2005 YAMAHA VX110 fuel pressure

4-13
EFUEL
CAUTION:
Do not rotate the quick connector tab
1
past the stopper position, otherwise it
could be damaged.
When the fuel hoses are disconnected,
quickly remove the retainer
2 from the
quick connector, otherwise the retainer
could be lost.
2. Disconnect the fuel hose 1
from the fuel
pipe 2
directly.
WARNING
Always reduce the fuel pressure in the fuel
line before servicing the line or the fuel
pipe. If the fuel pressure is not released,
pressurized fuel could spray out.
21
1
2
3. Cover the quick connector and fuel pipe
with a plastic bag 3 to prevent damage
and to protect them from dirt.
3
Fuel line inspection
1. Inspect:
Fuel hose
Damage/cracks → Replace.
O-rings (quick connector)
Damage/cracks → Replace the quick
connector.
Fuel pipe
Damage/cracks → Replace the fuel
pump.
THROTTLE BODY ASSEMBLY AND INTAKE
MANIFOLD
ProCarManuals.com

4-17
EFUEL
THROTTLE BODY ASSEMBLY AND INTAKE
MANIFOLD
Air filter case assembly installation
1. Install:
Air intake duct 1

Air intake hose 2

Air filter case cover
NOTE:
Align the projections a
on the air intake duct
and air intake hose with the projections b
on
the air filter case cover as shown in the illustra-
tion.
2. Adjust:
Throttle lever free play
Refer to “CONTROL SYSTEM” in Chap-
ter 3.
a
b a
b
2
1
Fuel pressure measurement
1. Disconnect:
Fuel hose
Refer to “Fuel hose disconnection”.
2. Install:
Fuel pressure gauge adapter 1

Fuel pressure gauge 2

NOTE:
To connect the fuel pressure gauge adapter,
follow the procedures for connecting a fuel
hose. (Refer to “Fuel hose connection”.)
3. Start the engine and arrow it to warm up
for several minutes.
4. Measure:
Fuel pressure
Out of specification →
Replace the fuel
pump module.
Fuel pressure gauge adapter:
YW-06842/90890-06842
Fuel pressure gauge:
YB-06766/90890-06786
Fuel pressure:
320–327 kPa
(3.2–3.3 kgf/cm
2, 46–47 psi)
2
1
ProCarManuals.com

4-18
EFUEL
5. Remove:
Fuel pressure gauge
Fuel pressure gauge adapter
NOTE:
To disconnect the fuel pressure gauge
adapter, follow the procedures for disconnect-
ing a fuel hose. (Refer to “Fuel hose discon-
nection”.)
6. Connect:
Fuel hose
Refer to “Fuel hose connection”.
THROTTLE BODY ASSEMBLY AND INTAKE
MANIFOLD
ProCarManuals.com

E
–+ELEC
FUEL CONTROL SYSTEM ........................................................................... 7-31
WIRING DIAGRAM ................................................................................. 7-31
ELECTRIC FUEL PUMP ......................................................................... 7-33
FUEL SENDER ....................................................................................... 7-33
FUEL INJECTOR .................................................................................... 7-34
MAIN AND FUEL PUMP RELAY............................................................. 7-34
OIL PRESSURE SWITCH ....................................................................... 7-34
THERMOSWITCH (ENGINE).................................................................. 7-34
THERMOSWITCH (EXHAUST) .............................................................. 7-34
SLANT DETECTION SWITCH ................................................................ 7-34
REMOTE CONTROL UNIT (DELUXE MODEL ONLY) ........................... 7-34
THROTTLE POSITION SENSOR ........................................................... 7-34
ACCELERATOR POSITION SENSOR ................................................... 7-34
STARTING SYSTEM ..................................................................................... 7-35
WIRING DIAGRAM ................................................................................. 7-35
BATTERY ................................................................................................ 7-37
WIRING CONNECTIONS........................................................................ 7-37
FUSES..................................................................................................... 7-37
START SWITCH...................................................................................... 7-37
STARTER RELAY ................................................................................... 7-38
REMOTE CONTROL UNIT (DELUXE MODEL ONLY) ........................... 7-38
THROTTLE POSITION SENSOR ........................................................... 7-38
ACCELERATOR POSITION SENSOR ................................................... 7-38
STARTER MOTOR ........................................................................................ 7-39
EXPLODED DIAGRAM ........................................................................... 7-39
REMOVAL AND INSTALLATION CHART ............................................. 7-39
SERVICE POINTS .................................................................................. 7-41
Armature inspection .......................................................................... 7-41
Brush holder inspection..................................................................... 7-42
Starter motor front cover inspection .................................................. 7-42
CHARGING SYSTEM .................................................................................... 7-43
WIRING DIAGRAM ................................................................................. 7-43
FUSE ....................................................................................................... 7-44
BATTERY ................................................................................................ 7-44
LIGHTING COIL ...................................................................................... 7-44
RECTIFIER/REGULATOR ...................................................................... 7-44
OFF THROTTLE STEERING SYSTEM......................................................... 7-45
WIRING DIAGRAM ................................................................................. 7-45
STEERING SENSOR .............................................................................. 7-47
ECM......................................................................................................... 7-47
PICKUP COIL .......................................................................................... 7-47
THROTTLE POSITION SENSOR ........................................................... 7-47
ACCELERATOR POSITION SENSOR ................................................... 7-47
ProCarManuals.com

E
–+ELEC
INDICATION SYSTEM .................................................................................. 7-48
WIRING DIAGRAM ................................................................................. 7-48
FUSE ....................................................................................................... 7-50
BATTERY ................................................................................................ 7-50
MAIN AND FUEL PUMP RELAY............................................................. 7-50
ECM......................................................................................................... 7-50
ENGINE TEMPERATURE SENSOR ...................................................... 7-50
THERMOSWITCH (ENGINE).................................................................. 7-50
THERMOSWITCH (EXHAUST) .............................................................. 7-50
REMOTE CONTROL UNIT (DELUXE MODEL ONLY) ........................... 7-50
BUZZER .................................................................................................. 7-50
OIL PRESSURE SWITCH ....................................................................... 7-51
MULTIFUNCTION METER...................................................................... 7-51
Multifunction meter ............................................................................ 7-51
MULTIFUNCTION METER REMOVAL ................................................... 7-51
Display function (Sport model only) .................................................. 7-52
Display function (Deluxe model only) ................................................ 7-53
Speedometer display ........................................................................ 7-54
Tachometer display ........................................................................... 7-55
Hour meter display ............................................................................ 7-55
Voltage meter display........................................................................ 7-55
Low oil pressure warning indicator .................................................... 7-55
Fuel level meter display and fuel warning indicator .......................... 7-55
Overheat warning indicator ............................................................... 7-56
Check engine warning indicator ........................................................ 7-56
Diagnostic display ............................................................................. 7-57
REMOTE CONTROL SYSTEM (DELUXE MODEL ONLY) .......................... 7-58
WIRING DIAGRAM ................................................................................. 7-58
REMOTE CONTROL SYSTEM ............................................................... 7-59
Yamaha Security System indicator ................................................... 7-59
Low-rpm mode indicator.................................................................... 7-59
Checking the remote control transmitter ........................................... 7-60
Transmitter registration ..................................................................... 7-62
Replacing of the transmitter battery .................................................. 7-63
ProCarManuals.com

7-1
E
–+ELECELECTRICAL COMPONENTS
ELECTRICAL COMPONENTS
O
N
M
L
K
J
I
H
G
F
E
D
C
B
A
0
91
2
3
4
5
6
7
8
1Thermoswitch (engine)
2Fuse box
3Slant detection switch
4Starter motor
5Engine temperature sensor
6Spark plugs and ignition coils
7Cam position sensor
8Battery
9Speed sensor
0Sensor assembly (intake air
pressure and intake air tem-
perature)AOil pressure switch
BFuel injectors
CThermoswitch (exhaust)
DRectifier/regulator
EECM
FThrottle body assembly
GLighting coil and pickup coil
HEngine stop switch, engine
shut-off switch, and start
switch
ISteering sensor
JBuzzerKAccelerator position sensor
LElectric fuel pump
MFuel sender
NMultifunction meter
ORemote control unit (Deluxe
model only)
ProCarManuals.com

7-12
E
–+ELECIGNITION SYSTEM
IGNITION SYSTEM
WIRING DIAGRAM
10A
10A
3A
30A20A
WBrBRFREE
PUSHBWFREE
PUSH
Br BrFREE
PUSH
BW
W
BrBrBrBrR
W
B/W
B/O
B/O
B/O
B/R
P/R
P/R
W/B
P/W
P/W
B/O
L/B
B/WB/R
B/OP/W
P/R
W
W
WLR
Y
G
O
O
W
GG
BW
GG
O
OLG
W
Y
W
G/O
W/BR/Y
Y/G
BL
PBWP/W
B/GB/Y
Y/WL/RB/RB/W
B
B
BBP
P
P
BBP
RR
BBR
R/Y
B/OL/BB/OL/B
B/G
G/OB/OG/O
P/W
B/OB/YB/YR/Y
R/Y
R/Y
R/YB/YR/Y
R/Y
B/O
B/RR/Y
R/Y
R/YY/W
Y/GL/R
Y
P
P
O
O R
R
R
BB
BrRB/O
BBr
B/W
Y BrL R B
R
GB
R/YBBr
4
0 98
B
B B
B
H
I JK LM NOQ
PR
3
5
67 2 1
A
A A
A
C
D
E
F
G
1Battery
2Fuse (30 A)
3Fuse (20 A)
4Fuse (3 A)
5Fuse (10 A)
6Fuse (10 A)
7Starter relay
8Main and fuel pump
relay9Electronic control
throttle valve relay
0Slant detection switch
AIgnition coil
BSpark plug
CCam position sensor
DEngine temperature
sensor
EThermoswitch
(engine)FThermoswitch
(exhaust)
GOil pressure switch
HRemote control unit
(Deluxe model only)
IAntenna
(Deluxe model only)
JECM
KRectifier/regulatorLThrottle body assem-
bly
MAccelerator position
sensor
NPickup coil
OLighting coil
PStart switch
QEngine stop switch
REngine shut-off switch
ProCarManuals.com

7-31
E
–+ELECFUEL CONTROL SYSTEM
FUEL CONTROL SYSTEM
WIRING DIAGRAM
10A
10A
3A
30A20A
RR
BBR
B/W
B/O
B/O
B/R
P/R
P/R
P/W
P/W
B/O
L/B
B/WB/R
B/O
P/RP/W
G
O
W
O
OLG
WR/YP/GY/G
B
OL
PB
Pu/RPu/B
Pu/GPu/Y
P/W
R/Y
W/B
Y/WL/R
B
BBP
P
P
BBP
R/Y
B/OL/BB/OL/B
P/G
P/W
B/O
B/O
B/YB/YR/Y
R/Y
R/Y
R/YPu/G
Pu/Y
Pu/B
Pu/RR/Y
R/Y
R/Y
R/Y
R/YY/W
Y/GL/R
O
P
P
O
R
R
L
R
R
B
BLBL
B
B/GPPB
W/BR/YB RW
9 87
E
E E E FGH I3
4
56 2 1
0
A
B
C
D J
K
1Battery
2Fuse (30 A)
3Fuse (20 A)
4Fuse (10 A)
5Fuse (10 A)
6Starter relay
7Main and fuel pump relay
8Electronic control throttle valve
relay9Slant detection switch
0Sensor assembly
(intake air pressure and intake
air temperature)
AEngine temperature sensor
BThermoswitch (engine)
CThermoswitch (exhaust)
DOil pressure switch
EFuel injectorFECM
GThrottle body assembly
HAccelerator position sensor
IElectric fuel pump
JFuel sender
KMultifunction meter
ProCarManuals.com