2006 KIA AMANTI air conditioning

465
1
2
3
4
5
6
7
8
910
Driving your vehicle
 Use the air conditioning systemevery month if only for a few min-
utes to ensure maximum system
performance.
 When using the air conditioning system, you may notice clear water
dripping (or even pudding) on the
ground under the passenger side
of the vehicle. This is a normal sys-
tem operation characteristics.
 The air conditioning system includes a function that automati-
cally turns the air conditioning
compressor off if engine coolant
temperature approaches an over
heating level. The air conditioning
compressor operation will resume
once engine coolant temperature
returns to the normal range. Also,
the air conditioning compressor is
automatically turned off for a few
seconds when the accelerator is
fully depressed (wide open throt-
tle).  When operating the air condition-
ing system use the outside (fresh)
air position.
 Operating the air conditioning sys- tem in the recirculated air position
does provide maximum cooling,
however, continual operation in this
mode may cause the air inside the
vehicle to become stale.
Checking the amount of air
conditioner refrigerant and
compressor lubricantWhen the amount of refrigerant is
low, the performance of the air con-
ditioning is reduced. Overfilling also
has a bad influence on the air condi-
tioning system.
Therefore, if abnormal operation is
found, have the system inspected by
an authorized Kia dealer.

Driving your vehicle66
4
1
2
3
4
5
6
7
8
910
✽ ✽
NOTICEWhen the performance of the air
conditioning system is reduced it is
important that the correct type and
amount of oil and refrigerant is
used. Otherwise, damage to the
compressor and abnormal system
operation may occur.
Item TypeAmount
Refrigerant R-134a22~24 oz. (625 ~ 675 g)
Compressor lubricant PAG(FD46XG) 8.5~9.8 in
3 (140 ~ 160 cc)
CAUTION
The air conditioning system
should be serviced by anauthorized Kia dealer. Improperservice may cause seriousinjury.Air conditioner refrigerant and compressor lubricantThe system complies with SAE J-639.

469
1
2
3
4
5
6
7
8
910
Driving your vehicle
To defog inside windshield 1. Select desired fan speed
2. Select desired temperature.
3. Press the defrost button ( ).
4. The air-conditioning will be turnedon according to the detected
ambient temperature and outside
(fresh) air position will be selected.
If you don’t want the air-conditioning
or outside (fresh) air position, press
the corresponding button to cancel
the operation.
To defrost outside windshield 1. Set fan speed to the or position.
2. Set temperature to the extreme hot (77~90°F / 25~32°C) position.
3. Press the defrost button ( ).
4. The air-conditioning will be turned on according to the detected
ambient temperature and outside
(fresh) air position will be selected.
If you don’t want the air-conditioning
or outside (fresh) air position, press
the corresponding button to cancel
the operation.
WINDSHIELD DEFROSTING AND DEFOGGING
WARNING
Do not use defrost position dur-
ing cooling operation in
extremely humid weather. The
difference between the tempera-
ture of the outside air and that
of the windshield could cause
the outer surface of the wind-
shield to fog up, causing loss of
visibility.
2GHN2229
2GHN2230

613
In case of an emergency
1
2
3
4
5
6
7
8
910
Driver-side knee bolster
Description Fuse rating Protected component
B/ALARM10A Burglar alarm
A/BAG 15A Air bag
C/LIGHTER 20A Cigar lighter
S/WARMER 10A Seat warmer
P/WDW(RH) 20A Power window (right)
P/HANDLE 15A Power steering wheel
T/SIG LP 15A Turn signal light
HTD GLASS 30A Defroster
TRUNK OPEN 15A Trunk lid opener
CLUSTER 10A Cluster
A/BAG IND 10A Air bag indicator
P/OUTLET 20A Electrical power socket
LAN UNIT 10A Lan unit
CURTAIN(RR) 10A Electric curtain (rear)
FOG LP(RR), PIC 15A Fog light (rear), Personal identifi- cation card
F/LID OPEN 15A Fuel filler lid opener
P/SEAT(RR) 30A Power seat (rear)
B/ALARM 10A Burglar alarm
STOP LP 15A Stop light
TRIP COMPUTER 10A Trip computer
B/UP LP 10A Back-up light
AV 10A Audio
H/LP 10A Headlight
Description Fuse rating Protected component
A/CON10A Air-conditioning system
P/WDW(LH) 20A Power window (left)
TAIL LP(RH) 10A Taillight (right)
BACK WARN’ G10A Back warning
DR LP 10A Door courtesy lamp
MIRROR HTD 10A Outside review mirror defroster
ENG SNSR 10A
Power train control system sensors
T/REDUCER10A Seat belt tension reducer
CLOCK 10A Clock
WIPER(FR) 20A Wiper (front)
EPS 10A Electronic power steering
TAIL LP(LH) 10A Tail light (left)
ROOM LP 10A Room lamp
AV, CLOCK 15A Audio, Clock
LAN UNIT 10A Lan unit
SHUNT CONN - Switch illumination
POWER/CONN - Power connector

711
Maintenance
OWNER MAINTENANCE Owner maintenance schedule The following lists are vehicle checks
and inspections that should be per-
formed by the owner or qualified
service technician at the frequencies
indicated to help ensure safe,
dependable operation of your vehi-
cle.
Any adverse conditions should be
brought to the attention of your deal-
er or qualified service technician or
service advice as soon as possible.
These Owner Maintenance Checks
are generally not covered by war-
ranties and you may be charged for
labor, parts and lubricants used.
When you stop for fuel: Check the engine oil level.
 Check coolant level in coolantreservoir.
 Check the windshield washer fluid level.
 Look for low or under-inflated tires.
While operating your vehicle: Note any changes in the sound of the exhaust or any smell of
exhaust fumes in the vehicle.
 Check for vibrations in the steering wheel. Notice any increased steer-
ing effort or looseness in the steer-
ing wheel, or change in its straight-
ahead position.
 Notice if your vehicle constantly turns slightly or “pulls” to one side
when traveling on smooth, level
road.
 When stopping, listen and check for strange sounds, pulling to one
side, increased brake pedal travel
or “hard-to-push” brake pedal.
 If any slipping or changes in the operation of your transaxle occurs,
check the transaxle fluid level.
 Check automatic transaxle P (Park) function.
 Check parking brake.
 Check for fluid leaks under your vehicle (water dripping from the air
conditioning system after use is
normal).
1
2
3
4
5
6
7
8
910
WARNING
Be careful when checking your
engine coolant level when the
engine is hot. Scalding hot
coolant and steam may blow out
under pressure. This could
cause serious injury.

Maintenance12
7At least monthly: Check coolant level in the coolant
recovery reservoir.
 Check the operation of all exterior lights, including the stoplights, turn
signals and hazard warning flash-
ers.
 Check the inflation pressures of all tires including the spare.
At least twice a year
(i.e., every Spring and Fall) : Check radiator, heater and air con- ditioning hoses for leaks or da-
mage.
 Check windshield washer spray and wiper operation. Clean wiper
blades with clean cloth dampened
with washer fluid.
 Check headlight alignment.
 Check muffler, exhaust pipes, shields and clamps.
 Check the lap/shoulder belts for wear and function.
 Check for worn tires and loose wheel lug nuts.
At least once a year : Clean body and door drain holes.
 Lubricate door hinges and checks,and hood hinges.
 Lubricate door and hood locks and latches.
 Lubricate door rubber weather- strips.
 Check the air conditioning system before the warm weather season.
 Check the power steering fluid level.
 Inspect and lubricate automatic transaxle linkage and controls.
 Clean battery and terminals.
 Check the brake fluid level.
1
2
3
4
5
6
7
8
910

723
Maintenance
DRIVE BELTSDrive belts should be checked peri-
odically for proper tension and
adjusted if necessary. At the same
time, belts should be examined for
cracks, wear, fraying or other evi-
dence of deterioration and replaced
if necessary.
Belt routing should also be checked
to be sure there is no interference
between the belts and other parts of
the engine. After a belt is replaced,
the new belt should be adjusted
again after two or three weeks to
eliminate slack resulting from initial
stretching after use.
Checking the compressor
drive beltWhen the air conditioning is being
used regularly, the compressor drive
belt tension should be checked at
least once a month.
To check the drive belt tension, turn
the engnie off, press down on the
belt halfway between the engine
crankshaft and compressor pulleys.
Pressing with your finger, you should
not be able to deflect this belt any-
more than 1/3 of an inch. If you have
the instruments to check it, with a
force of 22 lb. (98N), the deflection
should be 0.315 inches (approx. 8.0
mm). If the belt is too loose, have it
adjusted by an authorized Kia
Dealer.
1
2
3
4
5
6
7
8
910
2GHN722

Index2
10Air Bag - Advanced Supplemental Restraint System . 3-60
Air Bag Warning Light . . . . . . . . . . . . . . . . . . . . . . . 3-81
Air Cleaner . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-29
Air Conditioner (Specifications) . . . . . . . . . . . . . . . . 4-66
Air Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-30
Air Conditioning . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-63 Button . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-62
System Operation Tips . . . . . . . . . . . . . . . . . . . . . . 4-64
Air Intake Control Button . . . . . . . . . . . . . . . . . . . . . 4-58
Alignment, Tire Balance and Wheel . . . . . . . . . . . . . 7-39
Aluminum Wheel Maintenance . . . . . . . . . . . . . . . . . 7-56
Antenna . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-111
Anti-Lock Brake System . . . . . . . . . . . . . . . . . . . . . . 4-15 Warning Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-36
Anti-Theft Steering Column Lock, Ignition Switch and . . . . . . . . . . . . . . . . . . . . . . . . . 4-2
Ashtray . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-102
Automatic Climate Control System . . . . . . . . . . . . . . . . . . . . . 4-54
Headlight Aiming . . . . . . . . . . . . . . . . . . . . . . . . . 4-47
Power Window . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-16
Transaxle . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-5, 7-25
Transaxle (Specifications) . . . . . . . . . . . . . . . . . . . . 8-5
Transaxle Fluid Level, Checking the . . . . . . . . . . . 7-25
Window Reversal . . . . . . . . . . . . . . . . . . . . . . . . . . 3-16
Balance, Wheel Alignment and Tire . . . . . . . . . . . . . 7-39 Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-34
Recharging . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-35
Service, for Best . . . . . . . . . . . . . . . . . . . . . . . . . . 7-35
Before Driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-5
Belts, Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-36
Pre-tensioner, seat . . . . . . . . . . . . . . . . . . . . . . . . . 3-36
Blade Replacement, Windshield Wiper . . . . . . . . . . . 7-32
Blades, Wiper . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-32
Body Lubrication . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-28
Brake Fluid Level, Checking . . . . . . . . . . . . . . . . . . . . . . 7-21
Parking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-13, 7-22
System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-11
System, Anti-Lock . . . . . . . . . . . . . . . . . . . . . . . . . 4-15
Wear Indicators, Disc . . . . . . . . . . . . . . . . . . . . . . . 4-12
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
7-21 Power . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-11
Break-In Process, Vehicle . . . . . . . . . . . . . . . . . . . . . . 1-2
Bulb Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-44
Bulbs, Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-5
Capacities (Specifications) . . . . . . . . . . . . . . . . . . . . . 8-5
Capacity, Oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-17
Care of the Safety Belt System, Proper Use and . . . . . . . 3-47
Exterior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-53
Interior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . 7-57
1
2
3
4
5
6
7
8
910
AB
C