2007 CHEVROLET KODIAK charging

•If the engine coolant temperature gage needle
goes into the hot area on the gage, stop the
engine and find the cause of the overheating.
SeeEngine Coolant Temperature Gage on
page 173for more information.
•If you have air brakes, the dual-needle air
pressure gage should read at least 115 psi
(790 kPa) for both service systems before you
try to move the vehicle. When air pressure
is below 60 psi (420 kPa), the LOW AIR light
will come on and you will hear a tone
alarm. SeeBrake System Warning Light on
page 169for more information. If the pressure
does not build up or drops during warm-up,
stop the engine and find the cause before you
try to move the vehicle. Recommended air
pressure before driving is 120 psi (830 kPa).
SeeAir Pressure Gage on page 183for
more information.
•The charging system light should come on
when the ignition key is turned to RUN or
START and should go out when the engine is
running above idle. If the light does not go
out or comes back on during normal engine
operation, have the charging system checked
right away. (This light tells you if thegenerator is not charging; it does not reflect
the condition of the battery.) SeeCharging
System Light on page 167for more
information.
•The voltmeter charge indicator gage tells you
the condition of your battery’s charge. The
gage should be in the center area during
engine operation. The red area on the
left indicates an undercharge condition; the
red area on the right indicates an overcharge.
If the gage is in either red area, have the
battery and charging system checked
right away. SeeVoltmeter Gage on page 168
for more information.
Notice:Do not allow the engine to operate at
low idle for more than ve minutes. This
can cause low engine operating temperatures
which can affect engine operation and
reduce engine life. Engine idle speed should
be increased to 1200 rpm whenever extended
idle is required. Once started, the engine
should be placed under load to allow the
engine coolant temperature to reach 150°F
(66°C) before shutting off the engine.
110

Instrument Panel Overview........................ 140
Hazard Warning Flashers.......................... 142
Other Warning Devices............................. 142
Horn.......................................................... 142
Tilt Wheel.................................................. 142
Turn Signal/Multifunction Lever.................. 143
Turn and Lane-Change Signals................. 144
Headlamp High/Low-Beam Changer.......... 144
Windshield Wipers..................................... 145
Windshield Washer.................................... 146
Cruise Control........................................... 146
Exterior Lamps.......................................... 150
Headlamps on Reminder........................... 150
Daytime Running Lamps (DRL)................. 151
Marker Lamps........................................... 152
Instrument Panel Brightness...................... 152
Dome Lamps............................................. 153
Entry Lighting............................................ 154
Reading Lamps......................................... 154
Instrument Panel Switchbank..................... 154
Accessory Power Outlet(s)........................ 156
Ashtray(s) and Cigarette Lighter................ 157Climate Controls......................................... 157
Climate Control System............................. 157
Outlet Adjustment...................................... 160
Rear Heating System................................ 161
Warning Lights, Gages, and Indicators..... 161
Instrument Panel Cluster........................... 162
Speedometer and Odometer...................... 163
Trip Odometer........................................... 163
Tachometer............................................... 163
Engine Speed Limiter................................ 164
Safety Belt Reminder Light........................ 164
Safety Belt Reminder Tone....................... 164
Airbag Readiness Light............................. 165
Airbag Off Light......................................... 166
Charging System Light.............................. 167
Voltmeter Gage......................................... 168
Service Transmission Warning Light.......... 168
Range Inhibit Warning Indicator................. 169
Brake System Warning Light..................... 169
Anti-Lock Brake System Warning Light...... 172
Trailer Anti-Lock Brake System
Warning Light........................................ 172
Section 3 Instrument Panel
137

{CAUTION:
If the airbag readiness light ever comes
on when you have turned off the airbag, it
means that something may be wrong with
the airbag system. The right front
passenger’s airbag could inate even
though the switch is off. If this ever
happens, do not let anyone whom the
national government has identied as a
member of a passenger airbag risk group
sit in the right front passenger’s position
(for example, do not secure a rear-facing
child restraint in the right front
passenger’s seat) until you have your
vehicle serviced. SeeAirbag Off Switch on
page 76andAirbag Readiness Light on
page 165for more on this, including
important safety information.
Charging System Light
The charging system
light may be located in
the instrument panel
cluster, or with the
auxiliary warning lights
in the center of the
instrument panel.
It should come on briefly when you turn on the
ignition, before the engine is running, as a check to
show that it is working.
If it stays on, or comes on while you are driving,
have your vehicle checked right away. You
could have a loose generator drive belt or some
other problem.
Driving while this light is on will drain your battery.
If you must drive a short distance with the light
on, turn off your radio and other accessories.
Sustained driving with a generator failure could
result in a lack of back-up braking if the engine
quits or the power steering pump should fail.
167

Voltmeter Gage
When your engine is
running, the voltmeter
gage shows the
charging system
voltage.
Readings in either warning zone indicate a
possible problem in the electrical system.
Readings in the low warning zone may occur
when a large number of electrical accessories are
operating in the vehicle and the engine is left at
an idle for an extended period. This condition
is normal since the charging system may not be
able to provide full power at engine idle. As engine
speeds are increased, this condition should
correct itself because higher engine speeds allow
the charging system to create maximum power.You can only drive a short time on the battery.
Be sure to shut off the radio, the fan or any
unnecessary accessories and have the system
serviced.
Service Transmission Warning Light
If your vehicle has an Allison®automatic
transmission, certain transmission malfunctions
will turn this light on.
This light is located with
the auxiliary warning
lights in the center of the
instrument panel.
If this light comes on while you are driving, do not
use the transmission shift control or you may
lose forward gears. The computer for the
transmission senses a problem and chooses a
gear to stay in so that you can drive the vehicle in
that gear. You may not be able to drive as fast
or back up when this light is on.
168

Care of
Safety Belts............................................. 334
Your Cassette Tape Player....................... 202
Your CD Player........................................ 204
Your CDs ................................................. 203
Center Console Storage Area...................... 135
Center Passenger Position, Safety Belts........ 37
Charging System Light................................ 167
Check
Engine Light............................................ 174
Gages Warning Light............................... 180
Checking Things Under the Hood................ 266
Chemical Paint Spotting.............................. 338
Child Restraints
Child Restraint Systems............................. 49
Infants and Young Children........................ 45
Lower Anchors and Tethers for Children..... 57
Older Children........................................... 42
Securing a Child Restraint in a Rear
Outside Seat Position............................. 58
Securing a Child Restraint in the Center
Rear Seat Position (Crew Cab) or
Center Front Position.............................. 60
Securing a Child Restraint in the Right
Front Seat Position................................. 63
Where to Put the Restraint................. 54, 55
Chime Level Adjustment.............................. 204Cigarette Lighter.......................................... 157
Cleaning
Aluminum or Chrome-Plated Wheels........ 337
Exterior Lamps/Lenses............................. 335
Fabric/Carpet........................................... 333
Finish Care.............................................. 335
Inside of Your Vehicle .............................. 331
Instrument Panel, Vinyl, and Other
Plastic Surfaces.................................... 334
Tires........................................................ 337
Underbody Maintenance........................... 338
Washing Your Vehicle .............................. 335
Weatherstrips........................................... 334
Windshield and Wiper Blades................... 336
Climate Control System............................... 157
Outlet Adjustment..................................... 160
Rear Heating System............................... 161
Collision Damage Repair............................. 410
Control of a Vehicle..................................... 210
Coolant
Engine Temperature Gage........................ 173
Heater, Engine......................................... 111
Low Warning Light................................... 173
Surge Tank Pressure Cap........................ 288
Cooling System........................................... 290
Cruise Control............................................. 146
419

L
Lamps
Dome....................................................... 153
Exterior.................................................... 150
Marker..................................................... 152
Reading................................................... 154
LATCH System
Child Restraints......................................... 57
Light
Airbag Off................................................ 166
Airbag Readiness..................................... 165
Anti-Lock Brake System Warning............. 172
Brake System Warning............................. 169
Change Engine Oil................................... 176
Charging System..................................... 167
Check Gages Warning............................. 180
Daytime Running Lamps Indicator............ 179
Differential Lock Indicator......................... 178
Engine Overspeed Warning...................... 177
Engine Shutdown Warning....................... 177
Exhaust Brake Indicator........................... 178
Highbeam On.......................................... 179
Low Coolant Warning............................... 173
Low Oil Level........................................... 176
Low Washer Fluid Warning...................... 180
Malfunction Indicator................................ 174Light (cont.)
Range Inhibit Warning Indicator................ 169
Reduced Engine Power............................ 179
Safety Belt Reminder............................... 164
Safety Belt Reminder Tone...................... 164
Service Transmission Warning.................. 168
Trailer Anti-Lock Brake System Warning ... 172
Wait to Start Indicator.............................. 174
Water in Fuel Warning............................. 182
Lighting
Entry........................................................ 154
Loading Your Vehicle................................... 238
Locks
Door.......................................................... 91
Power Door............................................... 92
Loss of Control........................................... 221
Low Coolant Warning Light.......................... 173
Low Washer Fluid Warning Light................. 180
M
Maintenance, Normal Replacement Parts.... 352
Maintenance Schedule
At Each Fuel Fill...................................... 391
At Least Once a Year.............................. 396
At Least Twice a Year.............................. 392
How This Section is Organized................ 360
424