2007 CHEVROLET KODIAK power steering fluid

Engine Overheating................................... 288
Cooling System (Gas and
DURAMAX
®/Isuzu Engines).................... 290
Engine Fan Noise..................................... 294
Power Steering Fluid................................. 295
Windshield Washer Fluid........................... 296
Brakes...................................................... 297
Battery...................................................... 304
Jump Starting............................................ 305
Rear Axle.................................................... 311
Rear Axle Shift Motor................................ 312
Four-Wheel Drive........................................ 312
Front Axle................................................... 313
Noise Control System................................. 314
Tampering with Noise Control System
Prohibited.............................................. 314
Bulb Replacement....................................... 315
Windshield Wiper Blade Replacement....... 316Other Service Items.................................... 317
Fuel Filter.................................................. 317
Primary Fuel Filter and Water Separator...... 317
Secondary Fuel Filter and Water
Separator/Heater (Caterpillar
®Diesel)...... 318
Automatic Ether Injection System
(Caterpillar
®Diesel)................................ 318
Front Wheel Bearings with
Oil-Filled Hubs....................................... 319
Air Conditioning System............................ 320
Tires............................................................ 321
Inflation - Tire Pressure............................. 322
Wheel Loading.......................................... 323
Dual Tire Operation................................... 323
When It Is Time for New Tires.................. 324
Wheel Alignment and Tire Balance............ 324
Tightening the Wheel Nuts........................ 325
Wheel Replacement.................................. 328
If a Tire Goes Flat.................................... 330
Section 5 Service and Appearance Care
246

Power Steering Fluid
SeeScheduled Maintenance on page 363to
determine when to check your power steering fluid.
How To Check Power Steering Fluid
Check your power steering fluid only when the
engine is warm. If the engine is not warm, you
probably will not get an accurate reading.
If the fluid level is between the MIN (Minimum) and
MAX (Maximum) marks, you have enough. If you
need fluid, add only enough of the proper fluid to
bring it in between the MIN and MAX marks.
If your power steering fluid level is low, this can
cause the brake or service brakes soon warning
lights to come on. In addition, the steering
effort and emergency brake distance could
increase.If either light remains on after you have added
power steering fluid to the proper level, then shut
off the engine for 10 seconds. This should
reset the brake warning lights. If one or both lights
stay on, see “Hydraulic Brake System Warning
Lights” underBrake System Warning Light
on page 169for more information.
What to Use
To determine what kind of fluid to use, see
Part C: Recommended Fluids and Lubricants on
page 397.
Notice:When adding power steering uid or
making a complete uid change, always
use the proper uid. Failure to use the proper
uid can cause leaks and damage hoses
and seals.
295

Part GM Part Number ACDelco®Part Number
Engine Oil Filter
6.6L 88917036 PF2232
7.2L — 1R-1807††
Isuzu 6H 94037791 —
8.1L 25324052 PF454
Fuel Filter
6.6L 97385488 TP1298A
7.2L — 1R-0751††
Isuzu 6H 94392474 —
8.1L (NG6/NK1) 21998364 —
8.1L (All others) — S3202†
Power Steering Fluid Filter 88892858 —
Secondary Fuel Filter
6.6L — —
7.2L 25014274 TP915D
7.2L (KUK) 88983117 TP1519
7.2L (NWB) 15618921 —
Isuzu 6H 25014274 TP915D
Isuzu 6H (KUK) 88983117 TP1519
8.1L (K28 and standard U-Haul) 25014476 TP1247
353

Usage Fluid/Lubricant
Engine Coolant
(Gasoline
Engine &
DURAMAX
®/
Isuzu Diesel)50/50 mixture of clean, drinkable
water and use only DEX-COOL
®
Coolant. SeeEngine Coolant (Gas
and DURAMAX®/Isuzu Engines)
on page 284orEngine Coolant
(Caterpillar
®Diesel Engines)
on page 287.
Hydraulic Brake
SystemDelco
®Supreme 11 Brake Fluid
or equivalent DOT-3 brake fluid.
Windshield
Washer SolventGM Optikleen
®Washer Solvent.
Clutch Bearing
LubricantClutch Bearing Lubricant
(GM Part No. 12378484 or
equivalent NLGI #3 consistency).
Exhaust Brake
Ball Joint Cap
LubricantHigh-Temperature Grease
(GM Part No. U.S. 1051344,
in Canada 903037) or
NLGI #3 consistency.
Usage Fluid/Lubricant
Power Steering
SystemDEXRON
®-VI Automatic
Transmission Fluid.
Manual
TransmissionSynthetic Manual Transmission
Fluid (GM Part No. U.S. 12345724,
in Canada 10953510).
Automatic
TransmissionSee the Allison Transmission
®
Operator’s Manual for correct
transmission fluid.
Key Lock
CylindersMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241,
in Canada 10953474).
Chassis
LubricationChassis Lubricant
(GM Part No. U.S. 12377985,
in Canada 88901242) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
398

Flashers, Hazard Warning........................... 142
Flat Tire...................................................... 330
Fluid
Automatic Transmission............................ 282
Manual Transmission................................ 283
Power Steering........................................ 295
Windshield Washer.................................. 296
Four-Wheel Drive...............................119, 312
Front Axle................................................... 313
Front Wheel Bearings with Oil-Filled Hubs ... 319
Fuel............................................................ 251
Additives.................................................. 252
Diesel Engine Fuel................................... 253
Filling a Portable Fuel Container.............. 266
Filling Your Tank...................................... 264
Filter........................................................ 317
Filter Replacement................................... 263
Fuels in Foreign Countries....................... 264
Gage....................................................... 181
Gasoline Octane...................................... 251
Gasoline Specifications............................ 251
Primary Filter and Water Separator.......... 317
Running Out of Fuel................................ 262
Secondary Filter and Water Separator/
Heater.................................................. 318
Very Cold Weather Operation................... 256
Water in Fuel........................................... 256Fuel (cont.)
Water in Warning Light............................ 182
What Fuel to Use.................................... 253
Fuses
Fuses and Circuit Breakers...................... 341
Instrument Panel Fuse Block................... 342
Underhood Fuse Block............................. 344
Windshield Wiper..................................... 341
G
Gage
Air Pressure............................................. 183
Check Gages Warning Light..................... 180
Engine Coolant Temperature.................... 173
Filter Minder............................................ 182
Fuel......................................................... 181
Hourmeter................................................ 183
Oil Pressure............................................. 175
Speedometer........................................... 163
Tachometer.............................................. 163
Transmission Temperature........................ 178
Voltmeter Gage........................................ 168
Gasoline
Octane..................................................... 251
Specifications........................................... 251
Gasoline Engine, Starting.............................. 97
GM Mobility Reimbursement Program.......... 407
422

Other Service Items (cont.)
Primary Fuel Filter and Water
Separator............................................. 317
Secondary Fuel Filter and Water
Separator/Heater................................... 318
Other Warning Devices................................ 142
Outlet Adjustment........................................ 160
Outlet(s), Accessory Power.......................... 156
Outside
Convex Mirrors........................................ 134
Heated Mirrors......................................... 134
Manual Mirrors......................................... 133
Power Mirrors.......................................... 133
Overspeed Warning Light............................ 177
Owners, Canadian.......................................... 3
P
Paint, Damage............................................ 338
Parking....................................................... 125
Brake..............................................125, 126
Brake Burnish Procedure......................... 128
Over Things That Burn............................ 130
Part A - Scheduled Maintenance Services.... 362
Part B - Owner Checks and Services........... 391
Part C - Recommended Fluids and
Lubricants................................................ 397Part D - Maintenance Record...................... 400
Passing....................................................... 220
Power
Accessory Outlet(s).................................. 156
Door Locks................................................ 92
Electrical System..................................... 341
Reduced Engine Light.............................. 179
Steering Fluid.......................................... 295
Windows.................................................... 94
Power Take-Off (PTO)................................. 118
Q
Questions and Answers About Safety Belts ... 25
R
Radios........................................................ 184
AM-FM Radio.......................................... 186
Care of Your Cassette Tape Player.......... 202
Care of Your CD Player........................... 204
Care of Your CDs.................................... 203
Radio with Cassette................................. 189
Radio with CD......................................... 195
Setting the Time...................................... 185
Theft-Deterrent......................................... 201
Understanding Reception ......................... 201
426