................3-71
8