2008 SATURN ASTRA belt

(D) Construction Code:A letter code is used to indicate
the type of ply construction in
the tire. The letter R means
radial ply construction; the
letter D means diagonal or
bias ply construction; and the
letter B means belted-bias
ply construction.
(E) Rim Diameter
:Diameter of
the wheel in inches.
(F) Service Description
:These characters represent the
load range and speed rating
of the tire. The load index
represents the load carry
capacity a tire is certied to
carry. The load index can range
from 1 to 279. The speed
rating is the maximum speed a
tire is certied to carry a load.
Speed ratings range from A to Z.
Tire Terminology and
Denitions
Air Pressure:The amount of
air inside the tire pressing
outward on each square inch
of the tire. Air pressure is
expressed in pounds per square
inch (psi) or kilopascal (kPa).
Accessory Weight
:This means
the combined weight of optional
accessories. Some examples
of optional accessories are,
automatic transmission, power
steering, power brakes, power
windows, power seats, and air
conditioning.
Aspect Ratio
:The relationship
of a tire’s height to its width.
Belt
:A rubber coated layer of
cords that is located between the
plies and the tread. Cords may
be made from steel or other
reinforcing materials.Bead
:The tire bead contains
steel wires wrapped by steel
cords that hold the tire onto
the rim.
Bias Ply Tire
:A pneumatic tire
in which the plies are laid at
alternate angles less than
90 degrees to the centerline of
the tread.
Cold Tire Pressure
:The
amount of air pressure in a
tire, measured in pounds
per square inch (psi) or
kilopascals (kPa) before a tire
has built up heat from driving.
SeeInflation - Tire Pressure on
page 9-46.
Curb Weight
:The weight of a
motor vehicle with standard
and optional equipment including
the maximum capacity of fuel,
oil, and coolant, but without
passengers and cargo.
Vehicle Service and Care 9-43
ProCarManuals.com

Buying New Tires
GM has developed and matched
specic tires for your vehicle.
The original equipment tires installed
on your vehicle, when it was new,
were designed to meet General
Motors Tire Performance Criteria
Specication (TPC Spec) system
rating. If you need replacement
tires, GM strongly recommends
that you get tires with the same
TPC Spec rating. This way,
your vehicle will continue to have
tires that are designed to give
the same performance and vehicle
safety, during normal use, as
the original tires.
GM’s exclusive TPC Spec system
considers over a dozen critical
specications that impact the
overall performance of your vehicle,
including brake system performance,
ride and handling, traction control,and tire pressure monitoring
performance. GM’s TPC Spec
number is molded onto the tire’s
sidewall near the tire size. If the tires
have an all-season tread design,
the TPC Spec number will be
followed by an MS for mud and
snow. SeeTire Sidewall Labeling on
page 9-40for additional information.
GM recommends replacing tires
in sets of four. This is because
uniform tread depth on all tires will
help keep your vehicle performing
most like it did when the tires were
new. Replacing less than a full
set of tires can affect the braking
and handling performance of
your vehicle. SeeTire Inspection
and Rotation on page 9-51for
information on proper tire rotation.{CAUTION
Mixing tires could cause you
to lose control while driving.
If you mix tires of different
sizes, brands, or types
(radial and bias-belted tires),
the vehicle may not handle
properly, and you could
have a crash. Using tires
of different sizes, brands,
or types may also cause
damage to the vehicle.
Be sure to use the correct
size, brand, and type of tires
on all wheels. It is all right
to drive with the compact
spare temporarily, as it was
developed for use on the
vehicle. SeeCompact Spare
Tire on page 9-67.
9-54 Vehicle Service and Care
ProCarManuals.com

{CAUTION
If you use bias-ply tires on
the vehicle, the wheel rim
anges could develop cracks
after many miles of driving.
A tire and/or wheel could fail
suddenly, causing a crash.
Use only radial-ply tires with
the wheels on the vehicle.
If you must replace your vehicle’s
tires with those that do not have
a TPC Spec number, make sure
they are the same size, load range,
speed rating, and construction type
(radial and bias-belted tires) as
your vehicle’s original tires.
Vehicles that have a tire pressure
monitoring system could give
an inaccurate low-pressure warning
if non-TPC Spec rated tires are
installed on your vehicle. Non-TPC
Spec rated tires may give a
low-pressure warning that is higher
or lower than the proper warninglevel you would get with TPC Spec
rated tires. SeeTire Pressure
Monitor System on page 9-48.
Your vehicle’s original equipment
tires are listed on the Tire and
Loading Information Label. See
Loading the Vehicle on page 8-30,
for more information about the
Tire and Loading Information Label
and its location on your vehicle.Different Size Tires
and Wheels
If you add wheels or tires that are
a different size than your original
equipment wheels and tires,
this may affect the way your vehicle
performs, including its braking,
ride and handling characteristics,
stability, and resistance to rollover.
Additionally, if your vehicle has
electronic systems such as, anti-lock
brakes, traction control, and
stability control, the performance of
these systems can be affected.
{CAUTION
If you add different sized
wheels, your vehicle may not
provide an acceptable level of
performance and safety if tires
not recommended for those
wheels are selected. You may
increase the chance that you
will crash and suffer serious
injury. Only use Saturn specic
wheel and tire systems
developed for your vehicle, and
have them properly installed by
a Saturn certied technician.
SeeBuying New Tires on page 9-54
andAccessories and Modifications
on page 9-3for additional
information.
Vehicle Service and Care 9-55
ProCarManuals.com

Event Data Recorders
This vehicle has an Event
Data Recorder (EDR). The main
purpose of an EDR is to record, in
certain crash or near crash-like
situations, such as an airbag
deployment or hitting a road
obstacle, data that will assist in
understanding how a vehicle’s
systems performed. The EDR is
designed to record data related
to vehicle dynamics and safety
systems for a short period of time,
typically 30 seconds or less.The EDR in this vehicle is designed
to record such data as:How various systems in your
vehicle were operating
Whether or not the driver and
passenger safety belts were
buckled/fastened
How far, if at all, the driver was
pressing the accelerator and/or
brake pedal
How fast the vehicle was
traveling
This data can help provide a better
understanding of the circumstances
in which crashes and injuries occur.Important:EDR data is recorded
by your vehicle only if a non-trivial
crash situation occurs; no data is
recorded by the EDR under normal
driving conditions and no personal
data (e.g., name, gender, age,
and crash location) is recorded.
However, other parties, such as law
enforcement, could combine the
EDR data with the type of personally
identifying data routinely acquired
during a crash investigation.
To read data recorded by an EDR,
special equipment is required,
and access to the vehicle or the
EDR is needed. In addition to
the vehicle manufacturer, other
parties, such as law enforcement,
that have the special equipment, can
read the information if they have
access to the vehicle or the EDR.
11-16 Customer Information
ProCarManuals.com

C
California Fuel.....................8-35
California Perchlorate
Materials Requirements....... 9-3
California Proposition 65
Warning............................ 9-3
Canadian Owners..................... ii
Capacities and
Specications...................10-2
Carbon Monoxide.........8-14, 8-27
Care, Safety Belts................1-22
Cargo Cover......................... 3-1
Cargo Tie Downs................... 3-1
Cautions and Notices............... iii
Chains, Tire........................9-59
Charging System Light..........4-17
Check
Engine Light....................4-20
Chemical Paint Spotting........9-79
Child Restraints
Child Restraint Systems.....1-41
Infants and Young
Children.......................1-38
Lower Anchors and
Tethers for Children.......1-45Child Restraints (cont.)
Older Children..................1-37
Securing..................1-50, 1-53
Where to Put the
Restraint......................1-43
Cleaning
Exterior...........................9-75
Interior............................9-72
Underbody Maintenance....9-79
Climate Control System.......... 7-1
Outlet Adjustment............... 7-4
Clutch, Hydraulic..................9-12
Collision Damage Repair.....11-10
Compact Spare Tire.............9-67
Content Theft-Deterrent.......... 2-9
Control of a Vehicle..............8-17
Coolant
Engine............................9-12
Engine Temperature
Warning Light...............4-19
Cooling System...................
9-16
Cruise Control....................... 4-5
Cruise Control Light..............4-24
Cupholders........................... 3-1Customer Assistance
Information
Courtesy
Transportation.......11-4, 11-8
Customer Assistance
Offices.........................11-5
Customer Satisfaction
Procedure....................11-1
GM Mobility
Reimbursement
Program.......................11-5
Reporting Safety
Defects to
Saturn........................11-14
Reporting Safety
Defects to the
Canadian
Government................11-14
Reporting Safety Defects
to the United States
Government................11-13
Roadside Assistance
Program.......................11-5
Service Publications
Ordering Information.....11-14
i-2 INDEX
ProCarManuals.com

D
Daytime Running Lamps......... 5-2
Defensive Driving.................8-16
Delayed Headlamps............... 5-2
Doing Your Own
Service Work..................... 9-4
Dome Lamps ........................ 5-3
Door
Ajar Light........................4-24
Locks............................... 2-5
Power Door Locks.............. 2-5
Rear Door Security Locks.... 2-6
Driver Information
Center (DIC)....................4-26
DIC Operation and
Displays...............4-27, 4-31
DIC Warnings and
Messages....................4-37
Driving
At Night..........................8-24
Before a Long Trip............8-26
Defensive........................8-16
Drunken..........................8-16
Highway Hypnosis............8-26Driving (cont.)
Hill and Mountain Roads....8-26
In Rain and on Wet
Roads.........................8-25
Rocking Your Vehicle to
Get it Out ....................8-30
Winter.............................8-27
Winter Mode Light............4-23
E
EDR .................................11-15
Electrical System
Add-On Equipment............9-33
Engine Compartment
Fuse Block...................9-34
Fuses.............................9-34
Headlamp Wiring..............9-33
Power Windows and
Other Power
Options........................9-34
Rear Compartment Fuse
Block...........................9-36
Windshield Wiper Fuses....9-34Engine
Air Cleaner/Filter...............9-11
Check and Service
Engine Soon
Light............................4-20
Coolant...........................9-12
Coolant Temperature
Warning Light...............4-19
Engine Compartment
Overview....................... 9-6
Exhaust...........................8-14
Oil ................................... 9-7
Oil Life System.................. 9-9
Overheating.....................9-15
Starting............................. 8-3
Engine Heater....................... 8-4
Entry Lighting........................ 5-3
Event Data Recorders.........11-16
Extender, Safety Belt............1-22
Exterior Lamps...................... 5-1
Exterior Lamps Off
Reminder........................4-24
INDEX i-3
ProCarManuals.com

Hood
Release............................ 9-5
Horn .................................... 4-4
How to Wear Safety Belts
Properly..........................1-12
Hydraulic Clutch...................9-12
I
Ignition Positions................... 8-2
Immobilizer........................... 2-7
Immobilizer Operation............. 2-8
Infants and Young
Children, Restraints...........1-38
Ination - Tire Pressure.........9-46
Instrument Panel
Brightness......................... 5-3
Cluster............................4-12
Overview........................... 4-2
J
Jump Starting......................9-68
K
Keyless Entry System............ 2-3
Keys.................................... 2-2
L
Labeling, Tire Sidewall..........9-40
Lamp
Rear Compartment............. 5-4
Lamps
Dome ............................... 5-3
Exterior, Off Reminder.......4-24
Reading............................ 5-3
Lap-Shoulder Belt................1-17
LATCH System
Child Restraints................1-45
Replacing Parts After a
Crash..........................1-50
License Plate Lamps............9-32
Liftgate
Carbon Monoxide............... 2-6
Light
Airbag Readiness.............4-14
Anti-lock Brake System
(ABS) Warning..............4-18Light (cont.)
Brake System Warning......4-17
Charging System..............4-17
Cruise Control..................4-24
Door Ajar.........................4-24
Engine Coolant
Temperature Warning.....4-19
Fog Lamp ........................4-23
Highbeam On...................4-24
Low Fuel Warning.............4-25
Low Oil Level...................4-23
Malfunction Indicator.........4-20
Oil Pressure.....................4-22
Passenger Airbag Status
Indicator.......................4-15
Safety Belt Reminders.......4-14
Service Vehicle Soon........4-24
StabiliTrak
®Indicator.........4-19
Tire Pressure...................4-19
Winter Driving Mode..........4-23
Lighting
Entry................................ 5-3
Lights
Exterior Lamps................... 5-1
Flash-to-Pass..................... 4-8
High/Low Beam Changer..... 4-8
INDEX i-5
ProCarManuals.com

Power (cont.)
Steering Fluid...................9-20
Windows.........................2-10
Pressure Cap......................9-15
Privacy.............................11-15
Event Data Recorders.....11-16
Navigation System..........11-17
OnStar ..........................11-17
Radio Frequency
Identication................11-17
R
Radio Frequency
Identication (RFID),
Privacy..........................11-17
Radio(s)............................... 6-2
Radios
Reception........................6-25
Theft-Deterrent.................6-24
Reading Lamps..................... 5-3
Rear Compartment Lamp........ 5-4
Rear Door Security Locks....... 2-6Rear Heated Seats................ 1-6
Rear Seat Operation.............. 1-7
Rear Windshield Washer/
Wiper..............................4-10
Rearview Mirrors..................2-12
Reclining Seatbacks............... 1-3
Recreational Vehicle
Towing ............................9-72
Remote Keyless Entry
(RKE) System.................... 2-3
Remote Keyless Entry
(RKE) System,
Operation.......................... 2-4
Removing the Flat Tire
and Installing the
Spare Tire.......................9-62
Removing the Spare Tire
and Tools........................9-61
Replacement Bulbs..............9-33
Replacing LATCH
System Parts After
a Crash...........................1-50Reporting Safety Defects
Canadian Government.....11-14
Saturn...........................11-14
United States
Government................11-13
Restraint System Check
Replacing Airbag System
Parts After a Crash........1-36
Replacing Safety Belt
System Parts After
a Crash.......................1-23
Retained Accessory
Power (RAP) ..................... 8-3
Roadside
Assistance Program..........11-5
Rocking Your Vehicle
to Get it Out ....................8-30
Running the Vehicle
While Parked...................8-14
INDEX i-7
ProCarManuals.com