2007 VOLVO XC70 clutch

2007 Volvo XC70
WARNING!
Before starting, check that the seat, steering wheel and mirrors are adj\
usted properly. Make sure the
brake pedal can be depressed completely. Adjust the seat if necessary. S\
ee page
84 and 86.
- Apply the parking brake (hand brake) if not already set. The gear se\
lector (automatic transmission) is
locked in the (P)ark position (SHIFTLOCK). Manual transmission: the clutch must be fully depressed.
- Without touching the accelerator pedal, turn the ignition key
1 to the starting position. Allow the starter
to operate for up to 10 seconds. Release the key as soon as the engine s\
tarts. If the engine fails to start,
repeat this step.
NOTE:
l If the key blade section of the remote is not fully folded out when star\
ting the vehicle, the immobilizer
function may make it impossible to start the engine.
l After a cold start, idle speed may be noticeably higher than normal for \
a short period. This is done to
help bring components in the emission control system to their normal ope\
rating temperature as quickly
as possible, which enables them to control emissions and help reduce the\
vehicle's impact on the
environment.
l For cold starts at altitudes above 6000 ft (1800 meters), depress the \
accelerator pedal halfway and turn
the key to the starting position. Release the pedal slowly when the engi\
ne starts.
l To release the gear selector from the (P)ark position, the engine must be running (or the ignition key
must be in position II) and the brake pedal must be depressed.
l Select the desired gear. The gear engages after a very slight delay whic\
h is especially noticeable when
selecting R.
NOTE: Your vehicle is equipped with a KEYLOCK system (automatic transmission). When the engine
is switched off, the gear selector must be in the (P)ark position before the key can be removed from the
ignition switch.
When starting in cold weather, the transmission may shift up at slightly\
higher engine speeds than
normal until the automatic transmission fluid reaches normal operating t\
emperature.
1. If two of the keys to your vehicle are close together, e.g. on the sa\
me key ring, when you try to start the
vehicle, this could cause interference in the immobilizer system and res\
ult in the vehicle not starting. If this
should occur, remove one of the keys from the key ring before trying to \
start the vehicle again.
file:///K|/ownersdocs/2007/2007_XC70/07xc70_06.htm (7 of 41)12/30/2006\
5:51:37 PM

2007 Volvo XC70
CAUTION!
l Engine damage will occur if water is drawn into the air cleaner.
l If the vehicle is driven through water deeper than 9 in (25 cm), water\
may enter the differential and
the transmission. This reduces the oil's lubricating capacity and may sh\
orten the service life of these
components.
l Do not allow the vehicle to stand in water up to the door sills longer t\
han absolutely necessary.
This could result in electrical malfunctions.
l If the engine has been stopped while the car is in water, do not attempt\
to restart the engine. Have
the car towed out of the water.
pg. 129 Starting and driving
Manual transmission
5-speed manual transmission
Depress the clutch pedal completely when changing gears
1.
Remove your foot from the clutch pedal while driving. The shift pattern \
should be followed. Overdrive
(5th gear) should be used as often as possible to help improve fuel ec\
onomy.
1. Clutch interlock
The clutch must be fully depressed before you can start your vehicle. If\
the clutch is not depressed, it will not be
possible to start the engine.
file:///K|/ownersdocs/2007/2007_XC70/07xc70_06.htm (12 of 41)12/30/200\
6 5:51:37 PM

2007 Volvo XC70
6-speed manual transmission (option on certain models)
Fifth and sixth gears should be used as often as possible to help improv\
e fuel economy.
WARNING!
An extra mat on the driver's floor can cause the accelerator pedal and/o\
r the clutch pedal to catch.
Check that the movement of these pedals is not impeded. Not more than on\
e protective floor covering
may be used at one time.
Engaging reverse gear
Never engage R while the vehicle is moving.
file:///K|/ownersdocs/2007/2007_XC70/07xc70_06.htm (13 of 41)12/30/200\
6 5:51:37 PM

2007 Volvo XC70
Engine compartment
1. Expansion tank - coolant
2. Power steering fluid reservoir
3. Washer fluid reservoir
4. Dipstick - engine oil
5. Radiator
6. Cooling fan
7. Oil filler cap - engine
8. Clutch/brake fluid reservoir
9. Relay/fuse box
10. Air cleaner
11. Battery (under floor in cargo area)
12. Data plate
WARNING!
The cooling fan (6) may start or continue to operate (for up to 6 min\
utes) after the engine has been
switched off.
pg. 190 Maintenance and servicing
Engine oil
Oil specifications
Engine oil must meet the minimum ILSAC specification GF-3, API SL, and A\
CEA A1/ B1. Lower
quality oils may not offer the same fuel economy, engine performance, or\
engine protection.
file:///K|/ownersdocs/2007/2007_XC70/07xc70_09.htm (8 of 38)12/30/2006\
5:51:43 PM

2007 Volvo XC70
CAUTION!
The cooling system must always be kept filled to the correct level. If i\
t is not kept filled, there can be
high local temperatures in the engine which could result in damage. Diff\
erent types of antifreeze/
coolant may not be mixed.
Check coolant regularly!
WARNING!
l Never remove the radiator cap while the engine is warm. Wait until the v\
ehicle cools.
l If it is necessary to top up the coolant when the engine is warm, unscre\
w the expansion tank cap
slowly so that the overpressure dissipates.
pg. 193 Maintenance and servicing
Fluids
Clutch and brake fluid reservoir
The clutch and brake fluid should always be above the MIN mark on the si\
de of the reservoir. Check,
without removing the cap, that there is sufficient fluid in the reservoi\
r.
Fluid type: DOT 4+ boiling point >536 °F (280 °C), P/N 9437433.
Replace: Every second year or 30,000 miles (48,000 km). The fluid should be rep\
laced once a year or
every 15,000 miles (24,000 km) when driving under extremely hard condi\
tions (mountain driving, etc.).
Always entrust brake fluid changing to an authorized Volvo retailer.
file:///K|/ownersdocs/2007/2007_XC70/07xc70_09.htm (13 of 38)12/30/200\
6 5:51:43 PM