2008 MERCEDES-BENZ CLK63AMG octane

13 Introduction
Operator’s Manual
Operating your vehicle outside the USA
or Canada
If you plan to operate your vehicle in for-
eign countries, please be aware that:

service facilities or replacement parts
may not be readily available,

unleaded gasoline for vehicles with cat-
alytic converters may not be available;
the use of leaded fuels will damage the
catalysts,

gasoline may have a considerably low-
er octane rating, and improper fuel can
cause engine damage.Certain Mercedes-Benz models are avail-
able for delivery in Europe under our Euro-
pean Delivery Program. For details, consult
an authorized Mercedes-Benz Center or
write to:
In the USA:
Mercedes-Benz USA, LLC
European Delivery Department
One Mercedes Drive
Montvale, NJ 07645-0350
In Canada:
Mercedes-Benz Canada Inc.
European Delivery Department
98 Vanderhoof Avenue
Toronto, Ontario M4G 4C9

321 Operation
At the gas station
Take off the fuel cap and set it in the di-
rection of arrow 2 in the recess on the
fuel filler flap.
To prevent fuel vapors from escaping
into open air, fully insert the filler noz-
zle unit.
Only fill your tank until the filler nozzle
unit cuts out – do not top off or
overfill.
Replace the fuel cap by turning it
clockwise until it audibly engages.
Close the fuel filler flap.
Warning!G
Overfilling of the fuel tank may create
pressure in the system which could cause a
gas discharge. This could cause the gas to
spray back out when removing the fuel
pump nozzle, which could cause personal
injury.
iMake sure to close the fuel filler flap before
locking your vehicle as the flap locking pin
prevents closing after you have locked the
vehicle.
iOnly use premium unleaded gasoline with a
minimum Posted Octane Rating of 91 (average
of 96 RON / 86 MON).
Information on gasoline quality can normally be
found on the fuel pump. Please contact gas sta-
tion personnel in case labels on the pump cannot
be found.
For more information on gasoline, see “Premium
unleaded gasoline” (
page 492), or the Factory
Approved Service Products pamphlet (USA only),
or contact an authorized Mercedes-Benz Center.
iLeaving the engine running and the fuel cap
open can cause theú malfunction indicator
lamp (USA only) or the± malfunction indica-
tor lamp (Canada only) to illuminate.
More information can be found in the “Practical
hints” section (
page 381).

481 Technical data
Engine
Engine
Model Coupe
CabrioletCLK 350 (209.356)1
CLK 350 (209.456)1
1The quoted data apply only to the standard vehicle. See an authorized Mercedes-Benz Center for the corresponding data of all special bodies and special equipment.
CLK 550 (209.372)1
CLK 550 (209.472)1CLK 63 AMG (209.477)1
Engine272273156
Mode of operation4-stroke engine,
gasoline injection4-stroke engine,
gasoline injection4-stroke engine,
gasoline injection
No. of cylinders688
Bore3.66 in (92.90 mm)3.85 in (98.00 mm)4.02 in (102.20 mm)
Stroke3.39 in (86.00 mm)3.56 in (90.50 mm)3.72 in (94.60 mm)
Total piston displacement213.5 cu in (3 498 cm3)333.25 cu in (5 461 cm3)378.8 cu in (6 208 cm3)
Compression ratio10.5:110.5:111.3:1
Output acc. to SAE J 1349268 hp / 6 000 rpm2
(200 kW / 6 000 rpm)
2Premium fuel required. Performance may vary with fuel octane rating.
382 hp / 6 000 rpm2
(285 kW / 6 000 rpm)
475 hp / 6 800 rpm2
(354 kW / 6 800 rpm)
Maximum torque acc. to SAE J
1349258 lb-ft/ 2 400 - 5 000 rpm
(350 Nm / 2 400 - 5 000 rpm)391 lb-ft / 2 800 - 4 800 rpm
(530 Nm /2 800 - 4 800 rpm)465 lb-ft / 5 000 rpm
(630 Nm / 5 000 rpm)
Maximum engine speed6300 rpm6500 rpm7200 rpm
Firing order1-4-3-6-2-51-5-4-2-6-3-7-81-5-4-2-6-3-7-8
Poly-V-belt2404 mm2404 mm (CLK coupe)
2 380 mm (CLK cabriolet)2360 mm

490 Technical data
Fuels, coolants, lubricants, etc.
ModelCapacityFuels, coolants, lubricants, etc.
Power steeringCLK 350
CLK 550
CLK 63 AMGapprox. 1.1 US qt (1.0 l)
approx. 1.1 US qt (1.0 l)
approx. 1.3 US qt (1.2 l)MB Power Steering Fluid
(Pentosin CHF 11S)
Front wheel hubsCLK 350
CLK 550
CLK 63 AMGapprox. 3.0 oz (85 g) each
approx. 3.0 oz (85 g) each
approx. 2.5 oz (70 g) eachHigh temperature roller bearing grease
Brake system0.64 US qt (0.6 l)MB Brake Fluid (DOT 4+)
Cooling systemCLK 350
CLK 550
CLK 63 AMGapprox. 7.8 US qt (7.4 l)
approx. 9.7 US qt (9.2 l)
approx. 11.5 US qt (10.9 l)MB 325.0 Anticorrosion/Antifreeze
Agent
Fuel tank
including a reserve of
CLK 350
CLK 550
CLK 63 AMG
16.35 US gal (62.0 l)
2.11 US gal (8.0 l)
2.11 US gal (8.0 l)
3.17 US gal (12.0 l)Premium unleaded gasoline:
Minimum Posted Octane 91
(Avg. of 96 RON / 86 MON)
Air conditioning systemR-134a refrigerant and special PAG lu-
bricant oil (never R-12)
Windshield washer system
Heated windshield washer system and
headlamp cleaning system*3.2 US qt (3.0 l)
6.4 US qt (6.0 l)MB Windshield Washer Concentrate1
1Use MB Windshield Washer Concentrate “MB SummerFit” and water for temperatures above freezing point or MB Windshield Washer Concentrate “MB SummerFit”
and commercially available premixed windshield washer solvent / antifreeze for temperatures below freezing point. Follow suggested mixing ratios (page 496).

492 Technical data
Fuels, coolants, lubricants, etc.
Premium unleaded gasolineFuel requirements
Only use premium unleaded fuel:

The octane number (posted at the
pump) must be 91 min. It is an average
of both the Research Octane Number
(RON) and the Motor Octane Number
(MON): (RON+MON)/2. This is also
known as the ANTI-KNOCK INDEX.
Unleaded gasoline containing oxygenates
such as ethanol, IPA, IBA and TBA can be
used provided the ratio of any one of these
oxygenates to gasoline does not
exceed 10%; MTBE not to exceed 15%.
The ratio of methanol to gasoline must not
exceed 3% plus additional co-solvents.
Using mixtures of ethanol and methanol is
not allowed. Gasohol, which contains
10% ethanol and 90% unleaded gasoline,
can be used.
These blends must also meet all other fuel
requirements, such as resistance to spark
knock, boiling range, vapor pressure, etc.Warning!G
Gasoline is highly flammable and poisonous.
It burns violently and can cause serious
personal injury.
Never allow sparks, flame or smoking mate-
rials near gasoline!
Turn off the engine before refueling
Whenever you are around gasoline, avoid in-
haling fumes and skin or clothing contact,
extinguish all smoking materials.
Direct skin contact with fuels and the inha-
lation of fuel vapors can damage your
health.
!To maintain the engine’s durability and per-
formance, premium unleaded gasoline must be
used. If premium unleaded gasoline is not avail-
able and low octane fuel is used, follow these
precautions:

Have the fuel tank only partially filled with
unleaded regular gasoline and fill up with
premium unleaded gasoline as soon as
possible.

Avoid full throttle driving and abrupt
acceleration.

Do not exceed an engine speed of 3 000 rpm
if the vehicle is loaded with a light load such
as two persons and no luggage.

Do not exceed 2/3 of maximum accelerator
pedal position if the vehicle is fully loaded or
operating in mountainous terrain.

503 Index
F
Filler cap, Engine oil 327
Filler neck, Engine oil 327
First aid kit 421
Flat tire 452
Jacking up the vehicle 459
Lowering the vehicle 462
Minispare wheel 425
Mounting the spare wheel 458
Preparing the vehicle 452
TIREFIT (CLK 63 AMG only) 422
TIREFIT kit* 452
Floormats* 291
Fluids
Brake fluid 322, 491
Engine coolant 322, 494
Engine oil 322, 491
Windshield washer and headlamp
cleaning* system 322, 496
Fog lamps 132, 444
Messages in display 412
Replacing bulbs 444, 445, 448
Front air bags 70
Front lamps see Headlamps
Front passenger front air bag 65, 70
Messages in display 396–399Front passenger front air bag
off indicator lamp 31, 76, 390
Front seat head restraints
see Head restraints
Fuel 321, 489
Additives 493
Automatic transmission fluid 489
Brake fluid 490
Capacities 489
Capacities, Fuel tank 490
Engine coolant 490
Engine oil 489
Filling the tank 320
Fuel display 29
Fuel filler flap and cap 320
Fuel filler flap and cap, Multifunction
display messages 408
Fuel reserve warning lamp 385
Power steering fluid 490
Premium
unleaded gasoline 321, 490, 492
Requirements, Octane rating 492
Technical data 489
Fuel cap
Message in display 382Fuel consumption statistics
After start 167
Resetting 168
Since last reset 168
Fuel filler flap 320
Locking/unlocking 320
Opening 320
Fuel reserve warning lamp 29
Fuel tank
Capacity 490
Filler flap 320
Fuel, Premium
unleaded gasoline 321, 492
Fuels, coolants, lubricants etc.
Capacities 489
Fuses 472
Fuse box (main)
in passenger compartment 472
Fuse box
in engine compartment 473
Fuse box
in trunk 474
Replacing 472

508 Index
Mirrors
Adjusting 47
Antiglare position 185
Auto-dimming 186
Exterior rear view mirrors 47
Interior rear view mirror 47
Mobile phone see Telephone*
MOE tires* see MOExtended system*
MOE* see MOExtended system*
MOExtended system* 463
MOExtended tires* 482
MON 321
Motor Octane Number see MON
MP3 230
Multicontour seat* see
Seats, Multicontour*
Multifunction display 141
Changing settings see
Control system menus and
Control system submenus
Selecting language 158
Symbol messages 403–420
Text messages 394–401Multifunction display messages 392
ABS 394
Battery 403
Brake fluid 404
Brake pads 404
Check engine 405
Coolant 405–407
Engine 405
Engine coolant 405–407
ESP
®394
Fog lamps 412
Front passenger
front air bag 396–399
Fuel cap 408
Gear selector lever 400
Headlamps 411–415
Key, SmartKey 411
KEYLESS-GO* 410
Lamps 413
Lamps, exterior 411–415
License plate lamp 413
Light sensor 411
Low tire pressure 419
Parking brake 404
Parking lamps 412
Roll bars 417Soft top 420
SRS 416
Steering gear oil 417
Tele Aid 418
Telephone* 418
Turn signals 412
Windshield washer fluid 420
Multifunction steering wheel 30, 142
Button operation 142
N
Navigation system* 153
See separate COMAND*
operating instructions
Net, Parcel 286
Neutral gear position,
Automatic transmission 172, 174
New vehicle break-in 308
Night security illumination 132
Normal occupant weight 359
Number, paintwork code 478
Number,
vehicle identification (VIN) 478, 479

511 Index
Recommended
tire inflation pressure 359
Recovery services,
Stolen vehicle (Tele Aid) 301
Refrigerant, Air conditioning 491
Refueling 320
Regular checks 322
Remote control
SmartKey 100, 103
SmartKey with KEYLESS-GO* 103
Remote door unlock (Tele Aid) 300
Removing
Ski bag* (Canada only) 280
Replacing bulbs 443
Additional turn signals 444
Backup lamps 444, 448
Brake lamps 444
Corner-illuminating
front fog lamp* 444
Fog lamps 444, 448
Headlamp bulbs 446
Headlamps 444
High beam flasher (Bi-Xenon*) 444
High beam flasher (Halogen) 444
High beam headlamps
(Bi-Xenon*) 444High beam headlamps
(Halogen) 444, 446
High mounted brake lamp 444
License plate lamps 444, 449
Low beam headlamps
(Bi-Xenon*) 444
Low beam headlamps
(Halogen) 444, 446
Parking lamps 444, 447, 448
Side marker lamps 444
Standing lamps 444, 447, 448
Tail lamps 444, 448
Turn signal lamps 444, 448
Turn signal lamps (Bi-Xenon*) 448
Turn signal lamps (Halogen) 447
Reporting safety defects 18
Research Octane Number see RON
Reset button,
In instrument cluster 29, 138, 156
Residual heat and ventilation* see REST*
REST* 211
Restraint system see
Children in the vehicle
Restraint system see SRS
Reverse gear position,
Automatic transmission 172, 174Rims 359, 482
Roadside Assistance 12, 298
Roll bar 82
Messages in display 417
Operating manually 430
Warning lamp 385
RON 321
Roof rack 275
Rubber parts, cleaning 374
Run Flat Indicator (Canada only) 342