2008 CHRYSLER PT CRUISER catalytic converter

Certain conditions such as a loose or missing gas cap,
poor fuel quality, etc. may illuminate the light after
engine start. The vehicle should be serviced if the light
stays on through several of your typical driving cycles. In
most situations the vehicle will drive normally and will
not require towing.
If the Malfunction Indicator Light flashes when the
engine is running, serious conditions may exist that
could lead to immediate loss of power or severe catalytic
converter damage. The vehicle should be serviced as
soon as possible if this occurs.
11. Odometer/Trip Odometer Reset Knob
Press this button to change the display from odometer to
either of the two trip odometer settings. Trip A or Trip B
will appear when in the trip odometer mode. Push in and
hold the button for two seconds to reset the trip odometer
to 0 miles or kilometers. The odometer must be in trip
mode to reset.12. Charging System Light
This light shows the status of the electrical charg-
ing system. The light should come on briefly when
the ignition switch is first turned ON and remain on
briefly as a bulb check. If the light stays on or comes on
while driving, it means that there is a problem with the
charging system. Obtain SERVICE IMMEDIATELY.
13. Turn Signal Indicators
The arrows will flash in unison with the exterior
turn signal, when using the turn signal lever.
NOTE:Turn signal bulbs are located in the Instrument
Panel.
230 UNDERSTANDING YOUR INSTRUMENT PANEL

MANUAL TRANSAXLE
Before starting the engine fully apply the parking brake,
press the clutch pedal to the floor and shift the gear
selector lever in NEUTRAL.
NOTE:The engine will not start unless the clutch pedal
is pressed to the floor.
NORMAL STARTING
Normal starting of either a cold or a warm engine does
not require pumping or depressing the accelerator pedal.
Simply turn the ignition switch to the START position
and release when the engine starts. If the engine has not
started within three seconds, slightly depress the accel-
erator pedal while continuing to crank. If the engine fails
to start within 15 seconds, turn the ignition switch to the
OFF position, wait 10 to 15 seconds, then repeat the
ªNORMAL STARTINGº procedure above.
WARNING!
Do not attempt to push or tow your vehicle to get it
started. Vehicles equipped with an automatic trans-
axle cannot be started this way. Unburned fuel could
enter the catalytic converter and once the engine has
started, ignite and damage the converter and vehicle.
If the vehicle has a discharged battery, booster cables
may be used to obtain a start from another vehicle.
This type of start can be dangerous if done improp-
erly, so follow the procedure carefully. See Section 6
of this manual for jump starting instructions.
EXTREMELY COLD WEATHER (BELOW220ÉF or
229ÉC)
To insure reliable starting at these temperatures, use of an
externally powered electric engine block heater (available
from your authorized dealer) is recommended.
292 STARTING AND OPERATING

²The use of leaded gas is prohibited by Federal law.
Using leaded gasoline can impair engine performance,
damage the emission control system.
²An out-of-tune engine, or certain fuel or ignition
malfunctions, can cause the catalytic converter to
overheat. If you notice a pungent burning odor or
some light smoke, your engine may be out of tune or
malfunctioning and may require immediate service.
Contact your dealer for service assistance.
²The use of fuel additives which are now being sold as
octane enhancers is not recommended. Most of these
products contain high concentrations of methanol.
Fuel system damage or vehicle performance problems
resulting from the use of such fuels or additives is not
the responsibility of the manufacturer.
NOTE:Intentional tampering with emissions control
systems can result in civil penalties being assessed
against you.
CARBON MONOXIDE WARNINGS
WARNING!
Carbon monoxide (CO) in exhaust gases is deadly.
Follow the precautions below to prevent carbon
monoxide poisoning:
²Do not inhale exhaust gases. They contain carbon
monoxide, a colorless and odorless gas which can kill.
Never run the engine in a closed area, such as a
garage, and never sit in a parked vehicle with the
engine running for an extended period. If the vehicle is
stopped in an open area with the engine running for
more than a short period, adjust the ventilation system
to force fresh, outside air into the vehicle.
²Guard against carbon monoxide with proper mainte-
nance. Have the exhaust system inspected every time
STARTING AND OPERATING 339
5

WARNING!
Do not attempt to push or tow your vehicle to get it
started. Vehicles equipped with an automatic trans-
axle cannot be started this way. Unburned fuel could
enter the catalytic converter and once the engine has
started, ignite and damage the converter and vehicle.
If the vehicle has a discharged battery, booster cables
may be used to obtain a start from another vehicle.
This type of start can be dangerous if done improp-
erly, so follow this procedure carefully.
1. Wear eye protection and remove any metal jewelry
such as watch bands or bracelets that might make an
inadvertent electrical contact.2. When boosting from a battery in another vehicle, park
that vehicle within booster cable reach but without
letting the vehicles touch. Set parking brake, place auto-
matic transaxle in PARK (manual transaxle in NEU-
TRAL) and turn ignition to OFF for both vehicles.
3. Turn off the heater, radio and all unnecessary electrical
loads.
4. Connect one end of a jumper cable to the positive
terminal of the booster battery. Connect the other end of
the jumper cable to the positive terminal of the dis-
charged battery.
368 WHAT TO DO IN EMERGENCIES

MAINTAINING YOUR VEHICLE
CONTENTS
m2.4L Turbo Engine Compartment............378
m2.4L Engine Compartment................379
mOnboard Diagnostic System Ð OBD II........380
NLoose Fuel Filler Cap Message............381
mEmissions Inspection And Maintenance
Programs............................381
mReplacement Parts......................383
mAuthorized Dealer Service................383
mMaintenance Procedures..................384NEngine Oil..........................384
NDrive Belts Ð Check Condition And Tension . . 388
NSpark Plugs.........................388
NIgnition Wiring System.................388
NCatalytic Converter....................389
NEngine Timing Belt....................390
NCrankcase Emission Control System........390
NFuel Filter..........................391
NAir Cleaner Element (Air Filter)...........391
7

CATALYTIC CONVERTER
The catalytic converter requires the use of unleaded fuel
only. Leaded gasoline will destroy the effectiveness of the
catalyst as an emission control device.
Under normal operating conditions, the catalytic con-
verter will not require maintenance. However, it is im-
portant to keep the engine properly tuned to assure
proper catalyst operation and prevent possible catalyst
damage.CAUTION!
Damage to the catalytic converter can result if your
vehicle is not kept in proper operating condition. In
the event of engine malfunction, particularly involv-
ing engine misfire or other apparent loss of perfor-
mance, have your vehicle serviced promptly. Contin-
ued operation of your vehicle with a severe
malfunction could cause the converter to overheat,
resulting in possible damage to the converter and the
vehicle.
NOTE:Intentional tampering with emissions control
systems can result in civil penalties being assessed
against you.
MAINTAINING YOUR VEHICLE 389
7

Cargo Compartment
Luggage Carrier....................... 215
Carrier, Luggage........................ 215
Catalytic Converter...................... 389
Caution, Exhaust Gas..................... 115
CD (Compact Disc) Player...............251,259
CD (Compact Disc) Player Maintenance........ 277
Cellular Phone.......................138,277
Center High Mounted Stop Light............ 428
Chains, Tire............................ 330
Changing A Flat Tire..................... 360
Chart, Tire Sizing........................ 314
Check Engine Light (Malfunction Indicator
Light)................................ 381
Child Restraint.......................72,107
Child Restraint Tether Anchors............77,111
Child Restraint with Automatic Belts........... 76
Child Safety Locks........................ 22
Child Seat...........................78,112Clean Air Gasoline....................... 337
Cleaning
Wheels............................. 413
Climate Control......................... 277
Clock...........................250,253,261
Clutch............................... 406
Clutch Fluid........................... 406
Coin Holder........................... 208
Compact Disc (CD) Maintenance............. 277
Compact Spare Tire...................... 325
Compass.....................234,235,238,248
Compass Calibration................238,247,248
Compass Variance....................... 236
Computer, Trip/Travel.................234,235
Console.............................. 208
Contract, Service........................ 463
Convertible............................ 123
Convertible Boot.....................128,132
Convertible Top......................... 123
472 INDEX

INTRODUCTION INTRODUCTION HOW TO USE THIS MANUAL WARNINGS AND CAUTIONS VEHICLE IDENTIFICATION NUMBER VEHICLE MODIFICATIONS/ALTERATIONS THINGS TO KNOW BEFORE STARTING YOUR VEHICLE A WORD ABOUT YOUR KEYS
IGNITION KEY REMOVALLOCKING DOORS WITH A KEYKEY-IN-IGNITION REMINDERSENTRY KEY - IF EQUIPPED Replacement KeysSentry Key ProgrammingGeneral InformationSTEERING WHEEL LOCK - IF EQUIPPED If You Wish To Manually Lock The Steering
WheelTo Release The Steering Wheel LockAutomatic Transaxle Ignition Interlock SystemDOOR LOCKS MANUAL DOOR LOCKSPOWER DOOR LOCKS - IF EQUIPPEDCHILD PROTECTION DOOR LOCK SYSTEM - IF EQUIPPEDREMOTE KEYLESS ENTRY (SEDAN)
TO UNLOCK THE DOORS AND LIFTGATETO LOCK THE DOORS AND LIFTGATE - IF EQUIPPED WITH POWER OPTIONSPANIC ALARMTO TURN OFF FLASH LIGHTS WITH LOCKTO PROGRAM ADDITIONAL TRANSMITTERSGENERAL INFORMATION
TRANSMITTER BATTERY SERVICEREMOTE KEYLESS ENTRY (CONVERTIBLE) TO UNLOCK THE DOORSTO LOCK THE DOORSTO UNLATCH THE DECK LIDPANIC ALARMTO TURN OFF FLASH LIGHTS WITH LOCKTO PROGRAM ADDITIONAL TRANSMITTERS
GENERAL INFORMATIONTRANSMITTER BATTERY SERVICESECURITY ALARM SYSTEM - IF EQUIPPED To set the alarmTo disarm the systemSecurity System Manual OverrideLIFTGATE (SEDAN) Opening The Liftgate While the Security Alarm Is ActivatedDECK LID
(CONVERTIBLE) POWER DECK LID RELEASE (Convertible)EMERGENCY SEAT BACK RELEASE (SEDAN) EMERGENCY DECK LID RELEASE LATCH (CONVERTIBLE) POWER WINDOWS AUTO DOWN FEATUREREAR WINDOW SWITCHESWIND BUFFETING
OCCUPANT RESTRAINTS (SEDAN) LAP/SHOULDER BELTSLAP/SHOULDER SEAT BELT UNTWISTING PROCEDUREADJUSTABLE UPPER SHOULDER SEAT BELT ANCHORAGESEAT BELT PRETENSIONERSENHANCED SEAT BELT REMINDER SYSTEM
(BELTALERT) SEAT BELTS AND PREGNANT WOMENDRIVER AND FRONT PASSENGER SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIRBAGCHILD RESTRAINTOCCUPANT RESTRAINTS (CONVERTIBLE) LAP/SHOULDER BELTSLAP/SHOULDER SEAT BELT
UNTWISTING PROCEDURESEAT BELT PRETENSIONERSENHANCED SEAT BELT REMINDER SYSTEM (BELTALERT) SEAT BELTS AND PREGNANT WOMENDRIVER AND FRONT PASSENGER SUPPLEMENTAL RESTRAINT SYSTEM (SRS)CHILD RESTRAINT
ENGINE BREAK-IN RECOMMENDATIONS SAFETY TIPS Exhaust GasSafety Checks You Should Make Inside The VehiclePeriodic Safety Checks You Should Make Outside The VehicleUNDERSTANDING THE FEATURES OF YOUR VEHICLE CONVERTIBLE TOP
OPERATION To Lower The TopTo Raise The TopConvertible Top Boot Cover Installation-If EquippedConvertible Top Boot Cover Removal and StorageCONVERTIBLE TOP MANUAL OVERRIDEMIRRORS Inside Day/Night Mirror - If EquippedOutside Mirror-Drivers Side
Outside Mirror-Passengers SideElectric Remote-Control Mirrors - If EquippedIlluminated Vanity Mirrors - If EquippedSun Visor Sliding FeatureHANDS-FREE COMMUNICATION (UConnect) - IF EQUIPPED OperationsPhone Call FeaturesUConnect System Features
Advanced Phone ConnectivityThings You Should Know About Your UConnect SystemGeneral InformationSEATS FRONT SEAT ADJUSTMENTPOWER SEAT ADJUSTER -IF EQUIPPEDMANUAL LUMBAR - IF EQUIPPEDFOLDING FRONT PASSENGER SEAT - IF
EQUIPPEDDRIVERS SEAT BACK TILT - IF EQUIPPEDPASSENGER SEAT BACK TILT (EASY ENTRY SYSTEM) - CONVERTIBLEADJUSTABLE HEAD RESTRAINTSHEATED SEATS - IF EQUIPPEDFOLDING REAR SEAT (SEDAN)FOLDING REAR SEAT
(CONVERTIBLE)TUMBLING REAR SEAT (SEDAN)TUMBLING REAR SEAT (CONVERTIBLE)REAR SEAT REMOVAL (SEDAN)TO OPEN AND CLOSE THE HOOD LIGHTS Map/Reading Lights (Sedan)Map/Reading Lights (Convertible)Multi-Function Control Lever
Headlights, Parking Lights, Instrument Panel LightsDaytime Running Lights (DRL) - If EquippedLights-on ReminderFog Lights - If Equipped Turn Signals Highbeam/Lowbeam Select Switch Passing LightWINDSHIELD WIPERS AND WASHERS Windshield WashersMist
Feature Windshield Wiper OperationIntermittent Wiper SystemTILT STEERING COLUMN ELECTRONIC SPEED CONTROL - IF EQUIPPED To ActivateTo Set At A Desired SpeedTo DeactivateTo Resume SpeedTo Vary The Speed SettingManual TransaxleTo Accelerate
For PassingGARAGE DOOR OPENER - IF EQUIPPED PROGRAMMING HOMELINKGATE OPERATOR/CANADIAN PROGRAMMINGUSING HOMELINKREPROGRAMMING A SINGLE HOMELINK BUTTONSECURITYTROUBLESHOOTING TIPSGENERAL
INFORMATIONPOWER SUNROOF (SEDAN ONLY) - IF EQUIPPED Express Open FeatureWind BuffetingSunroof MaintenanceELECTRICAL POWER OUTLETS Electrical Outlet Use With Engine OffCONSOLE FEATURES STORAGE Center Console/Armrest Storage
Bin Storage PocketsREAR SHELF PANEL- IF EQUIPPED Position 1 (Top)Position 2 (Middle)Position 3 (Floor)Position 4 (Vertical)Position 5 (table)ROOF LUGGAGE RACK - IF EQUIPPED REAR WINDOW FEATURES Electric Rear Window Defroster Rear Wiper/Washer
Switch (Sedan Models Only) - If EquippedAdding Washer FluidUNDERSTANDING YOUR INSTRUMENT PANEL INSTRUMENT PANEL FEATURES INSTRUMENT CLUSTER-BASE INSTRUMENT CLUSTER-PREMIUM INSTRUMENT CLUSTER-TURBO INSTRUMENT
CLUSTER DESCRIPTIONS COMPASS MINI TRIP COMPUTER (CMTC) - IF EQUIPPED Compass Mini Trip Computer Reset ButtonCompass/Temperature DisplayOdometerDisplayTrip Odometer (ODO)ELECTRONIC VEHICLE INFORMATION CENTER (EVIC) - If
Equipped EVIC Functions Compass/Temperature/AudioAverage Fuel EconomyDistance To Empty (DTE)Elapsed TimeTire Pressure Monitor (TPM)PersonalSettings (Customer Programmable Features)SETTING THE ANALOG CLOCK RADIO GENERAL INFORMATION
Radio Broadcast SignalsTwo Types of SignalsElectrical DisturbancesAM ReceptionFM ReceptionSALES CODE REF - AM/FM/CD (SINGLE DISC) RADIO WITH OPTIONAL SATELLITE RADIO AND HANDS FREE PHONE CAPABILITY Operating Instructions - Radio Mode
Operating Instructions - CD ModeOperating Instructions - Auxiliary ModeOperating Instructions - Hands-Free Phone - If EquippedOperating Instructions - Satellite Radio - If EquippedSALES CODE RAQ - AM/FM/CD (6-DISC) RADIO WITH OPTIONAL SATELLITE RADIO,
HANDS-FREE PHONE, AND VIDEO ENTERTAINMENT SYSTEMS (VES) CAPABILITIES Operating Instructions - Radio ModeOperating Instructions - (CD Mode for CD Audio Play)LOAD/EJECT Button (CD Mode for CD Audio Play)Notes On Playing MP3 FilesOperating
Instructions - (CD Mode for MP3 Audio Play)LOAD/EJECT Button (CD Mode for MP3 Play)SATELLITE RADIO - IF EQUIPPED System ActivationElectronic SerialNumber/Sirius Identification Number (ESN/SID)Selecting Satellite Mode in REF, and RAQ, RadiosSelecting
a ChannelStoring and Selecting Pre-Set ChannelsUsing the PTY (Program Type) Button (if equipped)PTY Button SCANPTY Button SEEKSatellite AntennaReception QualityCD/DVD DISC MAINTENANCE RADIO OPERATION AND CELLULAR PHONES CLIMATE
CONTROLS Climate ControlsOperating Tips STARTING AND OPERATING STARTING PROCEDURES AUTOMATIC TRANSAXLEMANUAL TRANSAXLENORMAL STARTINGEXTREMELY COLD WEATHER (BELOW -20 degrees F or -29 degrees C)IF THE ENGINE FAILS
TO STARTAFTER STARTINGTURBOCHARGER COOL-DOWN AUTOMATIC TRANSAXLE - IF EQUIPPED BRAKE/TRANSMISSION INTERLOCK SYSTEMAUTOMATIC TRANSAXLE IGNITION INTERLOCK SYSTEMFOUR-SPEED AUTOMATIC TRANSAXLERESET
MODEGEAR RANGES FOR THE FOUR-SPEED AUTOMATIC TRANSAXLEAUTOSTICK - IF EQUIPPED AUTOSTICK OperationAUTOSTICK General InformationMANUAL TRANSAXLE OPERATION - IF EQUIPPED 2.4 LITER TURBO - IF EQUIPPED MANUAL
TRANSAXLE - RECOMMENDED SHIFT SPEEDSDownshiftingPARKING BRAKE BRAKE SYSTEM ANTI-LOCK BRAKE SYSTEM (ABS) - IF EQUIPPEDPOWER STEERING TRACTION CONTROL SYSTEM - IF EQUIPPED TIRE SAFETY INFORMATION Tire Markings
Tire Identification Number (TIN)Tire Loading and Tire PressureTIRES - GENERAL INFORMATION Tire PressureTire Inflation PressuresRadial Ply TiresCompact Spare Tire - If EquippedLimited-Use Spare - If EquippedTire SpinningTread Wear IndicatorsLife of Tire
Replacement TiresAlignment and BalanceTIRE CHAINS SNOW TIRES TIRE ROTATION RECOMMENDATIONS TIRE PRESSURE MONITOR SYSTEM (TPMS) - IF EQUIPPED BASESYSTEM - IF EQUIPPEDGENERAL INFORMATIONFUEL REQUIREMENTS -
GASOLINE ENGINES 2.4L AND 2.4L STANDARD TURBO ENGINESREFORMULATED GASOLINEGASOLINE/OXYGENATE BLENDSMMT IN GASOLINEMATERIALS ADDED TO FUELFUELSYSTEM CAUTIONSCARBON MONOXIDE WARNINGSADDING FUEL Fuel
Filler Cap (Gas Cap)Loose Fuel Filler Cap MessageVEHICLE LOADING TRAILER TOWING COMMON TOWING DEFINITIONSTRAILER HITCH CLASSIFICATIONTRAILER TOWING WEIGHTS (MAXIMUM TRAILER WEIGHT RATINGS)TRAILER AND TONGUE WEIGHT
TOWING REQUIREMENTSTOWING TIPSRECREATIONAL TOWING (BEHIND MOTORHOME, ETC.) Towing This Vehicle Behind Another Vehicle (Flat towing with all fourwheels on the ground)WHAT TO DO IN EMERGENCIES HAZARD WARNING FLASHER IF YOUR
ENGINE OVERHEATS JACKING AND TIRE CHANGING JACK LOCATIONSPARE TIRE STOWAGEPREPARATIONS FOR JACKINGJACKING INSTRUCTIONS JUMP-STARTING PROCEDURES DUE TO A LOW BATTERY DRIVING ON SLIPPERY SURFACES ACCELERATIONTRACTIONFREEING A STUCK VEHICLE TOWING A DISABLED VEHICLE With Ignition KeyWithout The Ignition KeyCONVERTIBLE TOP MANUAL OVERRIDE MAINTAINING YOUR VEHICLE 2.4L TURBO ENGINE COMPARTMENT 2.4L ENGINE
COMPARTMENT ONBOARD DIAGNOSTIC SYSTEM - OBD II Loose Fuel Filler Cap MessageEMISSIONS INSPECTION AND MAINTENANCE PROGRAMS REPLACEMENT PARTS AUTHORIZED DEALER SERVICE MAINTENANCE PROCEDURES ENGINE OILDRIVE
BELTS - CHECK CONDITION AND TENSIONSPARK PLUGSIGNITION WIRING SYSTEMCATALYTIC CONVERTERENGINE TIMING BELTCRANKCASE EMISSION CONTROL SYSTEMFUEL FILTERAIR CLEANER ELEMENT (AIR FILTER)MAINTENANCE-FREE
BATTERYAIR CONDITIONER MAINTENANCEPOWER STEERING - FLUID CHECKFRONT SUSPENSION BALL JOINTSSTEERING LINKAGEBODY LUBRICATIONWINDSHIELD WIPER BLADESWINDSHIELD WASHER RESERVOIREXHAUST SYSTEMCOOLING
SYSTEMHOSES AND VACUUM/VAPOR HARNESSESFUEL SYSTEM CONNECTIONSBRAKE SYSTEMAUTOMATIC TRANSAXLEMANUAL TRANSAXLEAPPEARANCE CARE AND PROTECTIONFROM CORROSIONCONVERTIBLE TOP CARE WashingGeneral
CleaningCloth Top Additional Cleaning ProcedureCloth Top ProtectionWeather Strip CareINTEGRATED POWER MODULE (IPM) VEHICLE STORAGE REPLACEMENT BULBS BULB REPLACEMENT HeadlightsFront Park/Turn Signal/Side Marker LightsFront Fog Lights
- If EquippedTail/Stop, and Rear Turn Signal LightsBack Up Lights Center High Mounted Stop LightFLUIDS AND CAPACITIES FLUIDS, LUBRICANTS AND GENUINE PARTS ENGINECHASSISMAINTENANCE SCHEDULES EMISSIONS CONTROL SYSTEM
MAINTENANCE MAINTENANCE SCHEDULE SCHEDULE B-ALL ENGINESSCHEDULE A-NON TURBOSCHEDULE A-TURBOIF YOU NEED CONSUMER ASSISTANCE SUGGESTIONS FOR OBTAINING SERVICE FOR YOUR VEHICLE Prepare For The Appointment
Prepare A ListBe Reasonable With RequestsIF YOU NEED ASSISTANCE DaimlerChrysler Motors Corporation Customer CenterDaimlerChrysler Canada Inc. Customer CenterIn Mexico contactCustomer Assistance For The Hearing Or Speech Impaired (TDD/TTY)Service
ContractWARRANTY INFORMATION (U.S. Vehicles Only) MOPAR PARTS REPORTING SAFETY DEFECTS In The 50 United States And Washington, D.CIn CanadaPUBLICATION ORDER FORMS DEPARTMENT OF TRANSPORTATION UNIFORM TIRE QUALITY
GRADES TreadwearTraction GradesTemperature GradesINDEX