2008 Mercury Mariner Hybrid automatic transmission fluid

Note:The brake system on this vehicle can only be bled at a authorized
dealer.
TRANSMISSION FLUID
Checking electronically controlled continuously variable
transmission (eCVT)
Refer to yourscheduled maintenance informationchapter for
scheduled intervals for fluid checks and changes. Your transaxle does not
consume fluid. It is designed to be filled for life. However, the fluid level
should be checked if you notice some sign of fluid leakage.
Automatic transmission fluid expands when warmed. To obtain an
accurate fluid check, drive the vehicle until it is warmed up
(approximately 20 miles [30 km]). If your vehicle has been
operated for an extended period at high speeds, in city traffic
during hot weather or pulling a trailer, the vehicle should be
turned off for about 30 minutes to allow fluid to cool before
checking.
1. Drive the vehicle 20 miles (30 km) or until it reaches normal operating
temperature.
2. Park the vehicle on a level surface and engage the parking brake.
3. With the parking brake engaged
and your foot on the brake pedal,
turn the key to the ACCESSORY
position but do not start the engine.
Turn the wheel to the left to gain
access to the check plug.
4. Latch the gearshift lever in P (Park) and make sure that the engine is
OFF by placing the ignition in the Lock position.
2008 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
279

Item CapacityFord Part Name or
equivalentFord Part Number /
Ford Specification
Automatic eCVT
transaxle fluid5.3 quarts (5.0L)
3
Motorcraft MERCONV
AT F
4
XT-5-QM /
MERCONV
Rear axle fluid (4WD) 2.96 pints (1.4L)
5
Motorcraft SAE 80W-90
Premium Rear Axle
Lubricant
6
XY-80W90-QL /
WSP-M2C197-A
Power Transfer Unit
fluid (4WD)
7
12 ounces (0.35L)Motorcraft SAE 75W-140
Rear Axle LubricantXY-75W140-QL /
WSL-M2C192-A
Windshield washer fluid 2.7 quarts (2.6L)Motorcraft Premium
Windshield Washer
ConcentrateZC-32-A /
WSB-M8B16-A2
Fuel tank 15 gallons (56.8L) — —
1Add the coolant type originally equipped in your vehicle. Refer toAdding engine coolantin this
chapter.2Use of synthetic or synthetic blend motor oil is not mandatory. Engine oil need only meet the
requirements of Ford specification WSS-M2C930-A and the API Certification mark.3Indicates only approximate dry-fill capacity.4Using any transmission fluid other than those that meet the recommended specification may cause
internal transaxle damage. Do not use Motorcraft MERCONCVT (blue) ATF. This vehicle uses
only Motorcraft MERCONVATF5Fill to 1/4 inch to 9/16 inch (6 mm to 14 mm) below bottom of fill hole.64WD vehicles exposed for prolonged periods to temperatures less than -40° C (-40° F) should
change out the rear axle fluid to Motorcraft SAE 75W-140 Rear Axle Lubricant, Ford part number
XY-75W140-QL meeting Ford specification WSL-M2C192-A.7The Power Transfer Unit is lubricated for life with synthetic lube. Lubricant levels are not to be
checked or changed unless a leak is suspected or repair required. Replace Power Transfer Unit
lubricant with specified synthetic lubricant anytime the unit is submerged in water.
2008 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
286

A
Accessory delay ..........................62
Air cleaner filter ...............281–284
Air conditioning
automatic temperature
control system ..........................39
Airbag supplemental restraint
system ........................123, 132, 135
and child safety seats ............125
description ..............123, 132, 135
disposal ....................................138
driver airbag ............125, 133, 136
indicator light .........132, 134, 137
operation .................125, 133, 136
passenger airbag .....125, 133, 136
side airbag ...............................132
All Wheel Drive (AWD),
driving off road .........................198
Ambulance packages ..................15
Anti-lock brake system
(see Brakes) ..............................188
Anti-theft system ........................96
Audio system (see Radio) .........25
Automatic transaxle
fluid, adding ............................279
fluid, checking ........................279
Automatic transmission
driving an automatic
overdrive .................................194
fluid, refill capacities ..............285
fluid, specification ..................285
Auxiliary input jack (Line in) ....32
Auxiliary power point .................58
Axle
lubricant specifications ..........285
refill capacities ........................285B
Battery .......................................259
acid, treating emergencies .....259
jumping a disabled
battery .............................227, 232
maintenance-free ....................259
replacement, specifications ...284
servicing ..................................259
Belt-Minder.............................118
Booster seats .............................139
Brakes ................................187–188
anti-lock ...................................188
anti-lock brake system (ABS)
warning light ...........................189
fluid, checking and adding ....278
fluid, refill capacities ..............285
fluid, specifications .................285
lubricant specifications ..........285
parking ....................................190
shift interlock ..........................192
Bulbs ............................................50
C
Capacities for refilling fluids ....285
Cargo area shade ........................79
Cell phone use ............................15
Child safety restraints ..............138
child safety belts ....................138
Child safety seats ......................142
attaching with tether straps ..146
in front seat ............................143
in rear seat ..............................143
Child safety seats - booster
seats ...........................................139
Cleaning your vehicle
engine compartment ..............245
instrument panel ....................247
2008 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Index
309

interior .....................................247
plastic parts ............................246
washing ....................................243
waxing .....................................244
wheels ......................................244
wiper blades ............................246
Climate control (see Air
conditioning or Heating) ............39
Compass, electronic ....................63
calibration .................................64
set zone adjustment .................63
Console ........................................57
Controls
power seat ...............................102
steering column ........................68
Coolant
checking and adding ......261–263
refill capacities ................266, 285
specifications ..........................285
Cruise control
(see Speed control) ....................65
Customer Assistance ................205
Ford Extended Service
Plan ..........................................239
Getting assistance outside the
U.S. and Canada .....................240
Getting roadside assistance ...205
Getting the service you
need .........................................235
Ordering additional owner’s
literature .................................241
Utilizing the
Mediation/Arbitration
Program ...................................239
D
Daytime running lamps
(see Lamps) ................................46Dipstick
automatic transmission
fluid ..........................................279
engine oil .................................256
Driving under special
conditions ..................195, 199, 202
sand .........................................200
snow and ice ...........................202
through water .................201, 204
E
Electronic message center .........70
Emergencies, roadside
jump-starting ..................227, 232
Emission control system ..........275
Engine ........................................287
cleaning ...................................245
idle speed control ...................259
lubrication specifications .......285
refill capacities ........................285
service points ..........................253
Engine block heater .................187
Engine oil ..................................256
checking and adding ..............256
dipstick ....................................256
filter, specifications ........258, 284
recommendations ...................258
refill capacities ........................285
specifications ..........................285
Event data recording ..................14
Exhaust fumes ..........................187
F
Fluid capacities .........................285
Foglamps .....................................45
Four-Wheel Drive vehicles
driving off road .......................198
2008 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Index
310

L
Lamps
bulb replacement
specifications chart ..................50
daytime running light ...............46
fog lamps ...................................45
headlamps .................................44
headlamps, flash to pass ..........46
instrument panel, dimming .....47
interior lamps ...............48–49, 51
replacing bulbs .........................51
Lane change indicator
(see Turn signal) ........................48
Liftgate ..................................78, 91
Lights, warning and indicator ....18
anti-lock brakes (ABS) ..........189
Load limits .................................172
Loading instructions .................178
Locks
autolock ...............................85, 87
childproof ..................................89
doors ..........................................85
Lubricant specifications ...........285
Lug nuts ....................................226
Luggage rack ...............................80
M
Manual transmission
fluid capacities ........................285
lubricant specifications ..........285
Message center ...........................70
english/metric button ...............74
system check button ................73
warning messages .....................75Mirrors ...................................62, 65
automatic dimming rearview
mirror ........................................62
fold away ...................................65
heated ........................................65
side view mirrors (power) .......65
Moon roof ....................................69
Motorcraft parts ........249, 267, 284
N
Navigation system .......................38
O
Octane rating ............................271
Oil (see Engine oil) ..................256
P
Parking brake ............................190
Parts (see Motorcraft parts) ....284
Passenger Occupant
Classification Sensor .................110
Power distribution box
(see Fuses) ...............................212
Power door locks ........................85
Power mirrors .............................65
Power point .................................58
Power steering ..........................191
Power Windows ...........................61
Preparing to drive your
vehicle ........................................192
R
Radio ............................................25
Relays ........................................209
2008 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Index
312

replacing ..................................158
rotating ....................................161
safety practices .......................160
sidewall information ...............162
snow tires and chains ............172
spare tire .........................216, 218
terminology .............................154
tire grades ...............................153
treadwear ........................153, 157
Towing .......................................178
recreational towing .................183
trailer towing ..........................178
wrecker ....................................234
Transmission .............................192
brake-shift interlock (BSI) ....192
fluid, checking and adding
(automatic) .............................279
fluid, refill capacities ..............285
lubricant specifications ..........285
Trunk ...........................................91
Turn signal ..................................48V
Vehicle Identification Number
(VIN) ..........................................288
Vehicle loading ..........................172
Ventilating your vehicle ...........187
W
Warning lights (see Lights) .......18
Washer fluid ..............................254
Water, Driving through .............204
Windows
power .........................................61
rear wiper/washer .....................56
Windshield washer fluid and
wipers ..........................................55
checking and adding fluid .....254
liftgate reservoir .....................254
replacing wiper blades ...255–256
Wrecker towing .........................234
2008 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Index
314