367 *Technical data
Rims and tires
6
\3 Rims and tires
!
CAUTION
Only use tires which have been tested
and approved for your Sprinter vehicle
by the vehicle manufacturer. Tires ap-
proved by the vehicle manufacturer are
developed to provide the best possible
performance in conjunction with the
driving safety systems on your Sprinter
vehicle such as ABS, BAS, ASR or ESP
®.
Using tires other than those approved
by the vehicle manufacturer may result
in damage that is not covered by the
Sprinter warranty.
Using tires other than those approved
by the vehicle manufacturer can have
detrimental effects, such as
\4poor handling characteristics
\4increased noise
\4increased fuel consumption
Moreover, tires and rims not approved
by the vehicle manufacturer may, un-
der load, exhibit dimensional variations
and different tire deformation charac-
teristics that could cause them to come
into contact with the vehicle body or
axle parts. Damage to the tires or the
vehicle may be the result.
Warning
G
Loose wheel nuts or bolts could cause the
vehicle to lose a wheel while it is in motion.
This would jeopardize the operating and
road safety of the vehicle. You could lose
control of the vehicle as a result, cause an
accident an injure yourself or others.
If a wheel was replaced or new wheel nuts
are used, the wheel bolts or wheel nuts must
be retightened to the specified tightening
torque after 30 miles (50 km).
If new or repainted wheels are mounted, the
wheel bolts or wheel nuts must be retight-
ened again to the specified tightening
torque after approximately 600 to 3000
miles (about 1000 to 5000 km).
iFurther information on tires and rims is
available at any authorized Sprinter
Dealer. A placard with the recommend-
ed tire inflation pressures is located on
\4the driver’s door B-pillar for vehi-
cles with a gross weight capacity
less than 10,000 lbs (4500 kg)
(\2page 375)
\4on a label below the driver’s seat on
an outward facing position of the
mounting pillar for vehicles with a
gross weight capacity above
10,000 lbs (4500 kg) (\2page 375)
The tire inflation pressure should be
checked regularly and should only be
adjusted on cold tires.
368 *Technical dataRims and tires
6
Vehicle Model Type
2500
3500
Rims (steel)
6.5 J x 16
5.5 J x 16
Rims (light alloy)
6.5 J x 16
–
Wheel offset
2.13 in (54 mm)
–
Half dual spacing
4.82 in (122.5 mm)
Wheel fixture
Wheel bolts
Wheel nuts
Tightening torque (steel wheel)
177 lb-ft (240 Nm)
133 lb-ft (180 Nm)
Tightening torque (light-alloy wheel)
133 lb-ft (180 Nm)
-
Summer tires
–
–
All-season tires
1
1 Radial-ply tires
LT 245/75 R16 120/116L
LT 215/85 R16 115/112N
LT 215/85 R16 115/112Q
LT 245/75 R16 120/116N
Winter tires
2
2 Radial-ply tires
LT 245/75 R16 120/116L M+S .
LT 215/85 R16 115/112N M+S .
LT 245/75 R16 120/116N M+S .
389 Index
T
Tachometer
. . . . . . . . . . . . . . . . . . . . 85
Tail lamps
. . . . . . . . . . . . . . . . . . . . 309
changing bulbs
. . . . . . . . . . . . . . . 310
perimeter lamp . . . . . . . . . . . . . . . 309
Tank
flap
. . . . . . . . . . . . . . . . . . . . . . 86
, 184
malfunction
. . . . . . . . . . . . . . 251
–252
reserve fuel, display message
. . . . 297
Technical Data
Tire inflation pressure
. . . . . . . . . . 369
Telephone
. . . . . . . . . . . . . . . . 171
, 183
display message
. . . . . . . . . . . . . . 291
hands-free microphone
. . . . . . . . . . 19
operating
(vehicles with steering wheel
buttons)
. . . . . . . . . . . . . . . . . . . . . 107
retrofitting . . . . . . . . . . . . . . . . . . . 354
Temperature
setting the unit
(vehicles with steering wheel
buttons)
. . . . . . . . . . . . . . . . . . . . . . 99
Tempmatic . . . . . . . . . . . . . . . . . . . . 129
air distribution
. . . . . . . . . . . . 129
, 133
air vents
in the dashboard
. . . . . . . . . . . . 129
airflow
. . . . . . . . . . . . . . . . . . . . . . 133air-recirculation mode
. . . . . . . . . . 133
control panel
. . . . . . . . . . . . . . . . . 131
defrosting
. . . . . . . . . . . . . . . . . . . 135
economy mode
. . . . . . . . . . . . . . . 131
fogged-up windows
. . . . . . . . . . . . 134
reheat function (dehumidification)
. 134
residual heat
. . . . . . . . . . . . . . . . . 134
special settings . . . . . . . . . . . . . . . 134
ventilation/cooling
. . . . . . . . . . . . 132
The first 1,500 km . . . . . . . . . . . . . 174
Thorax sidebag
. . . . . . . . . . . . . . . . . 34
Tightening torque
wheel nuts/wheel bolts
. . . . . . . . . 324
TIN
. . . . . . . . . . . . . . . . . . . . . . 225
, 230
Tire and loading information
placard
. . . . . . . . . . . . . . . . . . . . . . 205
terminology
. . . . . . . . . . . . . . . . . . 228
Tire and loading information
placard
. . . . . . . . . . . . . . . . . . . . . . . 375
Tire Identification Number
see TIN
Tire inflation pressure
. . . . . . . . . . 369
checking manually
. . . . . . . . . . . . . 213
Checking tire pressure electronically
with the Advanced Tire Pressure Monito-
ring System (Advanced TPMS)*,
(Canada only)
. . . . . . . . . . . . . . . . . 217Checking tire pressure electronically
with the Tire Pressure Monitoring
System (TPMS)
. . . . . . . . . . . . . . . 214
recommended tire inflation
pressure
. . . . . . . . . . . . . . . . . . . . . 210
setting the unit
(vehicles with steering wheel
buttons) . . . . . . . . . . . . . . . . . . . . . 100
table
. . . . . . . . . . . . . . . . . . . . . . . . 370
Tire valves
. . . . . . . . . . . . . . . . . . . . 201
Tires
. . . . . . . . . . . . . . . . . . . . . 199
, 212
Advanced Tire Pressure Monitoring
System (Advanced TPMS)*,
(Canada only)
. . . . . . . . . . . . . . . . . 217
air pressure
. . . . . . . . . . . . . . . . . . 228
alignment and balance
. . . . . . . . . . 120
care and maintenance . . . . . . . . . . 202
damage
. . . . . . . . . . . . . . . . . . . . . 202
direction of rotation, spinning
. . . . 204
driving instructions
. . . . . . . . . . . . 117
important guidelines . . . . . . . . . . . 201
inflation pressure
. . . . . . . . . . 210
, 213
information placard
. . . . . . . . . . . . 205
inspection
. . . . . . . . . . . . . . . . . . . 202
load limit information
. . . . . . . . . . . 206
load rating
. . . . . . . . . . 222
, 223
, 230
loading Information
. . . . . . . . . . . . 205
loading terminology . . . . . . . . . . . . 228
T
391 Index
closing
. . . . . . . . . . . . . . . . . . . . . . . 52
correct use
. . . . . . . . . . . . . . . . . . . . 7
data cards . . . . . . . . . . . . . . . . . . . 373
identification number
. . . . . . . . . . 373
leaving in storage
. . . . . . . . . . . . . 265
locking with key
. . . . . . . . . . . . . . . . 55
locking/unlocking centrally
. . . . . . . 64
opening
. . . . . . . . . . . . . . . . . . . . . . 52
with remote control
. . . . . . . . . . . 54
with the key
. . . . . . . . . . . . . . . . . 54
registering
. . . . . . . . . . . . . . . . . . . . . 5
towing
. . . . . . . . . . . . . . . . . . . . . . 342
towing out
. . . . . . . . . . . . . . . . . . . 343
tow-starting . . . . . . . . . . . . . . . . . . 341
transporting . . . . . . . . . . . . . . . . . . 344
Vehicle alteration
. . . . . . . . . . . . . . . . 6
Vehicle capacity weight
. . . . . . . . . 231
Vehicle identification plates
. . . . . 373
Vehicle loading
load limit
. . . . . . . . . . . . . . . . . . . . 206
loading terminology
. . . . . . . . . . . . 228
terminology
. . . . . . . . . . . . . . . . . . 228
Vehicle maximum load
on the tire
. . . . . . . . . . . . . . . . . . . . 231
Vehicle safety certification label
. 373
Vehicle tool kit
. . . . . . . . . . . . . . . . 300
Vehicle/engine emission label
. . . 375
W
Warning labels
. . . . . . . . . . . . . . . . . . 8
Warning lamp
ESP
®/ASR
. . . . . . . . . . . . . 43
, 44
, 268
warning lamp
. . . . . . . . . . . . . . . . . 299
Warning triangle . . . . . . . . . . . . . . . 299
Warranty information
. . . . . . . . . . . . . 5
Washer fluid
. . . . . . . . . . . . . . . . . . 127
adding
. . . . . . . . . . . . . . . . . . . . . . 193
Water separator
draining the fuel filter
. . . . . . . . . . 317
Wheel
. . . . . . . . . . . . . . . . . . . . . . . . 117
changing
. . . . . . . . . . . . . . . . . . . . 320
Wheel nuts/wheel bolts
retightening . . . . . . . . . . . . . . . . . . 324
tightening torque
. . . . . . . . . . . . . . 324
Wheel, tires and
. . . . . . . . . . . . . . . 199
Windows
cleaning the rear window
. . . . . . . . 244
cleaning the side windows . . . . . . . 244
cleaning the windshield
. . . . . . . . . 243
fogged-up
. . . . . . . . . . . . . . . . . . . . 134
power windows
. . . . . . . . . . . . . . . 144
washer fluid
. . . . . . . . . . . . . . . . . . 127Windshield
cleaning
. . . . . . . . . . . . . . . . . . . . . 243
heating . . . . . . . . . . . . . . . . . . 127
, 134
malfunction
. . . . . . . . . . . . . . . . 266
Windshield heating
. . . . . . . . . . . . . 127
Windshield washer fluid
display message
. . . . . . . . . . 287
, 298
wiping with
. . . . . . . . . . . . . . . . . . . 127
Windshield washer system
. . . . . . 193
indicator lamp
. . . . . . . . . . . . . . . . 280
rain sensor
. . . . . . . . . . . . . . . . . . . 126
Windshield wipers
. . . . . . . . . . . . . 126
cleaning
. . . . . . . . . . . . . . . . . . . . . 243
intermittent wipe
. . . . . . . . . . . . . . 126
malfunctions
. . . . . . . . . . . . . . . . . 258
rain sensor
. . . . . . . . . . . . . . . 126
, 127
setting the sensitivity (vehicles with
steering wheel buttons)
. . . . . . . 105
rear window wiper
. . . . . . . . . . . . . 127
replacing the wiper blades
. . . . . . . 319
windshield washer fluid
. . . . . . . . . 127
Winter driving
. . . . . . . . . . . . . 234
, 235
snow chains
. . . . . . . . . . . . . . . . . . 236
Winter operation
tires
. . . . . . . . . . . . . . . . . . . . . . . . 234
Wiper blades
. . . . . . . . . . . . . . . . . . 319
Working on the vehicle
. . . . . . . . . 124
W