2006 HONDA INSIGHT ignition

The brake system
indicator normally
comesonwhenyou
turn the ignition switch to the ON
(II) position and as a reminder to
check the parking brake. It will stay
on if you do not f ully release the
parking brake.
If the brake system indicator comes
on while driving, the brake f luid level
is probably low. Press lightly on the
brake pedal to see if it f eels normal.
If it does, check the brake f luid level
thenexttimeyoustopataservice
station (see page ).
If the f luid level is low, take your
vehicle to a dealer, and have the
brake system inspected f or leaks or
worn brake pads. However, if the brake pedal does not
f eel normal, you should take
immediate action. A problem in one
part of the system’s dual circuit
design will still give you braking at
two wheels. You will f eel the brake
pedal go down much f arther bef ore
the vehicle begins to slow down, and
you will have to press harder on the
pedal.
Slow down by shif ting to a lower
gear, and pull to the side of the road
when it is saf e. Because of the long
distance needed to stop, it is
hazardous to drive the vehicle. You
should have it towed and repaired as
soon as possible (see
on page ). If you must drive the vehicle a short
distance in this condition, drive
slowly and caref ully.
145 183
Brake System Indicator
Emergency
Towing
182
U.S. Canada

µµ
If your vehicle needs to be towed,
call a prof essional towing service or
organization. Never tow your vehicle
with just a rope or chain. It is very
dangerous.
The operator
loads your vehicle on the back of a
truck.
The tow
truck uses two pivoting arms that go
under the tires (f ront or rear) and lif t
them of f the ground. The other two
tires remain on the ground. With the f ront wheels on the ground,
it is best to tow the vehicle no farther
than 50 miles (80 km), and keep the
speedbelow35mph(55km/h).
If your vehicle is equipped with a
f ront spoiler, remove it bef ore
towing so it is not damaged.
Therearetwowaystotowyour
vehicle:
If , due to damage, your vehicle must
be towed with the f ront wheels on
the ground, do the f ollowing:
Release the parking brake.
Shif t the transmission to neutral.
Leave the ignition switch in the
ACCESSORY (I) position so the
steering wheel does not lock.
Release the parking brake.
Start the engine.
ShifttoD,thentoN.
Turn of f the engine.
Leave the ignition switch in the
ACCESSORY (I) position so the
steering wheel does not lock.
CONT INUED
5-speed Manual Transmission:
Automatic Transmission (CVT):
Emergency Towing
Flat -bed EquipmentWheel-lif t Equipment
This is the best way to trans-
port your vehicle.
T his is
an acceptable way to tow your
vehicle.
T aking Care of t he Unexpect ed
183
Trying to lif t or tow your vehicle by the
bumpers will cause serious damage.
The bumpers are not designed to
support the vehicle’s weight. Improper towing preparation will
damage the transmission. Follow the
above procedure exactly. If you cannot
shif t the transmission or start the
engine (CVT), your vehicle must be
transported with the f ront wheels of f
the ground.

For very short distances, such as
f reeing the vehicle, you can use the
detachable towing hook that mounts
on the anchor in the f ront bumper.
To use the towing hook:Remove the towing hook and
wheel wrench f rom the tool box. Remove the cover f rom the
bumper with the end of the
extension.
Screw the towing hook into the
hole and tighten it securely by
hand.
If your vehicle gets stuck in sand,
mud, or snow, call a towing service
to pull it out (see page ).
1.2.
3.
183
Emergency Towing
If Your Vehicle Gets Stuck
184
The steering system can be damaged if
the steering wheel is locked. Leave the
ignition switch in the ACCESSORY (I)
position, and make sure the steering
wheel turns f reely bef ore you begin
towing.

Check the smaller f uses in the
under-hood f use box and all the
fuses in the interior fuse box by
pulling out each one with the f use
puller provided in the under-hood
fuse box.
Check each of the large f uses in
the under-hood f use box by
looking through the top at the wire
inside. Removing these screws
requires a Phillips-head
screwdriver.
If something electrical in your
vehicle stops working, the first thing
youshouldcheckforisablownfuse.
Determine f rom the chart on pages
and , or the diagram on the
fuse box lid, which fuse or fuses
control that device. Check those
f uses f irst, but check all the f uses
bef ore deciding that a blown f use is
the cause. Replace any blown f uses,
and check if the device works.
Turn the ignition switch to the
LOCK (0) position. Make sure the
headlights and all other
accessories are of f .
Remove the cover f rom the f use
box. 3.
4.
1.
2. 188 189
Fuses
Checking and Replacing Fuses
186
FUSE
BLOWN FUSE PULLER

Thediagramsinthissectiongive
you the dimensions and capacities of
your vehicle, and the locations of the
identif ication numbers. It also
includes inf ormation you should
know about your vehicle’s tires and
emissions control systems.................
Identif ication Numbers . 192
................................
Specif ications .194
DOT Tire Quality Grading ......................
(U.S. Vehicles) .196
Unif orm Tire Quality ..................................
Grading .196
.................................
Treadwear .196
......................................
Traction .196
.............................
Temperature .197
.................................
Tire Labeling .198 .......................
Emissions Controls .199
.....................
The Clean Air Act .199
Crankcase Emissions Control ....................................
System .199
Evaporative Emissions Control ....................................
System .199
Onboard Ref ueling Vapor ................................
Recovery .199
...
Exhaust Emissions Controls . 200
....................
PGM-FI System .200
Ignition Timing Control ................................
System .200
Three Way Catalytic ...........................
Converter .200
....................
Replacement Parts . 200
..
Three Way Catalytic Converter . 201
..............
State Emissions Testing . 202
....
Testing of Readiness Codes . 202
T echnical Inf ormation
Technical Inf ormation
191

The exhaust emissions controls
include three systems: PGM-FI,
ignition timing control, and three
way catalytic converter. These three
systems work together to control the
engine’s combustion and minimize
the amount of HC, CO, and NOx that
comes out the tailpipe. The exhaust
emissions control systems are
separate f rom the crankcase and
evaporative emissions control
systems.The PGM-FI system uses sequential
multiport f uel injection. It has three
subsystems: air intake, engine
control, and f uel control. The
powertrain control module (PCM) in
automatic transmission vehicles or
the engine control module (ECM) in
manual transmission vehicles uses
various sensors to determine how
much air is going into the engine. It
then controls how much f uel to inject
under all operating conditions.The emissions control systems are
designed and certif ied to work to-
gether in reducing emissions to
levels that comply with the Clean Air
Act. To make sure the emissions
remain low, you should use only new
Honda replacement parts or their
equivalent f or repairs. Using lower
quality parts may increase the
emissions f rom your vehicle.
The emissions control systems are
covered by warranties separate from
the rest of your vehicle. Read your
warranty manual for more informa-
tion.
The three way catalytic converter is
in the exhaust system. Through
chemical reactions, it converts HC,
CO, and NOx in the engine’s exhaust
to carbon dioxide (CO ), nitrogen
(N ), and water vapor. This system constantly adjusts the
ignition timing, reducing the amount
of HC, CO, and NOx produced.
2
2
Emissions Cont rols
Exhaust Emissions Controls Replacement PartsPGM-FI System
Three Way Catalytic Converter
Ignit ion T iming Cont rol Syst em
200

BatteryCharging System ...........................
Indicator .44, 180
............................
Jump Starting .175
..............................
Maintenance .162
............................
Specif ications .195
................................
Bef ore Driving .93
..................................
Belts, Seat .10, 18
.............................
Beverage Holder .71
..................................
Booster Seats .35 Brakes
...........
Anti-lock System (ABS) . 122
................
Break-in, New Linings . 94
....................
Bulb Replacement .149
...........................................
Fluid .144
.........................................
Parking .69
.................
System Indicator . 45,182
........................
Wear Indicators .121
.............................
Braking System .121
...................
Break-in, New Vehicle . 94
..
Brightness Control, Instruments . 57
........................
Brights, Headlights .56
Bulb Replacement ..........................
Back-up Lights .149
..............................
Brake Lights .149
................
Front Parking Lights . 147
........
Front Side Marker Lights . 148
.................................
Headlights .146
............................
Specif ications .195
....................
Turn Signal Lights . 148
..............................
Bulbs, Halogen .146
....................................
Accessories .100
ACCESSORY (Ignition Key .......................................
Position) .61
...............
Accessory Power Socket . 71
....................
Additives, Engine Oil . 136
.............................
Airbag (SRS) .11, 21
...
Airbags, Additional Information . 21
...
Additional Safety Precautions . 24
.............................
Airbag Service .23
..
How the SRS Indicator Works . 23
How Your Front Airbags .........................................
Work .21
........................
SRS Components .21
................
Air Conditioning System . 74
.....................................
Usage .75, 78
.......................
Air Pressure, Tires .156
.........................
Normal Driving .157
.........................
Alcohol in Gasoline .94
......................................
Antif reeze .139
Anti-lock Brakes (ABS) ...............................
Indicator .45, 122
....................................
Operation .122
................
Anti-theft, Audio System . 90Anti-thef t Steering Column
..............................................
Lock .61
..................................
Audio System .80
........................
Auto Idle Stop .111, 118
...
Automatic Seat Belt Tensioners . 19
..............
Automatic Transmission . 113
..........................
Capacity,Fluid .194
...............
Checking Fluid Level . 142
.......................................
Shif ting .114
Shif t Lever Position ...............................
Indicators .113
................
Shif t Lever Positions . 114
....................
Shif t Lock Release . 117
CONT INUED
Index
A
B
INDEX
I

.................
Gas Mileage, Improving . 99
...........................................
Gasoline .94
...............
Fuel Reserve Indicator . 46
...........................................
Gauge .49
..................
Octane Requirement . 94
..........................
Tank, Filling the .95
..................
Gas Station Procedures . 95
Gauges ...
Engine Coolant Temperature . 49
...............................................
Fuel .49
Gearshif t Lever Positions Automatic Transmission .....................................
(CVT) .113
..............
Manual Transmission . 110
........................................
Glove Box .71 ...
Identif ication Number, Vehicle . 192
Ignition ..............................................
Keys .59
...........................................
Switch .61
............
Timing Control System . 200
....................
IMA System Indicator . 44
.........
Important Safety Precautions . 8
.........................................
Indicators .44
.......
ABS (Anti-lock Brake) . 45,122 Brake (Parking and Brake
............................
System) .45, 182
................
Charging System . 44,180
DRL (Daytime Running ......................................
Lights) .46
...................................
High Beam .46
...............................................
IMA .44
........
Key (Immobilizer System) . 46
......................................
Low Fuel .46
................
Low Oil Pressure . 44,179
.........................................
SRS .23, 44
Turn Signal and Hazard ...................................
Warning .45
......................................
Inf ant Seats .26
...................
Inf lation, Proper Tire . 156
.........................
Normal Driving .157
...................................
Inside Mirror .68
.............................
Inspection, Tire .158
............................
Instrument Panel .43
........
Instrument Panel Brightness . 57
.................................
Interior Lights .72
........................................
Introduction . i
.............
Halogen Headlight Bulbs . 146
Hatch .................................
Opening the .63
.............
Open Monitor Indicator . 46
.................
Hazard Warning Button . 57Headlights
........................................
Aiming .146
.....
Daytime Running Lights . 46,56
..................
High Beam Indicator . 46
...........................
Reminder Tone .56
........
Replacing Halogen Bulbs . 146
...................................
Turning on .56
.............................................
Heating .76
.............
High Altitude, Starting at . 109
.................
High-Low Beam Switch . 56
.........................
Hood, Opening the .96
..................................................
Horn .54
...........................
Hydraulic Clutch .145
Index
H I
G
IV