2006 DODGE POWER WAGON automatic transmission fluid

is on level ground, enough lubricant should be added to
bring the level to the bottom of the filler hole.
Lubricant Selection G56 (6 – Speed Manual
Transmission — If Equipped)
This transmission does not require periodic changing. If
it becomes necessary to add or change the fluid in this
transmission, refer to Fluids, Lubricants and Genuine
Parts for correct fluid type.
Automatic Transmission
Fluid Level Check
The fluid level should be checked when the engine is
fully warmed up and the fluid in the transmission is at
normal operating temperature. Operation of the trans-
mission with an improper fluid level will greatly reduce
the life of the transmission and of the fluid. Check the
fluid level whenever the vehicle is serviced.
Fluid Level Check – 545RFE
Check the fluid level while the transmission is at normal
operating temperature 82°C (180°F). This occurs after at
least 15 miles (25 km) of driving. At normal operating
temperature the fluid cannot be held comfortably be-
tween the fingertips.
To check the automatic transmission fluid level properly,
the following procedure must be used:
1. Operate the engine at idle speed and normal operating
temperature.
2. The vehicle must be on level ground.
3. Fully apply the parking brake and press the brake
pedal.
4. Place the gear selector momentarily in each gear
position ending with the lever in P (Park).
MAINTAINING YOUR VEHICLE 393
7

Selection Of Lubricant
Refer to Fluids, Lubricants and Genuine Parts for correct
fluid type. It is important that the transmission fluid be
maintained at the prescribed level using the recom-
mended fluid.
CAUTION!
Using a transmission fluid other than the manufac-
turers recommended fluid may cause deterioration
in transmission shift quality and/or torque converter
shudder. Using a transmission fluid other than the
manufacturers recommended fluid will result in
more frequent fluid and filter changes. Refer to
Fluids, Lubricants and Genuine Parts for correct
fluid type.
Automatic Transmission Fluid and Filter Change
To obtain best performance and long life for automatic
transmissions, the manufacturer recommends that they
be given regular maintenance service by an Authorized
Dodge Dealer or Service Center.
It is important that proper lubricant is used in the
transmission. Refer to Fluids, Lubricants and Genuine
Parts for correct fluid type.
The fluid and filter(s) should be changed as specified in
the Maintenance Schedule (Section 8).
NOTE:If the transmission is disassembled for any
reason, the fluid and filter(s) should be changed.
Special Additives
The manufacturer strongly recommends against the ad-
dition of any additives to the transmission. Exception to
this policy is the use of special dyes to aid in detecting
fluid leaks. The use of transmission sealers should be
avoided, since they may adversely affect seals.
MAINTAINING YOUR VEHICLE 395
7

Chassis
Component Fluids, Lubricants and Genuine Parts.
Automatic Transmission MoparATF+4, Automatic Transmission Fluid
Transfer Case MoparATF+4, Automatic Transmission Fluid
Manual Transmission Fluid (G-56) MoparATF+4, Automatic Transmission Fluid
Front Driveshaft Grease Fitting. Use Mopartype MS-6560 (lithium based grease), or equivalent.
Clutch Linkage Multipurpose Grease, NLGI Grade 2 E.P.
Front and Rear Axle Synthetic, GL-5 SAE, 75W-90. Limited-Slip 10.5 inch Rear AxleDOES NOT
REQUIREa limited slip additive.
Brake Master Cylinder MoparDOT 3 and SAE J1703 should be used. If DOT 3 brake fluid is not
available, then DOT 4 is acceptable. Use only recommended brake fluids.
Power Steering Reservoir MoparATF+4, Automatic Transmission Fluid
MAINTAINING YOUR VEHICLE 419
7

At Each Stop for Fuel
•Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant bottle, brake master
cylinder, and transmission and add as needed.
•Check all lights and all other electrical items for correct
operation.
At Each Oil Change
•Change the engine oil filter.
•Lubricate the front driveshaft grease fitting and tie rod
end links.
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the CV joints (if equipped) and front suspen-
sion components.
•Check the automatic transmission fluid level.
•Check the manual transmission fluid level.
•Check the coolant level, hoses, and clamps.
•Lubricate Front Drive Shaft Fitting.
424 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Adding Fuel........................319,347
Air Cleaner, Engine (Engine Air Cleaner Filter) . 375,398
Air Conditioner Maintenance............... 379
Air Conditioning Refrigerant.............379,380
Air Conditioning System................216,379
Air Conditioning System, Zone Control........ 219
Air Pressure, Tires....................306,314
Airbag.............................. 45,51
Airbag Light......................... 72,169
Airbag On/Off Switch..................... 51
Airbag, Side............................ 54
Alarm .............................. 29,171
Alignment and Balance................... 313
Alterations/Modifications, Vehicle............. 7
Antifreeze (Engine Coolant)..............387,417
Anti-Lock Warning Light...............173,294
Anti-Theft System..................... 29,171
Appearance Care........................ 401
Ashtray............................... 152Automatic Transmission
Adding Fluid......................... 394
Fluid and Filter Changes................. 395
Fluid Level Check...................... 393
FluidType ........................395,419
Shift Indicator........................ 171
Shifting ............................. 280
Special Additives...................... 395
AxleFluid ..........................391,419
Axle Lubrication........................ 391
BallJoints ............................. 380
Battery............................... 378
Emergency Starting..................... 356
Saving Feature (Protection)............... 122
Bearings.............................. 396
Belts,Drive ............................ 374
Belts, Seat.............................. 34
Body Mechanism Lubrication............... 382
452 INDEX

Event Data Recorder...................... 56
Exhaust Gas Caution.............. 71,162,322,384
Exhaust System....................... 71,384
Exterior Lighting........................ 123
Filters
Air Cleaner........................375,398
Engine Fuel.......................... 375
Engine Oil........................374,418
Engine Oil Disposal.................... 374
Flashers
Turn Signal.......................... 125
Flat Tire Stowage.....................349,355
Flooded Engine Starting................... 278
Fluid, Brake........................... 419
Fluid Capacities......................... 417
Fluid Level Checks
Automatic Transmission................. 393
Power Steering........................ 380Fluids, Lubricants and Genuine Parts.......... 418
Fog Lights.......................124,174,415
Fold Flat Load Floor..................... 156
Four Wheel Drive....................... 287
Four-Way Hazard Flasher.................. 346
Freeing A Stuck Vehicle................... 359
FrontAxle ............................. 391
Front Wheel Bearings..................... 396
Fuel................................. 317
Adding............................. 319
Filter ............................... 375
Gauge.............................. 175
Octane Rating......................317,418
Requirements......................317,417
Tank Capacity........................ 417
Fueling ............................... 319
Fuses................................ 405
Garage Door Opener..................... 142
456 INDEX

Maintenance Procedures................... 370
Maintenance Schedule.................... 422
ScheduleA......................... 437
ScheduleB.......................... 425
Malfunction Indicator Light................ 368
Manual, Service......................... 448
Manual Transmission..................285,392
Fluid Level Check...................... 392
Lubricant Selection..................393,419
Mirrors ................................ 84
Automatic Dimming..................... 85
Electric Powered....................... 87
Outside.............................. 86
Rearview............................. 84
TrailerTowing ...................... 88,339
Modifications/Alterations, Vehicle............. 7
Mopar Parts.........................370,447
Multi-Displacement Engine System........... 296
Multi-Function Control Lever............... 125Noise Control
Maintenance.......................... 397
Tampering Prohibited................397,398
Noise Emission Warranty.................. 399
Occupant Restraints....................... 33
Octane Rating, Gasoline................... 317
Odometer..........................171,175
Trip .............................171,175
Off-Pavement Driving.................... 235
Off-Road Driving........................ 235
Oil, Engine.........................370,418
Capacity............................ 417
Change Interval....................... 371
Dipstick............................. 370
Disposal............................ 374
Filter ............................374,418
Filter Disposal........................ 374
Identification Logo..................... 373
460 INDEX

Fluid ............................... 419
Transmission
Automatic........................280,393
Fluid ............................... 419
Maintenance.......................392,393
Manual........................277,285,392
Shifting ..........................280,286
Transmitter, Garage Door Opener............ 142
Tread Wear Indicators..................... 311
Trip Computer.......................... 135
Trip Odometer.......................171,175
Turn Signals...................125,168,407,410
Underhood Fuses........................ 405
Universal Transmitter..................... 142
Variance, Compass....................... 140
Vehicle Identification Number................ 6
Vehicle Loading......................302,324Vehicle Modifications/Alterations.............. 7
Vehicle Storage......................... 405
Voltmeter............................. 168
Warning Lights (Instrument Cluster Description) . 168
Warnings and Cautions..................... 5
Warranty Information..................... 447
Washers, Windshield..................128,383
Washing Vehicle......................... 401
Wheel Alignment and Balance............... 313
Wheel and Wheel Trim.................... 402
Wheel Changing........................ 349
Wheel Flares............................ 82
Wheel Mounting........................ 350
Wheel Nut Torque....................353,355
Wheels................................ 83
Winch .............................. 81,256
Accessories.......................... 260
Operation........................... 261
466 INDEX