2006 DODGE GRAND CARAVAN transmission

Chassis
Component Fluids, Lubricants and Genuine Parts.
Automatic Transmission Mopar  ATF+4 Automatic Transmission Fluid.
Brake Master Cylinder Mopar  DOT 3, SAE J1703 should be used. If DOT 3, SAE J1703 brake
fluid is not available, then DOT 4 is acceptable. Use only recommended
brake fluids.
Power Steering Reservoir Mopar  ATF+4 Automatic Transmission Fluid. MAINTAINING YOUR VEHICLE 445
7

• Taxi, police, or delivery service (commercial ser-
vice). 
• Off-road or desert operation.
NOTE: Most vehicles are operated under the conditions
listed for Schedule  B  .
Second is Schedule “ A ” . It is for vehicles that are not
operated under any of the conditions listed under Sched-
ule  B  .
Use the schedule that best describes your driving condi-
tions. Where time and mileage are listed, follow the
interval that occurs first.
CAUTION!Failure to perform the required maintenance items
may result in damage to the vehicle. At Each Stop for Fuel
• Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
• Check the windshield washer solvent and add if
required.
Once a Month
• Check tire pressure and look for unusual wear or
damage.
• Inspect the battery and clean and tighten the terminals
as required.
• Check the fluid levels of coolant reservoir, brake
master cylinder and transmission; add as needed. MAINTENANCE SCHEDULES 449
8 M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

• Check all lights and all other electrical items for correct
operation.
At Each Oil Change
• Change the engine oil filter.
• Inspect the exhaust system. • Inspect the brake hoses.
• Inspect the CV joints and front suspension compo-
nents.
• Check the automatic transmission fluid level.
• Check the coolant level, hoses, and clamps.450 MAINTENANCE SCHEDULES
8 M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

SCHEDULE “ B ”
Follow schedule “ B ” if you usually operate your vehicle
under one or more of the following conditions. Change
the automatic transmission fluid and filter every 60,000
miles (96 000 km) if the vehicle is usually operated under
one or more of the conditions marked with an  .
• Day or night temperatures are below 32 ° F(0 ° C).
• Stop and go driving.
• Extensive engine idling. • Driving in dusty conditions.
• Short trips of less than 10 miles (16 km).
• More than 50% of your driving is at sustained high
speeds during hot weather, above 90 ° F (32 ° C).
• Trailer towing. 
• Taxi, police, or delivery service (commercial ser-
vice). 
• Off-road or desert operation. SCHEDULE “ B ” 451
8 M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 57, 000 60, 000 63, 000 66, 000 69, 000 72, 000
(Kilometers) (95 000) (100 000) (105 000) (110 000) (115 000) (120 000)
Change engine oil and engine oil filter. X X XXXX
Rotate Tires X X X
Inspect the brake linings. X X
Inspect the engine air cleaner filter, replace if necessary. * X XXXX
Replace the engine air cleaner filter. X
Replace the spark plugs on 2.4 liter engines. X
Replace the ignition cables on 2.4 liter engines. X
Inspect the tie rod ends and boot seals. X
Inspect and adjust the power steering pump belt tension
on 2.4 liter engines. X
Inspect the generator belt on 2.4 liter engines, replace if
necessary. X
Inspect the PCV valve and replace if necessary.* X
Inspect the serpentine drive belt on 3.3 liter and 3.8 liter
engines, replace if necessary. X
Change the automatic transmission fluid and filter.  X
Replace the air conditioning filter. X X SCHEDULE “ B ” 455
8 M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 108, 000 111, 000 114, 000 117, 000 120, 000
(Kilometers) (180 000) (185 000) (190 000) (195 000) (200 000)
Change engine oil and engine oil filter. X X X X X
Rotate Tires X X X
Inspect the brake linings. X X
Inspect the engine air cleaner filter, replace if necessary. * X X X X
Replace the engine air cleaner filter. X
Replace the spark plugs on 2.4 liter engines. X
Replace the ignition cables on 2.4 liter engines. X
Inspect and adjust the power steering pump belt tension on
2.4 liter engines. X
Inspect the generator belt on 2.4 liter engines, replace if
necessary. X
Inspect the serpentine drive belt on 3.3 liter and 3.8 liter
engines, replace if necessary. ‡ X
Inspect the tie rod ends and boot seals. X
Inspect the PCV valve and replace as necessary.* X
Change the automatic transmission fluid and filter.  X
Replace the air conditioning filter. X X SCHEDULE “ B ” 459
8 M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Interlock System ....................... 310
Reset Mode .......................... 311
Selection Of Lubricant ................ 425,445
Shifting ............................. 311
Special Additives ...................... 427
Automatic Transmission ................... 424
Adding Fluid ......................... 426
Fluid and Filter Changes ................. 427
Fluid Change ......................... 427
Fluid Level Check ...................... 426
Fluid Type ........................ 425,445
Ball Joints ............................. 412
Battery ............................... 409
Gas Caution .......................... 409
Jump Starting ......................... 387
Keyless Transmitter Replacement (RKE) ....... 25
Saving Feature (Protection) ............... 145
Bearings .............................. 428 Belts, Drive ............................ 405
Body Mechanism Lubrication ............... 413
B-Pillar Location ........................ 324
Brake Fluid ............................ 445
Brake, Parking .......................... 313
Brake System ........................ 314,421
Anti-Lock (ABS) ....................... 315
Fluid Check .......................... 423
Hoses .............................. 422
Warning Light ........................ 205
Brakes ............................. 314,421
Brake/Transmission Interlock ............... 310
Break-In Recommendations, New Vehicle ........ 82
Bulb Replacement ....................... 438
Bulbs, Light ............................ 437
Calibration, Compass ..................... 159
Capacities, Fluid ........................ 443 INDEX 483
10

Compass Variance ....................... 160
Computer, Trip/Travel .................... 162
Console, Overhead ....................... 158
Console, Removable ................... 184,185
Contract, Service ........................ 476
Coolant Pressure Cap ..................... 418
Cooling System ......................... 416
Adding Coolant (Antifreeze) .............. 418
Coolant Capacity ...................... 443
Coolant Level ...................... 416,419
Disposal of Used Coolant ................ 419
Drain, Flush, and Refill .................. 417
Inspection ........................... 419
Points to Remember .................... 420
Pressure Cap ......................... 418
Radiator Cap ......................... 418
Selection of Coolant (Antifreeze) ...... 417,443,444
Cruise Control (Speed Control) .............. 155
Cruise Light ........................... 211 Cup Holder ......................... 177,432
Customer Assistance ..................... 474
Daytime Running Lights ................... 145
Dealer Service .......................... 400
Defroster, Rear Window ................... 300
Defroster, Windshield ................ 84,279,290
Diagnostic System, Onboard ................ 398
Dimmer Control ........................ 144
Dipsticks
Automatic Transmission ................. 426
Oil (Engine) .......................... 401
Disabled Vehicle Towing ................... 391
Disarming, Theft System ................... 27
Disposal
Antifreeze (Engine Coolant) ............... 419
Engine Oil ........................... 405
Domelight ............................. 144
Door Ajar Light ......................... 205 INDEX 485
10