2007 DODGE SPRINTER spare tire

303 Practical hints
Where will I find...?
5
\1Raise spare wheel bracket 4 using
the pump lever and release right secur-
ing hook 1.
\1Slowly lower spare wheel bracket 4
to the ground.
\1Raise spare wheel bracket 4 slightly
and pull the pump lever out of sleeve.
\1Use the pump lever to raise the spare
wheel beyond the rear end of the spare
wheel bracket.
\1Carefully remove the spare wheel from
the bracket.The Premium tire sealant is located in the
storage compartment in the right-hand
doorway.
1Latching springs
2Electric air pump
3Premium tire sealant
\1To open: press both latching
springs1 down and remove the cov-
er.
\1To close: attach the cover at the bot-
tom and fold it closed.
\1Press both latching springs1 up until
they engage.Panel Van
The wheel chock (optional for model vehi-
cle type 2500) is on the right-hand side of
the load compartment.
Panel van1Retaining band
2Retainer
\1Pull support cable 1 slightly down-
ward and pull it out of retainer 2.
\1Pull out the wheel chock.
Warning
G
Take care not to trap your fingers when you
lift out the spare wheel.
Premium tire sealant*
Chock!
CAUTION
When storing it away, make sure that
the chock is secured in the retainer by
the retaining band.

320 Practical hintsFlat tire
5
\3 Flat tireThe vehicle is either equipped with a spare
wheel or the Premium tire sealant*.
The spare wheel is located under the rear
end of the vehicle if the vehicle is not
equipped with Premium tire sealant*
(\2page 301).
When you replace a tire, the manufacturer
also recommends that you replace the tire
valve.\1Park the vehicle as far away as possible
from traffic and on a level, firm, and
non-slip surface.
\1Switch on the hazard warning lamps.
\1Apply the handbrake.
\1Engage first gear or reverse gear or
move the selector lever to positionP.
\1Any passengers should leave the vehi-
cle, ensuring that they are not endan-
gered as they do so.
\1Place the warning triangle or hazard
warning lamps at a suitable distance.
Observe legal requirements.Warning
G
Defective or worn tires, and tire pressures
that are either too high or too low, can cause
significant changes in the vehicle’s handling
and braking characteristics. There is an in-
creased risk of an accident.
Replace the tires, including the spare tire, at
least every 6 years, regardless of the degree
of treadwear. Check the tire pressure on the
spare wheel at regular intervals.
!
CAUTION
For safety reasons, the following tire
valves from the company Schrader
must be used on the vehicles:
\4TR 600 for vehicle model type 2500
\4TR 418 for vehicle model type 3500
Preparing the vehicle
Changing a wheelWarning
G
To avoid the risk of causing serious or fatal
injury, or damage to the vehicle, please bear
the following points in mind:
\4The jack is only designed to raise the ve-
hicle for a short time when changing a
wheel.
\4Position the jack under the appropriate
jacking point only (\2page 322). Check
that the jack is correctly seated under
the jacking point before raising the vehi-
cle.
\4The jack must be placed on a firm, flat
surface only.
\2\2

321 Practical hints
Flat tire
5
Preparing the vehicle
Prepare the vehicle as described
(\2page 320).
\1Prevent the vehicle from rolling away
using chocks or similar.
On a level road:
\1Place the chocks in front of and behind
the wheel diagonally opposite to the
wheel that is to be changed.
\1Take the vehicle tool kit and the jack
from the footwell on the co-driver’s
side (\2page 300).
\1Remove the spare wheel from the
spare wheel bracket (\2page 301).
\1For wheels with wheel bolts remove the
wheel cover.
Wheel with wheel bolts\1Loosen the wheel bolts and nuts on the
wheel you wish to change about one
turn. Do not remove them.
As an extension for the wheel wrench,
use the shaft from the jack’s 3-part
pump lever that has the largest diame-
ter.
\4Before raising the vehicle, also secure it
against rolling away, for example using
chocks or similar. Never release the
handbrake while the vehicle is raised.
Make sure that the distance between
the underside of the tires and the
ground does not exceed 1.2 in (3 cm).
The vehicle could slip or topple off the
jack.
\4Do not reach under the raised vehicle
with your hands or feet.
\4Do not start the engine and avoid creat-
ing other vibrations while the vehicle is
jacked up. The vehicle could slip off the
jack.
Warning
G
The vehicle could slip off the jack on uphill
and downhill gradients.
To avoid the risk of causing serious or fatal
injury, or damage to the vehicle, do not
change wheels on uphill and downhill gradi-
ents.
N40.10-2162-31

324 Practical hintsFlat tire
5
Wheels with centering by wheel bolts:
\1Screw in the wheel bolts and tighten
them finger-tight.
1Wheel bolt for light-alloy wheel
2Wheel bolt for steel wheelor wheels with wheel nuts:
For wheels with wheel nuts:
\1Center the wheel nut cover over the
wheel and push it onto the wheel.
\1Screw on the wheel nuts and tighten
them finger tight.
Lowering the vehicle
\1Slowly open the jack’s pressure release
screw one turn using the pump lever
(\2page 322) and lower the vehicle
slowly.
\1Put the jack to one side.Tightening torque pattern
1 – 6 Wheel bolts
\1Tighten all the wheel bolts and wheel
nuts evenly in the sequence indicated.
As an extension for the wheel wrench,
use the shaft from the jack’s 3-part
pump lever that has the largest diame-
ter.
iOn vehicles with light-alloy wheels, you
will find short wheel bolts suitable for
the steel spare wheel in the vehicle tool
kit.N40.10-2175-31
iScrew on the three wheel nuts that
hold the wheel nut cover first.
!
CAUTION
The tightening torque is:
\4for wheel bolts 177 lb-ft (240 Nm)
(steel wheel)/133 lb-ft (180 Nm)
(light-alloy wheel).
\4for wheel nuts 133 lb-ft (180 Nm)

325 Practical hints
Flat tire
5
\1For wheels with wheel bolts attach the
wheel cover.
Vehicles with wheel caps:
Make sure that the opening in the
wheel cap is positioned over the tire
vent.
Vehicles with center caps:
Make sure that the retaining lugs of the
hub cap are positioned over the bolts.
\1Compress the piston of the hydraulic
jack and close the pressure release
screw.
\1Store the jack and the remaining vehi-
cle tools.
\1Place the defective wheel in the spare
wheel bracket after changing the wheel
(\2page 301).
\1Check the tire pressure (\2page 210).
\1Retighten the wheel bolts and wheel
nuts to the specified tightening torque
once the vehicle has been driven for 30
miles (50 km).
iGive the middle of the center cap a
knock to engage it on the wheel.
Warning
G
For safety reasons, you must observe the
following after changing a wheel:
\4Have the tightening torque checked:
\4for wheel bolts 177 lb-ft (240 Nm)
(steel wheel)/133 lb-ft (180 Nm)
(light-alloy wheel) or
\4for wheel nuts
133 lb-ft (180 Nm).
The wheels could otherwise come loose.
\4Check the tire pressure and correct it if
necessary
\4Have the wheel bolts or wheel nuts re-
tightened after 30 miles (50 km) to a
torque of:
\4177 lb-ft (240 Nm) (steel wheel)/
133 lb-ft (180 Nm) (light-alloy
wheel) for wheel bolts or
\4133 lb-ft (180 Nm) for wheel nuts.
\4Have the direction of tire rotation cor-
rected, if reversed, as soon as possible
at an authorized Sprinter Dealer. The ve-
hicle handling characteristics could oth-
erwise be affected.Warning
G
Loose wheel nuts or bolts could cause the
vehicle to lose a wheel while it is in motion.
This would jeopardize the operating and
road safety of the vehicle. You could lose
control of the vehicle as a result, cause an
accident and injure yourself or others.
If new or repainted wheels are mounted, the
wheel bolts or wheel nuts must be retight-
ened again after approximately 600 to 3000
miles (about 1000 to 5000 km).

388 IndexSide lamps
. . . . . . . . . . . . . . . . . . . . 307
Side marker lamps
. . . . . . . . . . . . . 307
changing bulbs
. . . . . . . . . . . . . . . . 312
Side wall
. . . . . . . . . . . . . . . . . . . . . . 230
Side windows
cleaning . . . . . . . . . . . . . . . . . . . . . 244
operating . . . . . . . . . . . . . . . . . . . . 144
Sliding door
closing aid . . . . . . . . . . . . . . . . . . . . 57
electric
. . . . . . . . . . . . . . . . . . . . . . . 57
locking/unlocking
from the inside
. . . . . . . . . . . . . . . 56
opening/closing . . . . . . . . . . . . . . . . 56
Sliding sunroof
. . . . . . . . . . . . . . . . 145
opening/closing manually
. . . . . . . 304
resetting
. . . . . . . . . . . . . . . . . . . . . 146
Sliding sunroof emergency
operation . . . . . . . . . . . . . . . . . . . . . 304
Sliding/tilting sunroof
see Sliding sunroof
Snow chains . . . . . . . . . . . . . . . . . . 236
Spare wheel . . . . . . . . . . . . . . . . . . 301
Speed
adjusting
see Cruise control
Speedometer . . . . . . . . . . . . . . . . . . . 85
setting the unit (vehicles with steering
wheel buttons) . . . . . . . . . . . . . . . . . 99Spinning
see Tires, Direction of rotation
SRS (Supplemental
Restraint System)
. . . . . . . . . . . . . . . 28
display message . . . . . . . . . . . . . . . 288
SRS (Supplemental
Restraint System)
warning lamp
. . . . . . . . . . . . . . . . . 272
Standard seat . . . . . . . . . . . . . . . . . . 69
Standing lamps
changing bulbs . . . . . . . . . . . . . . . . 308
rear
. . . . . . . . . . . . . . . . . . . . . . . . 309
Steering . . . . . . . . . . . . . . . . . . . . . . 116
unlocking . . . . . . . . . . . . . . . . . . . . . 67
Steering column adjustment
. . . . . . 76
Steering lock
see Ignition lock
Steering wheel
adjusting
. . . . . . . . . . . . . . . . . . . . . 76
buttons (vehicle with steering wheel
buttons) . . . . . . . . . . . . . . . . . . . 17
, 89
releasing the lock
. . . . . . . . . . . . . . . 67
Steps
. . . . . . . . . . . . . . . . . . . . . . . . 243
Stickers . . . . . . . . . . . . . . . . . . . . . . . . 8
Storage compartment under the
co-driver's seat
. . . . . . . . . . . . . . . . 164
Storage compartments
. . . . . . . . . .13
,
18
, 164
–166co-driver door
. . . . . . . . . . . . . . . . . 299
cup holder
. . . . . . . . . . . . . . . . . . . 167
driver's door . . . . . . . . . . . . . . . . . . 299
glove box
. . . . . . . . . . . . . . . . . . . . 165
holder for bottled drinks
. . . . . . . . 167
storage compartment above the roof
trim
. . . . . . . . . . . . . . . . . . . . . . . . 164
storage compartment under the co-
driver's seat
. . . . . . . . . . . . . . . . . . 164
storage compartments above the
windshield
. . . . . . . . . . . . . . . . . . . 164
storage compartments in the doors
164
Storing tires
. . . . . . . . . . . . . . . . . . . 204
Submenu
clock/date . . . . . . . . . . . . . . . . . . . 101
convenience . . . . . . . . . . . . . . . . . . 105
instrument cluster
. . . . . . . . . . . . . . 99
lighting
. . . . . . . . . . . . . . . . . . . . . . 102
overview of settings
. . . . . . . . . . . . . 97
selecting
. . . . . . . . . . . . . . . . . . . . . . 97
vehicle
. . . . . . . . . . . . . . . . . . . . . . 104
Surround lighting
see Locator lighting
Suspension seat
. . . . . . . . . . . . . . . . 69
Switch unit
. . . . . . . . . . . . . . . . . . . . . 20
Swivel seat . . . . . . . . . . . . . . . . . . . . . 70