2008 MITSUBISHI SHOGUN coolant level

6-8 For emergencies
6
5. Check the coolant level in the reserve tank (A). 6. Add
coolant to the radiator and/or reserve tank if neces-
sary. (Refer to the “Maintenance” section.)
7. Examine the radiator hoses
for coolant leakage and the
drive belt for looseness or damage. If there is anything wrong with the cooling system ordrive belt, we recommend you to have it check and repaired.
WARNING
!●
If there is none, make sure that the engine has cooled down before removi
ng the radiator cap (B),
because hot steam or boiling water otherwise will gush from the filler port and may scald you.
CAUTION
!●
Do not add coolant while the engine is hot. Suddenly adding cold coolant coul
d damage the engine. Wait
for the engine to cool down
, then add coolant a little
at a time.
BK-BK2008E1ENUK.en-uk-Section9.fm Page 8 Wednesday, January 9, 2008 4:46 PM

8-10 Maintenance
8
Engine coolant
E01000501042
To check the coolant levelA translucent coolant reserve tank
is located in the engine com-
partment. The coolant level in this tank should be kept between the“LOW” and “FULL” marks when measured while the engine is cold.
To add coolantThe cooling system is a closed
system and normally the loss of
coolant should be very slight.
A noticeable drop in the coolant
level could indicate leakage. If
this occurs, we recommend you
to have the system checked as soon as possible. If the level should drop below th
e “LOW” level on the reserve
tank, open the lid
and add coolant.
Also, if the reserve tank is completely empty, remove the radia- tor cap and add coolant until the
level reaches the filler neck.
Anti-freezeThe engine coolant contains an ethylene glycol anti-corrosion agent. The cylinder head and
water pump housing are cast alu-
minium alloy, and periodic changing of the engine coolant is necessary to prevent corrosion of these parts. Use “DIA QUEEN SUPER LONG LIFE COOLANT” or equivalent.MITSUBISHI Genuine Coolan
t has excellent protection
against corrosion and rust form
ation of all metals including
aluminium and can avoid blockages in the radiator, heater, cyl-inder head, engine block, etc.
WARNING
!●
Do not open the radiator ca
p while the engine is hot.
The coolant system is u
nder pressure and any hot
coolant escaping coul
d cause severe burns.
BK-BK2008E1ENUK.en-uk-Section11.fm Page
10 Wednesday, January 9, 2008 4:50 PM

Maintenance
8-11
8
Because of the necessity of this
anti-corrosion agent, the cool-
ant must not be replaced with
plain water even in summer. The
required concentration of anti
-freeze differs depending on the
expected ambient temperature.During cold weatherThe engine coolant mixture used
at the factory provides protec-
tion against freezing for temperat
ures as low as approximately
-30 °C. The concentration should
be checked before the start of
cold weather and anti-freeze adde
d to the system if necessary
to prevent damage to engine
and radiator due to freezing.
Wa s h e r f l u i d
E01000700412
Windscreen washer fluidThe windshield washer fluid reservoir is in the engine compart- ment. Check the washer fluid level
at regular intervals and add
washer fluid to reservoir if necessary.NOTE●
The washer fluid container
serves the windscreen and
headlamps (if so equipped).
Ambient temperature
(minimum) °C
-15 -20 -25 -30 -35 -50
Anti-freeze concentra-
tion %
30 35 40 45 50 60
CAUTION
!●
Do not use alcohol or me
thanol anti-freeze or any
engine coolants mixed with alcohol or methanolanti-freeze. The use of an improper anti-freeze can cause corrosion of the
aluminium components.
●
For effective anti-corro
sion and anti-freeze per-
formance, keep the anti-f
reeze concentration within
the range of 30 to 60 %. Concentrations
exceeding 60 % will result in a
reduction of both the an
ti-freeze and cooling per-
formance thus adversely
affecting the engine.
●
Do not top up with water only.
BK-BK2008E1ENUK.en-uk-Section11.fm Page
11 Wednesday, January 9, 2008 4:50 PM

Alphabetical index
3
Exterior and interior lamp operation 8-27
F
Fluid Automatic transmission fluid 9-16Brake fluid 8-13, 9-16Clutch fluid 8-14, 9-16Engine coolant 8-10, 9-16Manual transmission fluid 9-16Power steering fluid 8-16, 9-16Washer fluid 8-11, 9-16Fog lamp switch 3-66Foot lamps and ceiling lamp 5-89For cold and snowy weather 8-28Front automatic air conditioning 5-4Front fog lampsBulb capacity 8-36Indication lamp 3-12Replacement 8-42Switch 3-66Front seats 2-6Front turn-signal lampsBulb capacity 8-36Replacement 8-41FuelFilling the fuel tank 3Fuel filter indication lamp 3-13Fuel gauge 3-7Fuel selection 2
Low fuel warning lamp 3-8 Modification/alterations to th
e electrical or fuel systems 7
Tank capacity 3Fuel consumption 9-14Fuses 8-29Fusible links 8-29
G
Gauges 3-2, 3-10General maintenance 8-27General vehicle data 9-4Genuine parts 7Glove box 5-93Glove box lampBulb capacity 8-38Replacement 8-55
H
Handling of compact discs 5-74Hazard warning flasher switch 3-66Hazard warning indication lamps 3-12Head restraints 2-16Headlamp levelling 3-62Headlamp washer switch 3-76HeadlampsBulb capacity 8-36Headlamp flasher 3-61Replacement 8-38Switch 3-58
BK-BK2008E1ENUK.en-ukIX.fm Page 3 Thursday, January 10, 2008 7:53 AM