2008 JEEP COMMANDER power steering

WARNING!
Fluid level should be checked on a level surface with
the engine off to prevent injury from moving parts,
and to insure accurate fluid level reading. Do not
overfill. Use only the manufacturer's recommended
fluid.
If necessary, add fluid to restore to the proper indicated
level. With a clean cloth, wipe any spilled fluid from all
surfaces. Refer to Fluids, Lubricants, and Genuine Parts
for correct fluid type.
NOTE:Upon initial start-up in cold weather, the power
steering pump may make noise for a short period of time.
This is due to the cold, thick fluid in the steering system.
This noise should be considered normal, and does not in
any way damage the steering system.
Body Lubrication
Locks and all body pivot points, including such items as
seat tracks, doors, tailgate and hood hinges, should be
lubricated periodically to assure quiet, easy operation
and to protect against rust and wear. Prior to the appli-
cation of any lubricant, the parts concerned should be
wiped clean to remove dust and grit; after lubricating
excess oil and grease should be removed. Particular
attention should also be given to hood latching compo-
nents to insure proper function. When performing other
underhood services, the hood latch, release mechanism
and safety catch should be cleaned and lubricated.
The external lock cylinders should be lubricated twice a
year, preferably in the fall and spring. Apply a small
amount of a high quality lubricant such as MopartLock
Cylinder Lubricant directly into the lock cylinder.
MAINTAINING YOUR VEHICLE 399
7

Brake and Power Steering System Hoses
When servicing the vehicle for scheduled maintenance,
inspect surface of hoses for evidence of heat and me-
chanical damage. Hard and brittle rubber, cracking, tears,
cuts, abrasion, and excessive swelling suggest deteriora-
tion of the rubber. Particular attention should be made to
examining those hose surfaces nearest to high heat
sources, such as the exhaust manifold.
Inspect all hose clamps and couplings to make sure they
are secure and no leaks are present.
NOTE:Often fluids such as oil, power steering fluid,
and brake fluid are used during assembly plant opera-
tions to ease the assembly of hoses to couplings. There-
fore, oil wetness at the hose-coupling area is not neces-
sarily an indication of leakage. Actual dripping of hot
fluid when systems are under pressure (during vehicle
operation) should be noted before hose is replaced based
on leakage.NOTE:Inspection of brake hoses should be done when-
ever the brake system is serviced and every engine oil
change.
WARNING!
Worn brake hoses can burst and cause brake failure.
You could have an accident. If you see any signs of
cracking, scuffing, or worn spots, have the brake
hoses replaced immediately.
Brake Master Cylinder Ð Brake Fluid Level Check
The fluid level in the master cylinder should be checked
when performing under hood services, or immediately if
the brake system warning lamp shows system failure
Be sure to clean the top of the master cylinder area before
removing the cap. If necessary, add fluid to bring the
fluid level up to the requirements described on the brake
408 MAINTAINING YOUR VEHICLE

Cav-
ityCartridge
FuseMini Fuse Description
13 10 Amp
RedAutowipe (R/A)
14 20 Amp
YellowCigar Ltr (R/A)
15 10 Amp
RedTire Pressure Trans-
ducers (R/O)
16 10 Amp
RedSteering Control Mod-
ule (SCM), Diag. Con-
nector, Cluster (B+)
17 15 Amp
BlueFlipper Glass (B+)
19 Spare
(R/S)
20 10 Amp
RedSentry Key Remote
Entry Module
(SKREEM), Cluster
(R/S)Cav-
ityCartridge
FuseMini Fuse Description
21 Spare
(Acc De-
lay)
22 15 Amp
BlueRear Wiper (B+)
24 10 Amp
RedPower Distribution
Center (PDC) Relays,
Final Drive Control
Module (FDCM),
Front Control Module
(FCM) (R/S), A580
(R/S)
25 10 Amp
RedShifter Assy (BTSI),
Trans. Case Switch,
ESP/ABS, Brake Supp
Rly Coil (R/S)
MAINTAINING YOUR VEHICLE 421
7

Chassis
Component Fluid, Lubricant, or Genuine Part
Automatic Transmission MopartATF+4 Automatic Transmission Fluid
Transfer Case (NV140 Single Speed
Only)MopartATF+4 Automatic Transmission Fluid
Transfer Case (NV245 Two Speed
Only)MopartNV 247/245 Transfer Case Lubricant
Axle Differential (Front-Rear) MopartSynthetic Gear & Axle Lubricant SAE 75W-140 (API-GL5) or
equivalent with friction modifier additive.
Brake Master Cylinder MopartDOT 3 Brake Fluid, SAE J1703 should be used. If DOT 3, SAE
J1703 brake fluid is not available, then DOT 4 is acceptable. Use only rec-
ommended brake fluids.
Power Steering Reservoir This system requires the use of MopartHydraulic System Power Steering
Fluid (P/N 05142893AA) or equivalent, which meets DaimlerChrysler Ma-
terial Standard MS-10838.
MAINTAINING YOUR VEHICLE 437
7

²Change your engine oil more often if you drive your
vehicle off-road for an extended period of time.
²Under no circumstances should oil change intervals
exceed 6,000 miles (10,000 km) or 6 months, whichever
comes first.
Your dealer will reset the oil change indicator message
after completing the scheduled oil change. If this sched-
uled oil change is performed by someone other than your
dealer the message can be reset by referring to the steps
described under ªOil Change Requiredº in ªUse Factory
Settingsº of the EVIC section in this manual.
At Each Stop for Fuel
²Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
²Check the windshield washer solvent and add if
required.
Once a Month
²Check tire pressure and look for unusual wear or
damage.
²Inspect the battery and clean and tighten the terminals
as required.
²Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transmission and
add as needed.
²Check all lights and other electrical items for correct
operation.
MAINTENANCE SCHEDULES 441
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Pressure Cap......................... 404
Radiator Cap......................... 404
Selection of Coolant (Antifreeze).........402,435
Courtesy Lights......................... 130
Crankcase Emission Control System.......... 395
Cruise Light........................... 193
Cup Holder............................ 172
Customer Assistance..................... 448
Data Recorder, Event...................... 58
Daytime Running Lights................... 128
Dealer Service.......................... 388
Defroster, Rear Window................... 177
Defroster, Windshield................71,258,265
Diagnostic System, Onboard................ 385
Digital Video Disc (DVD) Player............. 239
Dimmer Switch, Headlight................. 129
Dipsticks
Automatic Transmission................. 412Oil (Engine).......................... 389
Power Steering........................ 398
Disabled Vehicle Towing................... 378
Disposal
Antifreeze (Engine Coolant)............... 405
Engine Oil........................... 391
Used Engine Fluids..................... 391
Door Locks............................. 28
Door Locks, Automatic.................... 29
Door Opener, Garage..................... 159
Drive Belts............................ 392
Driving............................... 296
Off-Pavement......................... 296
Off-Road............................ 296
DVD Player (Video Entertainment System)...... 253
E-85 Fuel............................. 337
Electric Remote Mirrors.................... 80
Electrical Outlet, Auxiliary (Power Outlet)...... 169
INDEX 461
10

Starting............................. 277
Temperature Gauge..................... 191
Engine Oil Viscosity...................... 390
Engine Oil Viscosity Chart................. 390
Enhanced Accident Response Feature.......... 56
Entry System, Illuminated.................. 21
Event Data Recorder...................... 58
Exhaust Gas Caution.................38,70,337
Exhaust System......................... 401
Extender, Seat Belt........................ 48
Exterior Finish Care...................... 415
Filters
Air Cleaner.......................... 393
Engine Oil........................... 391
Engine Oil Disposal.................... 391
Finish Care............................ 415
Flashers.............................. 366
Hazard Warning....................... 366Turn Signal.....................187,430,432
Flexible Fuel Vehicles
Cruising Range........................ 340
Engine Oil........................... 340
Fuel Requirements..................337,339
Replacement Parts..................... 340
Starting............................. 340
Flipper Glass, Liftgate..................... 35
Flooded Engine Starting................... 279
Fluid Capacities......................... 435
Fluid Leaks............................. 72
Fluid Level Checks
Automatic Transmission............... 411,412
Engine Oil........................... 389
Power Steering........................ 398
Fluids, Lubricants and Genuine Parts.......... 436
Fog Light Service........................ 431
Fog Lights.......................128,194,431
Fold and Tumble Rear Seat................. 113
INDEX 463
10

Overheating, Engine...................192,367
Owner's Manual (Operator Manual).......... 452
Paint Care............................. 415
Paint Damage.......................... 415
Panic Alarm............................ 24
Park Sense System, Rear................... 153
Parking Brake.......................... 300
Passing Light........................... 129
Pedals, Adjustable....................... 135
Personal Settings........................ 205
Pets.................................. 69
Pets, Transporting........................ 69
Phone, Cellular.......................... 82
Phone, Hands-Free (UConnectŸ)............. 82
Placard, Tire and Loading Information......... 311
Polishing and Waxing..................... 415
Port
Universal Serial Bus (USB)................ 239USB ................................ 239
Power
Distribution Center (Fuses)............... 422
Door Locks........................... 29
Inverter............................. 170
Lift Gate............................. 36
Mirrors.............................. 80
Outlet (Auxiliary Electrical Outlet).......... 169
Seats............................... 110
Steering..........................305,398
Sunroof............................. 165
Windows............................. 31
Pregnant Women and Seat Belts.............. 47
Preparation for Jacking.................... 370
Pretensioners
Seat Belts............................. 46
Programmable Electronic Features............ 205
Programming Transmitters (Remote Keyless
Entry)................................. 21
470 INDEX