3-24
E
INSP
ADJ
ELECTRICAL
3. Inspect:
Specific gravity
Out of specification →
Charge.
4. Install:
Filler caps
CAUTION:
Before installation, rinse off any fluid from
the battery box and battery and make sure
that the battery is dry before installing it.
Specific gravity at 20 °C (68 °F):
1.28
Charging current:
1.9 A
× 10 h
5. Install:
Battery breather hose 1
Battery
Battery positive lead 2
Battery negative lead 3
Bands
CAUTION:
Connect the positive lead to the battery
terminal first.
Make sure the battery leads are con-
nected properly. Reversing the leads can
seriously damage the electrical system.
Make sure that the battery breather hose is
properly connected and is not obstructed.
Coat the terminals with a water resistant
grease to minimize terminal corrosion.
ProCarManuals.com
3-25
E
INSP
ADJ
JET PUMP UNIT
JET PUMP UNIT
Impeller inspection
1. Check:
Impeller 1
Damage/wear →
Replace.
Nicks/scratches →
File or grind.
2. Measure:
Impeller-to-housing clearancea
Out of specification →
Replace.
Maximum impeller-to-housing
clearance:
0.35–0.45 mm (0.0138–0.0177 in)
Measurement steps:
Remove the battery leads.
Remove the intake grate and intake duct.
Refer to “INTAKE GRATE AND RIDE
PLATE” in Chapter 6.
Measure the clearance at each impeller
blade as shown (a total of three measure-
ments).
Install the intake duct and intake grate.
Refer to “INTAKE GRATE AND RIDE
PLATE” in Chapter 6.
Install the battery leads.
Water inlet strainer inspection
1. Inspect:
Water inlet strainer
Contaminants →
Clean.
Cracks/damage →
Replace.
Inspection steps:
Remove the ride plate.
Refer to “INTAKE GRATE AND RIDE
PLATE” in Chapter 6.
Remove the rubber plate.
Refer to “JET PUMP UNIT” in Chapter 6.
Remove the water inlet cover 1
.
Inspect the water inlet strainer mesh a
.
Install the water inlet cover.
Install the rubber plate.
Refer to “JET PUMP UNIT” in Chapter 6.
Install the ride plate.
Refer to “INTAKE GRATE AND RIDE
PLATE” in Chapter 6.
a
1
ProCarManuals.com
4-12
EFUEL
THROTTLE BODY ASSEMBLY AND INTAKE
MANIFOLD
SERVICE POINTS
Fuel hose clamps removal
1. Remove:
Fuel hose clamps
CAUTION:
If the fuel hose clamps are removed with-
out cutting the joint first, the fuel hose will
be damaged.
Hose clamps installation
1. Install:
Fuel hose clamps
WARNING
Do not reuse the fuel hose clamps, always
replace them with new ones.
NOTE:
Crimp the fuel hose clamps properly to
securely fasten them.
Fuel hose disconnection
WARNING
Before disconnecting the hose, remove the
fuel tank filler cap to reduce any pressure
inside the fuel tank, and then disconnect
the battery negative lead to cut off the elec-
tric current to the electrical systems.
1. Wrap the quick connector with a cloth, and
then rotate the quick connector tab 1
to
the stopper position a
.
WARNING
If the quick connector is removed sud-
denly, pressurized fuel could spray out. To
gradually release the fuel pressure, be sure
to remove the quick connector slowly.
1
a
ProCarManuals.com
5-1
EPOWRENGINE UNIT
ENGINE UNIT
EXPLODED DIAGRAM
REMOVAL AND INSTALLATION CHART
Step Procedure/Part name Q’ty Service points
ENGINE UNIT REMOVAL
Follow the left “Step” for removal.
Engine oil Drain.
Refer to “POWER UNIT” in Chapter 3.
Storage compartment panel Refer to “FRONT HOOD” in Chapter 8.
Battery negative and positive lead Refer to “FUSE BOX” in Chapter 7.
Fuel hose Refer to “FUEL INJECTION SYSTEM” in
Chapter 4.
Water lock and exhaust joint Refer to “EXHAUST SYSTEM” in Chapter 8.
1 Bolt/washer 2/2
2 Fuse box 1
14 10
10
2
113
3
4
11
15
12
8
7
9
6
5
2nd 18 N m (1.8 kgf m, 13 ft Ib) 1st 8.8 N m (0.88 kgf m, 6.4 ft Ib)
8 × 35 mm
6 × 25 mm
7.8 N m (0.78 kgf m, 5.6 ft Ib)
8 × 35 mm 17 N m (1.7 kgf m, 12 ft Ib)
17 N m (1.7 kgf m, 12 ft Ib)8 × 40 mm
17 N m (1.7 kgf m, 12 ft Ib)
10LT
242
LT
LT
572
LT
LT
271
ProCarManuals.com
5-33
EPOWRGENERATOR AND STARTER MOTOR
GENERATOR AND STARTER MOTOR
EXPLODED DIAGRAM
REMOVAL AND INSTALLATION CHART
Step Procedure/Part name Q’ty Service points
GENERATOR COVER AND
FLYWHEEL MAGNETO
REMOVALFollow the left “Step” for removal.
Engine unit Refer to “ENGINE UNIT”.
1 Nut/washer 1/1
2 Starter motor lead 1
3Bolt 2
4 Battery negative lead 1
5 Starter motor 1
6 Band 1
7 Lighting coil coupler 1
4 3
2 1
5
7
89
1113 12
18 16171920 21
15 14
AA
E
E
E
LT
572
LT
572
AA
AA
8 × 30 mm
18 N m (1.8 kgf
m, 13 ft
Ib)
4.9 N
m (0.49 kgf m, 3.5 ft Ib)
10 × 47 mm
75 N m (7.5 kgf
m, 54 ft
Ib) 8 × 20 mm
24 N m (2.4 kgf
m, 17 ft
Ib)
10 × 60 mm
2nd 50 N m (5.0 kgf
m, 36 ft
Ib) 1st 15 N m (1.5 kgf
m, 11 ft
Ib)
6
2nd 50 N m (5.0 kgf
m, 36 ft
Ib) 1st 15 N m (1.5 kgf m, 11 ft Ib)
10 × 135 mm
10
LT
572
LT
572
ProCarManuals.com
E
–+ELEC
1
2
3
4
5
6
7
8
9
CHAPTER 7
ELECTRICAL SYSTEM
ELECTRICAL COMPONENTS........................................................................ 7-1
FUSE BOX ....................................................................................................... 7-2
EXPLODED DIAGRAM ............................................................................. 7-2
REMOVAL AND INSTALLATION CHART ................................................ 7-2
ECM AND RECTIFIER/REGULATOR............................................................. 7-7
EXPLODED DIAGRAM ............................................................................. 7-7
REMOVAL AND INSTALLATION CHART ................................................ 7-7
ELECTRICAL ANALYSIS ............................................................................... 7-9
INSPECTION............................................................................................. 7-9
Digital tester ........................................................................................ 7-9
Low resistance measurement ........................................................... 7-10
Peak voltage measurement .............................................................. 7-10
Peak voltage adapter ........................................................................ 7-11
Test harness .................................................................................... 7-11
IGNITION SYSTEM ....................................................................................... 7-12
WIRING DIAGRAM ................................................................................. 7-12
IGNITION SPARK ................................................................................... 7-14
IGNITION SYSTEM PEAK VOLTAGE .................................................... 7-15
BATTERY ................................................................................................ 7-17
FUSE ....................................................................................................... 7-17
SPARK PLUGS ....................................................................................... 7-17
IGNITION COIL ....................................................................................... 7-18
ENGINE STOP SWITCH ......................................................................... 7-18
ENGINE TEMPERATURE SENSOR ...................................................... 7-19
SENSOR ASSEMBLY ............................................................................. 7-19
THERMOSWITCH (ENGINE).................................................................. 7-20
THERMOSWITCH (EXHAUST) .............................................................. 7-21
MAIN AND FUEL PUMP RELAY............................................................. 7-22
ELECTRONIC CONTROL THROTTLE VALVE RELAY ......................... 7-23
THROTTLE POSITION SENSOR ........................................................... 7-24
ACCELERATOR POSITION SENSOR ................................................... 7-26
CAM POSITION SENSOR ...................................................................... 7-29
SLANT DETECTION SWITCH ................................................................ 7-30
ProCarManuals.com
E
–+ELEC
FUEL CONTROL SYSTEM ........................................................................... 7-31
WIRING DIAGRAM ................................................................................. 7-31
ELECTRIC FUEL PUMP ......................................................................... 7-33
FUEL SENDER ....................................................................................... 7-33
FUEL INJECTOR .................................................................................... 7-34
MAIN AND FUEL PUMP RELAY............................................................. 7-34
OIL PRESSURE SWITCH ....................................................................... 7-34
THERMOSWITCH (ENGINE).................................................................. 7-34
THERMOSWITCH (EXHAUST) .............................................................. 7-34
SLANT DETECTION SWITCH ................................................................ 7-34
REMOTE CONTROL UNIT (DELUXE MODEL ONLY) ........................... 7-34
THROTTLE POSITION SENSOR ........................................................... 7-34
ACCELERATOR POSITION SENSOR ................................................... 7-34
STARTING SYSTEM ..................................................................................... 7-35
WIRING DIAGRAM ................................................................................. 7-35
BATTERY ................................................................................................ 7-37
WIRING CONNECTIONS........................................................................ 7-37
FUSES..................................................................................................... 7-37
START SWITCH...................................................................................... 7-37
STARTER RELAY ................................................................................... 7-38
REMOTE CONTROL UNIT (DELUXE MODEL ONLY) ........................... 7-38
THROTTLE POSITION SENSOR ........................................................... 7-38
ACCELERATOR POSITION SENSOR ................................................... 7-38
STARTER MOTOR ........................................................................................ 7-39
EXPLODED DIAGRAM ........................................................................... 7-39
REMOVAL AND INSTALLATION CHART ............................................. 7-39
SERVICE POINTS .................................................................................. 7-41
Armature inspection .......................................................................... 7-41
Brush holder inspection..................................................................... 7-42
Starter motor front cover inspection .................................................. 7-42
CHARGING SYSTEM .................................................................................... 7-43
WIRING DIAGRAM ................................................................................. 7-43
FUSE ....................................................................................................... 7-44
BATTERY ................................................................................................ 7-44
LIGHTING COIL ...................................................................................... 7-44
RECTIFIER/REGULATOR ...................................................................... 7-44
OFF THROTTLE STEERING SYSTEM......................................................... 7-45
WIRING DIAGRAM ................................................................................. 7-45
STEERING SENSOR .............................................................................. 7-47
ECM......................................................................................................... 7-47
PICKUP COIL .......................................................................................... 7-47
THROTTLE POSITION SENSOR ........................................................... 7-47
ACCELERATOR POSITION SENSOR ................................................... 7-47
ProCarManuals.com
E
–+ELEC
INDICATION SYSTEM .................................................................................. 7-48
WIRING DIAGRAM ................................................................................. 7-48
FUSE ....................................................................................................... 7-50
BATTERY ................................................................................................ 7-50
MAIN AND FUEL PUMP RELAY............................................................. 7-50
ECM......................................................................................................... 7-50
ENGINE TEMPERATURE SENSOR ...................................................... 7-50
THERMOSWITCH (ENGINE).................................................................. 7-50
THERMOSWITCH (EXHAUST) .............................................................. 7-50
REMOTE CONTROL UNIT (DELUXE MODEL ONLY) ........................... 7-50
BUZZER .................................................................................................. 7-50
OIL PRESSURE SWITCH ....................................................................... 7-51
MULTIFUNCTION METER...................................................................... 7-51
Multifunction meter ............................................................................ 7-51
MULTIFUNCTION METER REMOVAL ................................................... 7-51
Display function (Sport model only) .................................................. 7-52
Display function (Deluxe model only) ................................................ 7-53
Speedometer display ........................................................................ 7-54
Tachometer display ........................................................................... 7-55
Hour meter display ............................................................................ 7-55
Voltage meter display........................................................................ 7-55
Low oil pressure warning indicator .................................................... 7-55
Fuel level meter display and fuel warning indicator .......................... 7-55
Overheat warning indicator ............................................................... 7-56
Check engine warning indicator ........................................................ 7-56
Diagnostic display ............................................................................. 7-57
REMOTE CONTROL SYSTEM (DELUXE MODEL ONLY) .......................... 7-58
WIRING DIAGRAM ................................................................................. 7-58
REMOTE CONTROL SYSTEM ............................................................... 7-59
Yamaha Security System indicator ................................................... 7-59
Low-rpm mode indicator.................................................................... 7-59
Checking the remote control transmitter ........................................... 7-60
Transmitter registration ..................................................................... 7-62
Replacing of the transmitter battery .................................................. 7-63
ProCarManuals.com