2008 Lexus ES350 boot
[x] Cancel search: bootPage 64 of 82
SCHEDULED MAINTENANCE LOG
MAINTENANCE
150 Months or 125,000 Miles
❏Replace engine oil and oil filter; reset
reminder light
❏ Rotate tires
1
❏Visually inspect brake pads and rotors
❏ Road-test vehicle
Additional Maintenance Required
If You Drive Primarily Under the
Following Conditions
Driving on dirt roads or dusty roads:
❏ Inspect axle shaft boots
❏ Inspect ball joints and dust covers
❏ Inspect engine air filter
❏ Inspect steering linkage and boots
❏ Tighten nuts and bolts on chassis
Driving while towing:
❏ Tighten nuts and bolts on chassis (ES)
Date: _________ Mileage: _________
Notes:
156 Months or 130,000 Miles
❏ Replace engine oil and oil filter; reset
reminder light
❏ Rotate tires
1
❏Inspect engine coolant (see page 67)
❏ Measure thickness of brake pads and rotors
(GS, IS, LS
2)
❏ Replace air conditioner filter (LS, SC)
❏ Visually inspect brake pads and rotors
❏ Road-test vehicle
Additional Maintenance Required
If You Drive Primarily Under the
Following Conditions
Driving on dirt roads or dusty roads:
❏ Inspect axle shaft boots
❏ Inspect ball joints and dust covers
❏ Inspect engine air filter
❏ Inspect steering linkage and boots
❏ Tighten nuts and bolts on chassis
Driving while towing:
❏ Tighten nuts and bolts on chassis (ES)
Date: _________ Mileage: _________
Notes:
Scheduled Maintenance Log
62
1Applies to models with same size front and rear tires and wheels.2Applies to LS 460 L with Touring Package.
Lexus sedans-046_080.cgla 7/3/07 8:09 PM Page 62
Page 65 of 82
SCHEDULED MAINTENANCE LOG
MAINTENANCE
Scheduled Maintenance Log63
162 Months or 135,000 Miles
❏Replace engine oil and oil filter; reset reminder light
❏ Rotate tires
1
❏Clean air conditioner filter (ES, GS, IS)
❏ Visually inspect brake pads and rotors
❏ Road-test vehicle
❏ Inspect the following:
___Axle shaft boots
___Ball joints and dust covers
___Body
___Brake lines and hoses
___Drive belt
___Exhaust pipes and mountings
Additional Maintenance Required If You Drive Primarily Under the Following Conditions
Driving on dirt roads or dusty roads:
❏ Inspect engine air filter
❏ Tighten nuts and bolts on chassis
Driving while towing:
❏ Tighten nuts and bolts on chassis (ES)
___Front differential oil (GS 350 AWD,
IS 250 AWD)
___Rack and pinion assembly
___Rear differential oil (GS, IS, LS, SC)
___Steering linkage and boots
Date: _____________________________ Mileage: ____________________________
Notes:
Lexus sedans-046_080.cgla 7/3/07 8:10 PM Page 63
Page 66 of 82
SCHEDULED MAINTENANCE LOG
MAINTENANCE
168 Months or 140,000 Miles
❏Replace engine oil and oil filter; reset
reminder light
❏ Rotate tires
1
❏Measure thickness of brake pads and rotors
(GS, IS, LS2)
❏ Replace air conditioner filter (LS, SC)
❏ Visually inspect brake pads and rotors
❏ Road-test vehicle
Additional Maintenance Required
If You Drive Primarily Under the
Following Conditions
Driving on dirt roads or dusty roads:
❏ Inspect axle shaft boots
❏ Inspect ball joints and dust covers
❏ Inspect engine air filter
❏ Inspect steering linkage and boots
❏ Tighten nuts and bolts on chassis
Driving while towing:
❏ Tighten nuts and bolts on chassis (ES)
Date: _________ Mileage: _________
Notes:
174 Months or 145,000 Miles
❏ Replace engine oil and oil filter; reset
reminder light
❏ Rotate tires
1
❏Inspect engine coolant (see page 67)
❏ Visually inspect brake pads and rotors
❏ Road-test vehicle
Additional Maintenance Required
If You Drive Primarily Under the
Following Conditions
Driving on dirt roads or dusty roads:
❏ Inspect axle shaft boots
❏ Inspect ball joints and dust covers
❏ Inspect engine air filter
❏ Inspect steering linkage and boots
❏ Tighten nuts and bolts on chassis
Driving while towing:
❏ Tighten nuts and bolts on chassis (ES)
Date: _________ Mileage: _________
Notes:
Scheduled Maintenance Log
64
1Applies to models with same size front and rear tires and wheels.2Applies to LS 460 L with Touring Package.
Lexus sedans-046_080.cgla 7/3/07 8:44 PM Page 64
Page 67 of 82
SCHEDULED MAINTENANCE LOG
MAINTENANCE
Scheduled Maintenance Log65
180 Months or 150,000 Miles
❏Replace engine oil and oil filter; reset reminder light
❏ Rotate tires
1
❏Measure thickness of brake pads and rotors; measure rotor runout (GS, IS, LS2)
❏ Replace air conditioner filter
❏ Replace brake fluid
❏ Replace engine air filter
❏ Replace engine coolant (see page 67)
❏ Visually inspect brake pads and rotors
❏ Road-test vehicle
❏ Inspect the following:
___Axle shaft boots
___Ball joints and dust covers
___Body
___Brake lines and hoses
___Drive belt
___Exhaust pipes and mountings
___Front differential oil (GS 350 AWD, IS 250 AWD)
___Fuel lines and connections, fuel tank band
and fuel tank vapor vent system hoses
Additional Maintenance Required If You Drive Primarily Under the Following Conditions
Driving on dirt roads or dusty roads:
❏ Tighten nuts and bolts on chassis
Driving while towing:
❏ Tighten nuts and bolts on chassis (ES)
___Fuel tank cap gasket
___Manual transmission oil (IS 250)
___Rack and pinion assembly
___Rear differential oil (GS, IS, LS, SC)
___Steering linkage and boots
___Transfer case for signs of leakage
(GS 350 AWD, IS 250 AWD)
___Transmission for signs of leakage
Date: _____________________________ Mileage: ____________________________
Notes:
Lexus sedans-046_080.cgla 7/3/07 8:11 PM Page 65
Page 68 of 82
EXPLANATION OF MAINTENANCE ITEMS
MAINTENANCE
Scheduled Maintenance Log
66
The following descriptions are provid-
ed to give you a better understanding
of the maintenance services that
should be performed on your vehicle.
The scheduled maintenance log indi-
cates at which time/mileage intervals
each service should be performed.
Please note that many maintenance
services should be performed only
by a qualified technician.
Air Conditioner Filter
Clean or replace at specified inter-
vals. More frequent cleaning or
replacement may be required when
driving in dusty conditions.
Axle Shaft Boots
Check the axle shaft boots and
clamps for cracks, deterioration and
damage. Replace any damaged parts
and, if necessary, repack the grease.
A qualified technician should perform
these operations. Ball Joints and Dust Covers
Check the suspension and steering
linkage ball joints for looseness and
damage. Check all dust covers for
deterioration and damage. A qualified
technician should perform these
inspections.
Body Inspection
Visually check for corrosion, scratch-
es and other damage. Check outer
body panels, inner panels of the hood
and doors, and underneath the vehi-
cle. Apply touch-up paint to any chips
and scratches or have them repaired
by a qualified technician.
Brake Fluid
Replace using fluid type specified
in your
Owner’s Manual . A qualified
technician should perform this
operation.
Brake Lines and Hoses
Visually inspect for proper installation.
Check for chafing, cracks, deteriora-
tion and signs of leakage. Replace
any deteriorated or damaged parts.
A qualified technician should perform
these operations.
For further information on
maintenance services that you
can perform yourself, see the
maintenance sections of your
Owner’s Manual .
Lexus sedans-046_080.cgla 7/3/07 8:12 PM Page 66
Page 71 of 82
EXPLANATION OF MAINTENANCE ITEMS
MAINTENANCE
Scheduled Maintenance Log69
Steering Linkage and Boots
With the vehicle stopped, check for
excessive freeplay in the steering
wheel. Inspect the linkage for bending
and damage and the dust boots for
deterioration, cracks and damage.
Replace any damaged parts. A quali-
fied technician should perform these
operations.
Timing Belt (SC)
Replace every 90,000 miles or
108 months. A qualified technician
should perform this operation.
Timing Chain (ES, GS, IS, LS)
The ES, GS, IS and LS are equipped
with a timing chain that requires no
periodic inspection.
Tire Rotation
Tires should be rotated according
to the instructions in your Owner’s
Manual . When rotating tires, check
pressure and check for damage and
uneven wear. If the spare is not rotat-
ed, check the condition and pressure
of the spare.
Tire-Pressure Warning Sensors
A tire-pressure sensor is mounted on
each full-size wheel. These sensors
do not require periodic maintenance. When a sensor’s long-life lithium bat-
tery becomes discharged, the battery
should be replaced by a qualified
technician following procedures in
Lexus service and repair publications.
Transfer Case/Transmission
Inspect each transfer case/transmis-
sion component for signs of leakage.
If you discover any leakage, have it
repaired immediately by a qualified
technician.
Note:
The transfer case/transmission
and transmission fluid are a complete-
ly sealed unit. Therefore, periodic
checks and replacement of the trans-
mission fluid are not required, and
there is no dipstick on the transmis-
sion. Any repairs that require adding
or replacing fluid should be per-
formed by a qualified technician fol-
lowing procedures in Lexus service
and repair publications.
Lexus sedans-046_080.cgla 7/3/07 8:17 PM Page 69
Page 73 of 82
INDEX
Air conditioner filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .46–65*
, 66
Axle shaft boots . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4 6–65*
, 66
Ball joints and dust covers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .46–65 *
, 66
Body inspection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .46 –65*
, 66
Brakes General information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .inside front cover
Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .42, 66
Lines and hoses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .46–65 *
, 66
Pads/rotors and linings/drums . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .46–65 *
, 67
Collision repairs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8
Complimentary services Maintenance services . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4, 44–45
Other services . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4–6
Dispute resolution . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9–13, 21
Drive belt . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .46–65*
, 67
Emergency repairs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .37–38
Engine air filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .46–65*
, 67
Engine coolant . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .43, 46–65 *
, 67
Engine oil and filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .43, 46–65 *
, 67
Engine valve clearance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .46–65*, 6 8
Exhaust pipes and mountings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .46–65*, 68
Fuel lines and connections, fuel tank band and
fuel tank vapor vent system hoses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .46–65 *
, 68
Fuel tank cap gasket . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .46–65 *
, 68
Inspections, general maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .42–43
Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8
*See scheduled maintenance log for maintenance interval.
71
Lexus sedans-046_080.cgla 7/3/07 8:17 PM Page 71
Page 74 of 82
72
INDEX
Lexus Personalized Settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1, 4, 45
Loaner vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
Maintenance As related to warranty coverage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .25, 30, 35, 40
Complimentary first and second services . . . . . . . . . . . . . . . . . . . . . . . . . . .4, 44–46
Explanation of maintenance items . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .66–69
General maintenance and inspections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .42–43
Importance of maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .39
Maintenance intervals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44
Scheduled maintenance log . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .45–65
Where to obtain maintenance . . . . . . . . . . . . . . . . . . . . . . .inside front cover, 35, 41
Nuts and bolts on chassis . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .46–65 *
, 68
Oil change . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .46–65*
, 67
Owner responsibilities . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .25, 29, 30, 35–38
Parts replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8, 16, 25, 3 1, 36
Power steering fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .42, 68
Pre-delivery service . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1
Quality control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Rack and pinion assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .46–65 *
, 68
Road test . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .46–65*
, 68
Roadside assistance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1, 5–6
Service agreements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Service history . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Smog-check tests . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .26, 31
Spark plugs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .53, 61, 68
Steering linkage and boots . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .46–65 *
, 69
Lexus sedans-046_080.cgla 7/3/07 8:18 PM Page 72