2007 CHEVROLET HHR transaxle fluid

BRAKE FLUID
This message displays to inform the driver that the
brake uid level is low while the ignition is on.
The brake system warning light on the instrument
panel cluster also comes on. SeeBrake System
Warning Light on page 185for more information.
Have the brake system serviced by your dealer
as soon as possible.
CHANGE OIL SOON
This message displays when the life of the engine
oil has expired and it should be changed.
When you acknowledge the CHANGE OIL SOON
message by clearing it from the display, you
still must reset the engine oil life system
separately. SeeEngine Oil Life System on
page 302andScheduled Maintenance on
page 393for more information.
CHECK GAS CAP
This message displays if the fuel cap has not
been fully tightened. Recheck the fuel cap to make
sure that it is on properly. A few driving trips
with the cap properly installed should turn
the message off.
COOLING MODE ON
This message may display on some vehicles.
Under severe conditions, hot ambient
temperatures, steep grades, and towing, your
vehicle may experience more transaxle shifting.
This is temporary and normal under these
conditions. This does not require engine or
transaxle service.
CRUISE ENGAGED
This message displays when the cruise control
system is active. SeeCruise Control on page 160
for more information.
DOOR AJAR
This message displays if one or more of the
vehicle’s doors are not closed properly. When this
message displays, make sure that the door(s)
are closed completely.
ENGINE DISABLED
This message displays if the starting of the engine
is disabled. Have your vehicle serviced by your
dealer immediately.
198

Service........................................................ 289
Accessories and Modications................... 289
California Proposition 65 Warning.............. 290
Doing Your Own Service Work.................. 290
Adding Equipment to the Outside of
Your Vehicle.......................................... 291
Fuel............................................................. 291
Gasoline Octane........................................ 291
Gasoline Specications.............................. 292
California Fuel........................................... 292
Additives................................................... 292
Fuels in Foreign Countries........................ 293
Filling the Tank......................................... 294
Filling a Portable Fuel Container............... 296
Checking Things Under the Hood.............. 296
Hood Release........................................... 297
Engine Compartment Overview.................. 298
Engine Oil................................................. 299
Engine Oil Life System.............................. 302
Engine Air Cleaner/Filter............................ 304
Automatic Transaxle Fluid......................... 305
Manual Transaxle Fluid............................. 305
Hydraulic Clutch........................................ 306
Engine Coolant.......................................... 306Pressure Cap............................................ 309
Engine Overheating................................... 309
Cooling System......................................... 312
Windshield Washer Fluid........................... 316
Brakes...................................................... 317
Battery...................................................... 320
Jump Starting............................................ 320
Headlamp Aiming........................................ 327
Bulb Replacement....................................... 330
Halogen Bulbs........................................... 330
Headlamps, Front Turn Signal, and
Parking Lamps....................................... 330
Center High-Mounted Stoplamp (CHMSL) ... 331
Taillamps, Turn Signal, Stoplamps and
Back-up Lamps...................................... 332
License Plate Lamp................................... 334
Replacement Bulbs................................... 334
Windshield Wiper Blade Replacement....... 335
Tires............................................................ 336
Tire Sidewall Labeling............................... 337
Tire Terminology and Denitions............... 340
Ination - Tire Pressure............................. 344
Tire Inspection and Rotation...................... 345
Section 5 Service and Appearance Care
287

{CAUTION:
Operating the engine with the air
cleaner/lter off can cause you or others
to be burned. The air cleaner not only
cleans the air; it helps to stop ames if
the engine backres. If it is not there and
the engine backres, you could be
burned. Do not drive with it off, and be
careful working on the engine with the air
cleaner/lter off.
Notice:If the air cleaner/lter is off, a backre
can cause a damaging engine re. And, dirt
can easily get into your engine, which will
damage it. Always have the air cleaner/lter in
place when you are driving.
Automatic Transaxle Fluid
It is not necessary to check the transaxle uid
level. A transaxle uid leak is the only reason for
uid loss. If a leak occurs, take your vehicle to
the dealership service department and have
it repaired as soon as possible.
Change the uid and lter at the intervals listed in
Additional Required Services on page 396, and
be sure to use the transaxle uid listed in
Recommended Fluids and Lubricants on page 403.
Notice:Use of the incorrect automatic
transaxle uid may damage your vehicle, and
the damages may not be covered by your
warranty. Always use the automatic transaxle
uid listed inRecommended Fluids and
Lubricants on page 403.
Manual Transaxle Fluid
It is not necessary to check the transaxle uid
level. A transaxle uid leak is the only reason for
uid loss. If a leak occurs, take the vehicle to
the dealer and have it repaired as soon as
possible. SeeRecommended Fluids and
Lubricants on page 403for the proper uid to use.
305

(h)Change automatic transaxle fluid and filter if
the vehicle is mainly driven under one or more of
these conditions:
In heavy city traffic where the outside
temperature regularly reaches 90°F (32°C) or
higher.
In hilly or mountainous terrain.
When doing frequent trailer towing.
Uses such as found in taxi, police, or delivery
service.
If you do not use your vehicle under any of these
conditions, the fluid and filter do not require
changing.
(i)Drain, flush, and refill cooling system. This
service can be complex; you should have
your dealer perform this service. See Engine
Coolant on page 306 for what to use. Inspect
hoses. Clean radiator, condenser, pressure cap,
and filler neck. Pressure test the cooling
system and pressure cap.
(j)A fluid loss in any vehicle system could indicate
a problem. Have the system inspected and
repaired and the fluid level checked. Add fluid
if needed.(k)If you drive regularly under dusty conditions,
inspect the filter at each engine oil change.
(l)If you drive regularly under dusty conditions,
the filter may require replacement more often.
(m)Visually inspect belt for fraying, excessive
cracks, or obvious damage. Replace belt if
necessary.
Owner Checks and Services
These owner checks and services should be
performed at the intervals specied to help
ensure the safety, dependability, and emission
control performance of your vehicle. Your
GM Goodwrench
®dealer can assist you with
these checks and services.
Be sure any necessary repairs are completed at
once. Whenever any uids or lubricants are added
to your vehicle, make sure they are the proper
ones, as shown inRecommended Fluids and
Lubricants on page 403.
398

Recommended Fluids and
Lubricants
Fluids and lubricants identied below by name,
part number, or specication may be obtained from
your dealer.
Usage Fluid/Lubricant
Engine OilEngine oil which meets GM
Standard GM6094M and displays
the American Petroleum Institute
Certied for Gasoline Engines
starburst symbol. GM Goodwrench
®
oil meets all the requirements for
your vehicle. To determine the
proper viscosity for your vehicle’s
engine, seeEngine Oil on page 299.
Engine Coolant50/50 mixture of clean, drinkable
water and use only DEX-COOL
®
Coolant. SeeEngine Coolant on
page 306.
Usage Fluid/Lubricant
Hydraulic Brake
SystemDelco®Supreme 11 Brake Fluid or
equivalent DOT-3 brake uid.
Hydraulic
Clutch SystemDelco
®Supreme 11 Brake Fluid or
equivalent DOT-3 brake uid.
Windshield
WasherOptikleen
®Washer Solvent.
Parking Brake
Cable GuidesChassis Lubricant
(GM Part No. 12377985, in
Canada 88901242) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Manual
TransaxleManual Transmission Fluid
(GM Part No. U.S. 88861800,
in Canada 88861801).
Automatic
TransaxleDEXRON
®-VI Automatic
Transmission Fluid.
403

Usage Fluid/Lubricant
Key Lock
CylindersMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241,
in Canada 10953474).
Manual
Transaxle Shift
LinkageChassis Lubricant
(GM Part No. U.S. 12377985,
in Canada 88901242) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Chassis
LubricationChassis Lubricant
(GM Part No. U.S. 12377985,
in Canada 88901242) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.Usage Fluid/Lubricant
Hood Latch
Assembly,
Secondary
Latch, Pivots,
Spring Anchor,
and
Release PawlLubriplate Lubricant Aerosol
(GM Part No. U.S. 12346293,
in Canada 992723) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Hood and Door
HingesMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241,
in Canada 10953474).
Weatherstrip
ConditioningWeatherstrip Lubricant
(GM Part No. U.S. 3634770,
in Canada 10953518) or Dielectric
Silicone Grease
(GM Part No. U.S. 12345579,
in Canada 992887).
404

Audio System(s) (cont.)
Fixed Mast Antenna................................. 236
Radio with CD................................210, 215
Setting the Time..............................207, 208
Theft-Deterrent Feature............................ 233
Understanding Radio Reception............... 234
XM™ Satellite Radio Antenna System...... 236
Automatic Door Lock................................... 105
Automatic Headlamp System....................... 165
Automatic Transaxle
Fluid........................................................ 305
Operation................................................. 122
B
Battery........................................................ 320
Electric Power Management..................... 168
Run-Down Protection............................... 168
Before Leaving on a Long Trip.................... 260
Brake
Anti-Lock Brake System (ABS)................. 243
Emergencies............................................ 245
Parking.................................................... 127
System Warning Light.............................. 185
Brakes........................................................ 317
Braking....................................................... 242
Braking in Emergencies............................... 245Break-In, New Vehicle................................. 115
Bulb Replacement....................................... 330
Center High-Mounted
Stoplamp (CHMSL)............................... 331
Halogen Bulbs......................................... 330
Headlamp Aiming..................................... 327
Headlamps, Front Turn Signal, and
Parking Lamps..................................... 330
License Plate Lamps................................ 334
Replacement Bulbs.................................. 334
Taillamps, Turn Signal, Stoplamps
and Back-up Lamps.............................. 332
Buying New Tires........................................ 347C
Calibration..........................................134, 136
California Fuel............................................. 292
California Proposition 65 Warning................ 290
Canadian Owners........................................... 3
Capacities and Specications...................... 386
Carbon Monoxide......................106, 132, 264,
276, 277
Care of
Safety Belts............................................. 373
Your CD Player........................................ 235
Your CDs ................................................. 235
CD, MP3 ..................................................... 226
434

E
Electric Power Management........................ 168
Electrical System
Add-On Equipment................................... 380
Engine Compartment Fuse Block............. 383
Floor Console Fuse Block........................ 381
Fuses and Circuit Breakers...................... 381
Headlamp Wiring..................................... 380
Power Windows and Other Power
Options................................................. 380
Windshield Wiper Fuses........................... 380
Engine
Air Cleaner/Filter...................................... 304
Battery..................................................... 320
Check and Service Engine Soon Light..... 188
Coolant.................................................... 306
Coolant Heater......................................... 121
Coolant Temperature Gage...................... 188
Coolant Temperature Warning Light.......... 187
Drive Belt Routing.................................... 406
Engine Compartment Overview................ 298
Exhaust................................................... 132
Oil ........................................................... 299
Oil Life System........................................ 302
Overheating............................................. 309
Starting.................................................... 119Enhanced Traction System (ETS) ................ 246
Warning Light........................................... 187
Entry/Exit Lighting....................................... 167
Event Data Recorders (EDR)...................... 423
Extender, Safety Belt..................................... 42
F
Filter
Engine Air Cleaner................................... 304
Finish Damage............................................ 377
Fixed Mast Antenna.................................... 236
Flashers, Hazard Warning........................... 154
Flash-to-Pass.............................................. 156
Flat Tire...................................................... 354
Flat Tire, Changing...................................... 355
Flat Tire, Storing......................................... 365
Fluid
Automatic Transaxle................................. 305
Manual Transaxle..................................... 305
Windshield Washer.................................. 316
Fog Lamp Light........................................... 193
Fog Lamps.................................................. 166
Folding Rear Seat......................................... 17
Folding Seatback, Passenger........................ 14
Front Console Storage Area........................ 143
437