2005 YAMAHA VX110 fuel pump

4-5
EFUELFUEL TANK AND FUEL PUMP MODULE
Fuel sender inspection
Refer to “FUEL CONTROL SYSTEM” in
Chapter 7.
Fuel tank inspection
1. Inspect:
Fuel tank
Cracks/damage →
Replace.
Fuel hose inspection
Refer to “FUEL INJECTION SYSTEM”.
Fuel pump filter inspection
1. Inspect:
Fuel pump filter 1

Clog/contaminants →
Wash the fuel
pump filter in kerosene or gasoline.
1
ProCarManuals.com

4-6
EFUEL
Fuel pump module installation
1. Tighten:
Nuts
NOTE:
Tighten the nuts in the sequence shown.
Fuel hose connect
Refer to “FUEL INJECTION SYSTEM”.
T R..
Fuel pump module nut:
1st:
3.2 N  m
(0.32 kgf  m, 2.3 ft  lb)
2nd:
6.4 N  m
(0.64 kgf  m, 4.6 ft  lb)238
7
5
1 872
3
5
9
4 6
1 6 4
FUEL TANK AND FUEL PUMP MODULE
ProCarManuals.com

4-13
EFUEL
CAUTION:
Do not rotate the quick connector tab
1
past the stopper position, otherwise it
could be damaged.
When the fuel hoses are disconnected,
quickly remove the retainer
2 from the
quick connector, otherwise the retainer
could be lost.
2. Disconnect the fuel hose 1
from the fuel
pipe 2
directly.
WARNING
Always reduce the fuel pressure in the fuel
line before servicing the line or the fuel
pipe. If the fuel pressure is not released,
pressurized fuel could spray out.
21
1
2
3. Cover the quick connector and fuel pipe
with a plastic bag 3 to prevent damage
and to protect them from dirt.
3
Fuel line inspection
1. Inspect:
Fuel hose
Damage/cracks → Replace.
O-rings (quick connector)
Damage/cracks → Replace the quick
connector.
Fuel pipe
Damage/cracks → Replace the fuel
pump.
THROTTLE BODY ASSEMBLY AND INTAKE
MANIFOLD
ProCarManuals.com

4-17
EFUEL
THROTTLE BODY ASSEMBLY AND INTAKE
MANIFOLD
Air filter case assembly installation
1. Install:
Air intake duct 1

Air intake hose 2

Air filter case cover
NOTE:
Align the projections a
on the air intake duct
and air intake hose with the projections b
on
the air filter case cover as shown in the illustra-
tion.
2. Adjust:
Throttle lever free play
Refer to “CONTROL SYSTEM” in Chap-
ter 3.
a
b a
b
2
1
Fuel pressure measurement
1. Disconnect:
Fuel hose
Refer to “Fuel hose disconnection”.
2. Install:
Fuel pressure gauge adapter 1

Fuel pressure gauge 2

NOTE:
To connect the fuel pressure gauge adapter,
follow the procedures for connecting a fuel
hose. (Refer to “Fuel hose connection”.)
3. Start the engine and arrow it to warm up
for several minutes.
4. Measure:
Fuel pressure
Out of specification →
Replace the fuel
pump module.
Fuel pressure gauge adapter:
YW-06842/90890-06842
Fuel pressure gauge:
YB-06766/90890-06786
Fuel pressure:
320–327 kPa
(3.2–3.3 kgf/cm
2, 46–47 psi)
2
1
ProCarManuals.com

5-12
EPOWROIL TANK
OIL TANK
EXPLODED DIAGRAM
REMOVAL AND INSTALLATION CHART
Step Procedure/Part name Q’ty Service points
OIL TANK REMOVAL
Follow the left “Step” for removal.
Engine unit Refer to “ENGINE UNIT”.
Intake assembly Refer to “FUEL INJECTION SYSTEM” in
Chapter 4.
1 Clamp/cooling water hose 1/1È
To exhaust pipe 1
2Bolt 4
3 Water jacket 1
4Gasket 1
5 Clamp/breather hose 2/1
6 Clamp/breather hose 2/1É
To oil pump
7Bolt 2
8 Collar 2
Ì
LT
572
LT
572
LT
572
LT
572
LT
572
LT
572
23 1925 24
26
25
2116 17 15
14
1220 22
3
4
6 8
9
72
6
AA
6 × 30 mm
2nd 7.6 N  m (0.76 kgf
 m, 5.5 ft
 Ib) 1st 3.7 N  m (0.37 kgf
 m, 2.7 ft
 Ib)
2nd 15 N  m (1.5 kgf
 m, 11 ft
 Ib) 1st 2.0 N  m (0.2 kgf
 m, 1.4 ft
 Ib)
3rd 39 N  m (3.9 kgf
 m, 28 ft
 Ib)
2nd 39 N  m (3.9 kgf
 m, 28 ft
 Ib) 1st 15 N  m (1.5 kgf
 m, 11 ft
 Ib)
10 × 85 mm2nd 15 N  m (1.5 kgf
 m, 11 ft
 Ib) 1st 2.0 N  m (0.2 kgf
 m, 1.4 ft
 Ib)
10 × 70 mm
3rd 39 N  m (3.9 kgf
 m, 28 ft
 Ib)7.6 N 
m (0.76 kgf  m, 5.5 ft  Ib)
6 × 35 mm
È
ÉÌ13
LT
572
LT
572
LT
572
LT
572
18
102nd 7.6 N  m (0.76 kgf  m, 5.5 ft  Ib)
1st 3.7 N  m (0.37 kgf  m, 2.7 ft  Ib)
6 × 20 mm
Ê
Ë
a
1
5
1111
5
6 × 35 mm
Not reusable
ProCarManuals.com

5-71
EPOWRCRANKCASE
CRANKCASE
EXPLODED DIAGRAM
REMOVAL AND INSTALLATION CHART
Step Procedure/Part name Q’ty Service points
OIL PAN AND CRANKCASE
REMOVALFollow the left “Step” for removal.
Engine unit Refer to “ENGINE UNIT”.
Intake assembly Refer to “FUEL INJECTION SYSTEM” in
Chapter 4.
Exhaust pipes 1 and 2 Refer to “EXHAUST PIPES 1 AND 2”.
Exhaust manifold Refer to “EXHAUST MANIFOLD”.
Generator cover Refer to “GENERATOR AND STARTER
MOTOR”.
Oil tank Refer to “OIL TANK”.
Oil pump Refer to “OIL PUMP”.
*: Loosen completely
6
21 20
20 11
10 9
87
23
4
5
16
151718
13 14
1219
1
LT
271
LT
LT
572
LT
LT
572
LT
LT
572
LT
LT
572
LT
LT
572
LT
E
E
AA
12 N •
m (1.2 kgf • m, 8.7 ft • Ib)
6 × 70 mm
12 N •
m (1.2 kgf • m, 8.7 ft • Ib)
6 × 20 mm
20 N •
m (2.0 kgf • m, 14 ft • Ib)
8 × 40 mm
2nd *
3rd 15 N • m (1.5 kgf
• m, 11 ft
• Ib) 1st 7.8 N • m (0.78 kgf
• m, 5.6 ft
• Ib)
9 × 105 mm
4th 49 ± 5˚
8.4 N •
m (0.84 kgf • m, 6.1 ft • Ib)
12 N •
m (1.2 kgf • m, 8.7 ft • Ib)
6 × 55 mm
12 N •
m (1.2 kgf • m, 8.7 ft • Ib)
6 × 55 mm
7.6 N •
m (0.76 kgf • m, 5.5 ft • Ib)
6 × 16 mm
15 N •
m (1.5 kgf • m, 11 ft • Ib)
12 N •
m (1.2 kgf • m, 8.7 ft • Ib)
6 × 20 mm
18
AA
1280B
ProCarManuals.com

E
–+ELEC
1
2
3
4
5
6
7
8
9
CHAPTER 7
ELECTRICAL SYSTEM
ELECTRICAL COMPONENTS........................................................................ 7-1
FUSE BOX ....................................................................................................... 7-2
EXPLODED DIAGRAM ............................................................................. 7-2
REMOVAL AND INSTALLATION CHART ................................................ 7-2
ECM AND RECTIFIER/REGULATOR............................................................. 7-7
EXPLODED DIAGRAM ............................................................................. 7-7
REMOVAL AND INSTALLATION CHART ................................................ 7-7
ELECTRICAL ANALYSIS ............................................................................... 7-9
INSPECTION............................................................................................. 7-9
Digital tester ........................................................................................ 7-9
Low resistance measurement ........................................................... 7-10
Peak voltage measurement .............................................................. 7-10
Peak voltage adapter ........................................................................ 7-11
Test harness .................................................................................... 7-11
IGNITION SYSTEM ....................................................................................... 7-12
WIRING DIAGRAM ................................................................................. 7-12
IGNITION SPARK ................................................................................... 7-14
IGNITION SYSTEM PEAK VOLTAGE .................................................... 7-15
BATTERY ................................................................................................ 7-17
FUSE ....................................................................................................... 7-17
SPARK PLUGS ....................................................................................... 7-17
IGNITION COIL ....................................................................................... 7-18
ENGINE STOP SWITCH ......................................................................... 7-18
ENGINE TEMPERATURE SENSOR ...................................................... 7-19
SENSOR ASSEMBLY ............................................................................. 7-19
THERMOSWITCH (ENGINE).................................................................. 7-20
THERMOSWITCH (EXHAUST) .............................................................. 7-21
MAIN AND FUEL PUMP RELAY............................................................. 7-22
ELECTRONIC CONTROL THROTTLE VALVE RELAY ......................... 7-23
THROTTLE POSITION SENSOR ........................................................... 7-24
ACCELERATOR POSITION SENSOR ................................................... 7-26
CAM POSITION SENSOR ...................................................................... 7-29
SLANT DETECTION SWITCH ................................................................ 7-30
ProCarManuals.com

E
–+ELEC
FUEL CONTROL SYSTEM ........................................................................... 7-31
WIRING DIAGRAM ................................................................................. 7-31
ELECTRIC FUEL PUMP ......................................................................... 7-33
FUEL SENDER ....................................................................................... 7-33
FUEL INJECTOR .................................................................................... 7-34
MAIN AND FUEL PUMP RELAY............................................................. 7-34
OIL PRESSURE SWITCH ....................................................................... 7-34
THERMOSWITCH (ENGINE).................................................................. 7-34
THERMOSWITCH (EXHAUST) .............................................................. 7-34
SLANT DETECTION SWITCH ................................................................ 7-34
REMOTE CONTROL UNIT (DELUXE MODEL ONLY) ........................... 7-34
THROTTLE POSITION SENSOR ........................................................... 7-34
ACCELERATOR POSITION SENSOR ................................................... 7-34
STARTING SYSTEM ..................................................................................... 7-35
WIRING DIAGRAM ................................................................................. 7-35
BATTERY ................................................................................................ 7-37
WIRING CONNECTIONS........................................................................ 7-37
FUSES..................................................................................................... 7-37
START SWITCH...................................................................................... 7-37
STARTER RELAY ................................................................................... 7-38
REMOTE CONTROL UNIT (DELUXE MODEL ONLY) ........................... 7-38
THROTTLE POSITION SENSOR ........................................................... 7-38
ACCELERATOR POSITION SENSOR ................................................... 7-38
STARTER MOTOR ........................................................................................ 7-39
EXPLODED DIAGRAM ........................................................................... 7-39
REMOVAL AND INSTALLATION CHART ............................................. 7-39
SERVICE POINTS .................................................................................. 7-41
Armature inspection .......................................................................... 7-41
Brush holder inspection..................................................................... 7-42
Starter motor front cover inspection .................................................. 7-42
CHARGING SYSTEM .................................................................................... 7-43
WIRING DIAGRAM ................................................................................. 7-43
FUSE ....................................................................................................... 7-44
BATTERY ................................................................................................ 7-44
LIGHTING COIL ...................................................................................... 7-44
RECTIFIER/REGULATOR ...................................................................... 7-44
OFF THROTTLE STEERING SYSTEM......................................................... 7-45
WIRING DIAGRAM ................................................................................. 7-45
STEERING SENSOR .............................................................................. 7-47
ECM......................................................................................................... 7-47
PICKUP COIL .......................................................................................... 7-47
THROTTLE POSITION SENSOR ........................................................... 7-47
ACCELERATOR POSITION SENSOR ................................................... 7-47
ProCarManuals.com