2008 DODGE SPRINTER engine

314 OperationDriving tips
4
Certain systems of the engine serve to
keep the toxic components of the ex-
haust gases within permissible limits re-
quired by law.These systems, of course, will function
properly only when maintained strictly
according to factory specifications. Any
adjustments to the engine should there-
fore be carried out only by an authorized
Sprinter Dealer.
Engine adjustments should not be al-
tered in any way. Moreover, the speci-
fied service jobs must be carried out
regularly according to the manufactur-
er’s servicing requirements. For details
refer to the Service Booklet.Warning
G
As with any vehicle, do not idle, park or
operate this vehicle in areas where com-
bustible materials such as grass, hay, or
leaves can come into contact with the hot
exhaust system, as these materials could
be ignited and cause a vehicle fire.Emission control
Warning
G
Inhalation of exhaust gas is hazardous to
your health. All exhaust gas contains car-
bon monoxide (CO), and inhaling it can
cause unconsciousness and lead to
death.
Do not run the engine in confined areas
(such as a garage) which are not properly
ventilated. If you think that exhaust gas
fumes are entering the vehicle while driv-
ing, have the cause determined and cor-
rected immediately. If you must drive
under these conditions, drive with at least
one window fully open at all times.
nf_BA.book Page 314 Friday, January 25, 2008 3:53 PM

318 OperationEngine compartment
4
\3 Engine compartment
Opening
1Release lever\1
Pull release lever
1
under the in-
strument panel on the left-hand side
in the driver’s footwell.
The hood is released.
HoodWarning
G
Do not pull the release lever while the ve-
hicle is in motion. The hood could other-
wise open, thereby impairing visibility and
leading to loss of control of the vehicle.
For this reason, only open the hood when
the vehicle is parked.
!
CAUTION
Make sure that the windshield wipers
are not folded away from the wind-
shield. The windshield wipers or the
hood may otherwise be damaged.
N88.40-2060-31
nf_BA.book Page 318 Friday, January 25, 2008 3:53 PM

319 Operation
Engine compartment
4
2
Securing hook
\1
Push up securing hook lever
2
.
3
Support strut
\1
Swing the hood upward until support
strut
3
engages and the hood is
supported. N88.40-2063-31
N88.40-2062-31
Warning
G
If the hood support strut is not engaged,
the hood can fall shut. You could be in-
jured.
After opening the hood, you should there-
fore check whether the support strut is
engaged.
nf_BA.book Page 319 Friday, January 25, 2008 3:53 PM

320 OperationEngine compartment
4
Closing
Warning
G
Engine parts may be hot and can rotate.
There is a risk of injury if the hood is open
and the engine is running.
Only open the hood when the engine has
stopped and cooled down.
Warning
G
The engine has an electronic ignition sys-
tem which carries a high voltage. For this
reason, you must never touch the ignition
system components (ignition coil, test
socket) while:
\4the engine is running
\4the engine is being started
\4the key is in position2 in the ignition
lock and the engine is being cranked
by hand
Warning
G
Make sure that nobody can become
trapped as you close the hood.
nf_BA.book Page 320 Friday, January 25, 2008 3:53 PM

321 Operation
Engine compartment
4
\1
Lift the hood gently.
\1
Push back support strut
3

(
\2
page 319).
\1
Let the hood drop from a height of
approximately 05. ft (30 cm).
The hood engages audibly.
\1
Check to make sure the hood is fully
closed.
If the hood can be raised slightly, it
is not properly engaged. Open it
again and allow it to drop from a
slightly greater height.
Warning
G
Make sure that the hood is securely en-
gaged before driving off. Do no continue
driving if the hood can no longer engage
after an accident, for example.
The hood could otherwise come loose
while the vehicle is in motion and endan-
ger you and/or others.
!
CAUTION
When you press the support strut
back, make sure that you do not
press it against the detent position
and cause it to bend.
!
CAUTION
Do not use your hands to push the
hood down. Doing so could damage
it.
nf_BA.book Page 321 Friday, January 25, 2008 3:53 PM

322 OperationEngine compartment
4
Mechanical elements and the lubricants
used for them must be carefully
matched.
For this reason, only brands tested and
approved by the manufacturer should be
used. Please contact your Sprinter Deal-
er to obtain the necessary information.
No lubricant additives should be used.
The use of such additives could affect
your warranty rights. Information is
available from any authorized Sprinter
Dealer.For specifications of engine oils, coolant
and brake fluid, see "Service products
and capacities" (
\2
page 604) and con-
tact your authorized Sprinter Dealer.The vehicle consumes a maximum of
1 US qt (1.0 l) oil per 620 miles
(1000 km), depending on your driving
style.
Engine oil consumption may even be
higher if:
\4
the vehicle is new
\4
you mainly operate the vehicle under
arduous operating conditions
\4
you often drive at high engine
speeds
The engine oil consumption can only be
judged after a lengthy distance has been
covered.
Service products
Warning
G
If handled incorrectly, service products
can constitute a health risk for people and
an environmental hazard.
Always observe relevant guidelines for
handling, storing and disposing of service
products.
Engine oil
nf_BA.book Page 322 Friday, January 25, 2008 3:53 PM

323 Operation
Engine compartment
4
Check the engine oil level on a regular ba-
sis, for example weekly or each time you re-
fuel.Checking the engine oil level in the
displayIn vehicles with diesel engines, you can
view the engine oil level in the display.When the oil is being checked, the vehi-
cle must
\4
be standing level
\4
be at normal operating temperature
\4
have been standing with the engine
switched off for at least five minutes
\1
Switch on the ignition (
\2
page 111).
The display is activated.
iIf the oil level exceeds the maximum
level several times during operation,
have the malfunction rectified imme-
diately at an authorized Sprinter
Dealer.
iIf no oil level reading is shown again,
check the engine oil level with the dip-
stick.
Have the engine oil level display
checked at an authorized Sprinter Deal-
er.
!
CAUTION
Have any excess oil drained or si-
phoned off at an authorized Sprinter
Dealer. Otherwise, the engine or cat-
alytic converter could be damaged.
iIf at extremely low temperatures no
engine oil level is displayed after 5
minutes, wait a further 5 minutes be-
fore repeating the engine oil level
check.
nf_BA.book Page 323 Friday, January 25, 2008 3:53 PM

324 OperationEngine compartment
4
Vehicles without steering wheel
buttons
\1
Press the menu button on the in-
strument cluster repeatedly until you
see the
P
symbol in the display.
The
--:--
display flashes during the
measurement process.The following messages may be dis-
played:
POK
\1
Do not add oil.
-1.0 qt
\1
Add the amount of
oil shown
(\2
page 328).
-1.5 qts-2.0 qtsHI
\1
The engine oil level
is too high. Have
the oil siphoned off.
iEngine oil level display:\4
qt in USA only
\4
l in Canada only
nf_BA.book Page 324 Friday, January 25, 2008 3:53 PM