2008 FIAT GRANDE PUNTO rear brake

199
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
fig. 10F0M0154m
WINDSCREEN/REAR WINDOW
WASHER FLUID fig. 10
To top up, remove the cap A.
Pour a mixture of water and TUTELA
PROFESSIONAL SC35, in the follow-
ing concentrations:
30% TUTELA PROFESSIONAL
SC35and 70% water in summer.
50% TUTELA PROFESSIONAL
SC35and 50% water in winter.
In case of temperatures below –20°C, use
undiluted TUTELA PROFESSIONAL
SC35fluid.BRAKE FLUID fig. 11
Unscrew cap A: check that the fluid level
in the reservoir is at maximum.
Fluid level in the reservoir shall not exceed
the MAXmark.
If fluid has to be added, it is suggested to
use the brake fluid in table “Fluids and lu-
bricants” (see chapter “Technical charac-
teristics”). Check level through the reservoir.
Do not travel with the wind-
screen washer reservoir emp-
ty: the windscreen washer is funda-
mental for improving visibility.
WARNING
Certain commercial addi-
tives for windscreen washers
are inflammable. The engine com-
partment contains hot components
which may set it on fire.
WARNING
fig. 11
NOTE Clean accurately the tank cap A
and the surrounding surface.
At plug opening, pay maximum attention
in order to prevent any impurities from
entering the tank.
For topping up, always use a funnel with
integrated filter with mesh equal to or
lower than 0.12 mm.
IMPORTANT Brake fluid absorbs mois-
ture, for this reason, if the vehicle is main-
ly used in areas with a high degree of at-
mospheric humidity, the fluid should be
replaced at more frequent intervals than
specified in the “Service schedule”.
F0M0155m
Make sure that the highly
corrosive brake fluid does not
drip onto the paintwork; if it
does, wash it off immediate-
ly with water.
187-208 Punto GDX GB 31-07-2008 17:28 Pagina 199

204
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
WINDSCREEN/REAR
WINDOW WIPERS
BLADES
Periodically clean the rubber part using
special products; TUTELA PROFES-
SIONAL SC 35is recommended.
If the rubber blades are bent or worn they
should be replaced. In any case they
should be changed once a year.
A few simple notions can reduce the pos-
sibility of damage to the blades:
❒ if the temperature fall below zero,
make sure that ice has not frozen the
rubber against glass. If necessary, thaw
using an antifreeze product;
❒ remove any snow from the glass: in ad-
dition to protecting the blades, this pre-
vents effort on the motor and over-
heating;
❒do not operate the windscreen wipers
on dry glass.
Driving with worn wiper
blades is a serious hazard,
because visibility is reduced in bad
weather.
WARNING
RUBBER HOSES
As far as the brake system and fuel rubber
hoses are concerned, carefully follow the
“Service schedule” in this section.
Indeed ozone, high temperatures and pro-
longed lack of fluid in the system may
cause hardening and cracking of the hoses,
with possible leaks. Careful control is
therefore necessary.If the pressure is too low the
tyre overheats and this can
cause it serious damage.
WARNING
Do not cross switch the
tyres, moving them from the
right of the car to the left and vice
versa.
WARNING
Never submit alloy rims to
repainting treatments re-
quiring to use temperatures exceed-
ing 150°C. The mechanical properties
of the wheels could be impaired.
WARNING
187-208 Punto GDX GB 31-07-2008 17:28 Pagina 204

216
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
SUSPENSIONS
1.2 1.4 - 1.4 16V- 1.4 T-JET - 1.3 Multijet - 1.6 Multijet
Front
Rear twisting axle with interconnected wheels
BRAKES
1.2 1.4 - 1.4 16V- 1.4 T-JET1.3 Multijet 1.6 Multijet
Service brakes:
– front
– rear
Parking brake
IMPORTANT Water, ice and antifreeze salt on roads may deposit on the brake discs thus reducing braking efficiency
at first braking.
independent, Mc Pherson
type with anti-roll bar
rack and pinion with electric power steeringcontrolled by hand lever, it works on rear brakesdrum or disc (where provided) disc (self-ventilating for versions where provided)
STEERING
1.2 1.4 1.4 16V1.3 Multijet 1.3 Multijet 1.6 Multijet1.4 T-JET 75HP 90HP 120HP
Type
Minimum steering
cycle m 10,9Mc Pherson independent wheels
209-229 Punto GDX GB 6-08-2008 10:11 Pagina 216

3 door
4 seat
1015
480
850
850
1495
900
400
75
603 door
5 seat
1015
560
850
850
1575
900
400
75
605 door
5 seat
1030
560
850
850
1590
900
400
75
603 door
4 seat
1025
480
850
850
1505
1000
400
75
603 door
5 seat
1025
560
850
850
1585
1000
400
75
605 door
5 seat
1040
560
850
850
1600
1000
400
75
603 door
4 seat
1060
480
850
850
1540
1000
400
75
603 door
5 seat
1060
560
850
850
1620
1000
400
75
605 door
5 seat
1075
560
850
850
1635
1000
400
75
603 door
4 seat
1155
480
950
850
1635
1000
400
75
603 door
5 seat
1155
560
950
850
1715
1000
400
75
605 door
5 seat
1170
560
950
850
1730
1000
400
75
60
223
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
WEIGHTS
Petrol versions 1.2 1.4 1.4 16V1.4 T-JET
Weights (kg)
Empty weight
(including all fluids,
fuel tank at 90%
and with
no optional):
Payload (*)
including the driver:
Maximum admitted
loads (**)
– front axle:
– rear axle:
– total:
Towable loads
– trailer with brakes:
– trailer without brakes:
Maximum load on roof:
Maximum load on
tow hitch
(trailer with brakes):
(*) If special equipment is fitted (sunroof, tow hitch, etc.) the unladen car weight increases, thus reducing the specified payload.
(**) Loads not be exceeded. The driver is responsible for arranging the loads in the boot and/or on the roof so that they comply
with these limits.
209-229 Punto GDX GB 6-08-2008 10:11 Pagina 223

224
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
3 Door
4-seat
1090
480
950
850
1570
1000
400
75
603 Door
5-seat
1090
560
950
850
1650
1000
400
75
605 Door
5-seat
1105
560
950
850
1665
1000
400
75
603 Door
4-seat
1130
480
950
850
1610
1000
400
75
603 Door
5-seat
1130
560
950
850
1690
1000
400
75
605 Door
5-seat
1145
560
950
850
1705
1000
400
75
603 Door
4-seat
1205
480
1000
850
1685
1000
400
75
603 Door
5-seat
1205
560
1000
850
1765
1000
400
75
605 Door
5-seat
1220
560
1000
850
1780
1000
400
75
60
Multijet versions 1.3 Multijet 75 HP 1.3 Multijet 90 HP 1.6 Multijet
Weights (kg)
Empty weight
(including all fluids, fuel tank at 90%
and with no optional):
Payload (*) including the driver:
Maximum admitted loads (**)
– front axle:
– rear axle:
– total:
Towable loads
– trailer with brakes:
– trailer without brakes:
Maximum load on roof:
Maximum load on tow hitch
(trailer with brakes):
(*) If special equipment is fitted (sunroof, tow hitch, etc.) the unladen car weight increases, thus reducing the specified payload.
(**) Loads not be exceeded. The driver is responsible for arranging the loads in the boot and/or on the roof so that they comply
with these limits.
209-229 Punto GDX GB 6-08-2008 10:11 Pagina 224

Specified fuels and
original lubricants
Unleaded petrol with
no less than 95 R.O.N.
(EN 228 Specification)
Diesel fuel for motor
vehicles
(EN590 Specification)
Mixture of 50% water
and PARAFLU UP (
❒)
SELENIA K P.E.
SELENIA WR
TUTELA CAR
TECHNYX (
▲)
TUTELA CAR
MATRYX (
❍)
TUTELA TOP 4
Mixture of water and
TUTELA
PROFESSIONAL
SC 35
225
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
1.3
Multijet
75 HP
–
–
45
5 ÷ 7
7.3
–
–
3.0
3.2
1.7 (
▲)
(*)
0.5
2.2
4.5 1.4
45
5 ÷ 7
–
–
5.27
2.4
2.6
–
–
1.5 (▲)
0.5
2.2
4.5 1.2
45
5 ÷ 7
–
–
5.27
2.4
2.6
–
–
1.5 (▲)
0.5
2.2
4.5
1.3
Multijet
90 HP
–
–
45
5 ÷ 7
7.4
–
–
3.0
3.2
2.0 (
❍)
(**)
0.5
2.2
4.5
1.6
Multijet
120 HP
–
–
45
5 ÷ 7
5.7
–
–
4.3
4.6
2.0 (
❍)
0.5
2.2
4.5
1.416V
45
5 ÷ 7
–
–
5.27
2.75
2.9
–
–
1.65 (
▲)
0.5
2.2
4.5
1.4
T-JET
45
5 ÷ 7
–
–
6.0
2.75
3.3
–
–
1.7 (
▲)
0.5
2,2
4,5
CAPACITIES
Fuel tank: litres
including a reserve of: litres
Fuel tank: litres
including a reserve of: litres
Engine cooling system:litres
Engine sump: litres
Engine sump and filter: litres
Engine sump: litres
Engine sump and filter: litres
Gearbox/differential
casing kg:
Hydraulic brake circuit: kg
Windscreen, rear window
andheadlight washer litres
fluid reservoir: litres
(*) Valve also valid for 1.3 Multijet 90 HP version with 5-gear transmission.
(**) Version with 6-speed gearbox
(
❒) When the vehicle is used under particularly harsh climate conditions, we recommend using a 60-40 mixture of PARAFLU UP
and demineralised water.
209-229 Punto GDX GB 6-08-2008 10:11 Pagina 225

Lubricants and
greases
for transmission
Use Fluid and lubricant specifications Original fluids and Applications
for correct car operation lubricants
(*) IMPORTANT Do not top up or mix with fluids having characteristics different from those specified.
(❒) When the vehicle is used under particularly harsh climate conditions, we recommend using a 60-40 mixture of PARAFLU UP and demineralised water. LSynthetic-based oils, grade SAE 75W- 85.
Qualification FIAT 9.55550-MX3
Synthetic-based oil, grade SAE 75W-85.
Qualification FIAT 9.55550-MZ1
Grease containing Molybdenum bisulphide for high
temperature appliances. Qualification FIAT 9.55580.
N.L.G.I. 1-2 consistency.
Specifc grease to be used for constant-velocity joints with
low friction coefficient. Qualification FIAT 9.55580.
N.L.G.I. 0-1 consistency.
Poly-urea oil synthetic-based grease suitable for high
temperatures. QualificationFIAT 9.55580.
NL.GI. 2 consistency
Synthetic fluid FMVSS no. 116 DOT 4, ISO 4925
SAE J1704, CUNA NC 956- 01.
QualificationFIAT 9.55597
Protective with antifreeze action, red colour
based on inhibited monoethylen glycol and organic formula,
that passes CUNA NC 956-16, ASTM D 3306 specifications.
Qualification FIAT 9.55523
Additive for diesel fuels with protective action
for Diesel engines.
Mixture of alcohol and surfactants CUNA NC 956-11.
Qualification FIAT 9.55522.TUTELA CAR
TECHNYX
Contractual Technical
Reference N° F010.B05
TUTELA CAR
MATRYX
Contractual Technical
Reference N° F108.F02
TUTELA ALL STAR
Contractual
Technical Reference
N° F702.G07
TUTELA STAR 700
Contractual Technical
Reference N° F701.C07
TUTELA STAR 325
Contractual Technical
Reference N° F301.D03
TUTELA TOP 4
Contractual Technical
Reference N° F001.A93
PARAFLU UP (*)
Contractual Technical
Reference N° F101.M01
TUTELA DIESEL ART
Contractual Technical
Reference N°F601.L06
TUTELA PROFES-
SIONAL SC 35
Contractual Technical
Reference N° F201.D02Mechanical gearbox
and differential (petrol
versions and 1.3 Multijet
75 HP versions)
Mechanical gearbox and
differential (1.3 Multijet
90HP and 1.9 Multijet
versions)
CV joints
on wheel side
CV joints on differential
side (excluding 1.9
Multijet versions)
CV joints
on differential side
(1.9 Multijet versions)
Brake and clutch
hydraulic controls
Radiator antifreeze
proportion: 50% water and
50% PARAFLU UP (❒)
To be mixed with diesel fuel
(25 cc per 10 litres)
To be used diluted or
undiluted in windscreen/
rear window washer/
wiper systems
227
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
Brake fluids
Protective agent for
radiators
Windscreen/ rear
window washer fluid
Fuel additivel
209-229 Punto GDX GB 6-08-2008 10:11 Pagina 227

230
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
Bodywork
– maintenance .................................. 206
– version codes ............................... 212
Bonnet .................................................. 86
Boot ........................................................ 83
– extension........................................ 84
– tailgate opening/closing ............... 83
– emergency opening....................... 83
Boot light .............................................. 174
Brake Assist
(brake assist in an emergency) ....... 91
Brakes
– fluid level ........................................ 199
– specifications ................................. 216
Bulb (replacement)
– general instructions ..................... 166
– bulb types ...................................... 166
Capacities ............................................ 106
Care and maintenance
– periodic checks.............................. 193
– planned maintenance .................. 188– planned maintenance plan ........... 189
– Heavy-duty use of the car ........... 193
Card/ CD compartment.................... 73
Carrying children safely ..................... 115
Courtesy lights
– boot light ....................................... 68
– courtesy ......................................... 65
– front ................................................ 65
– puddle/door .................................. 68
– rear ................................................. 66
Chassis (marking) ............................... 211
Checking levels..................................... 194
Child locks............................................. 79
Child seat “Isofix Universal” ............ 120
Cigar lighter.......................................... 73
Clutch ................................................... 215
CO
2emissions..................................... 229
Code Card ........................................... 8
Consumption
– engine oil ........................................ 197
– fuel ................................................... 228
ABS ...................................................... 90
Accessories purchased by
the owner .......................................... 104
Air bag
– front................................................. 121
– side .................................................. 124
Air filter ................................................ 200
Air vents ............................................... 41
Alarm...................................................... 10
Armrest................................................. 74
ASR system........................................... 93
– activation/deactivation................. 94
At the filling station ............................ 106
Automatic two-zone climate
control system .................................. 51
Battery
– checking the charge ..................... 201
– jump starting ................................. 154
– recharging ...................................... 183
– replacement .................................. 201
II I
N N
D D
E E
X X
230-240 Punto GDX GB 8-08-2008 9:20 Pagina 230