2005 TOYOTA RAV4 spare wheel

'05 Rav4_U (L/O 0409)
250
2005 RAV4 from Sep. '04 Prod. (OM42570U)
To remove the jack, move the seat
to the rear- most position and turn the
jack joint by hand.
To remove: Turn the joint in direction
1 until the jack is free.
To store: Turn the joint in direction 2
until the jack is firmly secured to pre-
vent it flying forward during a collision
or sudden braking.
Clearances
Full spare tire cover
Half spare tire cover To remove the spare tire on the back
door:
1. Remove the spare tire cover.
Full spare tire coverÐUnhook the
latch handle which is on the bottom
of the cover. Pull up the cover by
grasping the clearances on both sides
between the cover and latch handle
base.
Half spare tire coverÐPry off the cen-
ter cover and loose the nut with wheel
nut wrench, then remove the spare
tire cover.

'05 Rav4_U (L/O 0409)
251
2005 RAV4 from Sep. '04 Prod. (OM42570U)
2. Turn the hold- down nuts counter-clockwise with the wheel nut
wrench and remove them.
When storing the spare tire, put it in
place and secure it to prevent it from
flying forward during a collision or
sudden braking.2. Block the wheel diagonally op- posite the flat tire to keep the
vehicle from rolling when it is
jacked up.
When blocking the wheel, place a
wheel block in front of one of the front
wheels or behind one of the rear
wheels.3. Loosen all the wheel nuts.
Always loosen the wheel nuts before
raising the vehicle.
Turn the wheel nuts counterclockwise
to loosen. To get maximum leverage,
fit the wrench to the nut so that the
handle is on the right side, as shown
above. Grab the wrench near the end
of the handle and pull up on the han-
dle. Be careful that the wrench does
not slip off the nut.
Do not remove the nuts yetÐjust un-
screw them about one- half turn.
ÐBlocking the wheel ÐLoosening wheel nuts

'05 Rav4_U (L/O 0409)
252
2005 RAV4 from Sep. '04 Prod. (OM42570U)
CAUTION
Never use oil or grease on the
bolts or nuts. The nuts may loose
and the wheels may fall off,
which could cause a serious ac-
cident.
4. Position the jack at the follow-ing jack points.
1 Front suspension cross mem- ber rear mounting
2 Rear suspension arm
Make sure the jack is positioned on
a level and solid place.5. After making sure that no one is in the vehicle, raise it high
enough so that the spare tire
can be installed.
Remember you will need more ground
clearance when putting on the spare
tire than when removing the flat tire.
To raise the vehicle, insert the jack
handle into the jack (it is a loose fit)
and turn it clockwise. As the jack
touches the vehicle and begins to lift,
double- check that it is properly posi-
tioned.
ÐPositioning the jack ÐRaising your vehicle

'05 Rav4_U (L/O 0409)
253
2005 RAV4 from Sep. '04 Prod. (OM42570U)
CAUTION
Never get under the vehicle when
the vehicle is supported by the
jack alone.
6. Remove the wheel nuts andchange tires.
Lift the flat tire straight off and put it
aside.
Roll the spare wheel into position and
align the holes in the wheel with the
bolts. Then lift up the wheel and get
at least the top bolt started through
its hole. Wiggle the tire and press it
back over the other bolts.Before putting on wheels, remove any
corrosion on the mounting surfaces
with a wire brush or such. Installation
of wheels without good metal- to- met-
al contact at the mounting surface can
cause wheel nuts to loosen and
eventually cause a wheel to come off
while driving.
ÐChanging wheels

'05 Rav4_U (L/O 0409)
255
2005 RAV4 from Sep. '04 Prod. (OM42570U)
CAUTION

When lowering the vehicle,
make sure all portions of your
body and all other persons
around will not be injured as
the vehicle is lowered to the
ground.

Have the wheel nuts tightened
with torque wrench to 103 N´m
(10.5 kgf´m, 76 ft´lbf), as soon
as possible after changing
wheels. Otherwise, the nuts
may loosen and the wheels
may fall off, which could cause
a serious accident.
9. Install the flat tire and spare tire
cover on the back door.
CAUTION
Make sure flat tire and spare tire
cover are securely in place in
their storage location to reduce
the possibility of personal injury
during a collision or sudden
braking.
Install the full spare tire cover by the
following procedure:
Guides
ÐStowing flat tire

'05 Rav4_U (L/O 0409)
294
2005 RAV4 from Sep. '04 Prod. (OM42570U)
The tires on your Toyota have built- in
tread wear indicators to help you
know when the tires need replace-
ment. When the tread depth wears to
1.6 mm (0.06 in.) or less, the indica-
tors will appear. If you can see the
indicators in two or more adjacent
grooves, the tire should be replaced.
The lower the tread, the higher the
risk of skidding.
The effectiveness of snow tires is
lost if the tread wears down below
4 mm (0.16 in.).
If you have tire damage such as
cuts, splits, cracks deep enough to
expose the fabric, or bulges indi-
cating internal damage, the tire
should be repl aced.
If a tire often goes flat or cannot be
properly repaired due to the size or
location of a cut or other damage, it
should be replaced. If you are not
sure, consult with your Toyota dealer. If air loss occurs while driving, do not
continue driving. Driving even a short
distance can damage a tire beyond
repair.
An y ti res wh i ch are over 6 years
old must be checked by a qualified
technician even if damage is not
obvious.
Tires deteriorate with age even if they
have never or seldom been used.
This applies also to the spare tire and
tires stored for future use.
REPLACING YOUR TIRES
When replacing a tire, use a tire of
the same size and construction,
and the same or greater maximum
load as the originally installed
tires. Also, on four- wheel drive
models, all the tires must be the
same brand and have the same
tread patterns.
Using any other size or type of tire
may seriously affect handling, ride,
speedometer/odometer calibration,
ground clearance, and clearance be-
tween the body and tires or snow
chains.
Check that the maximum load of the
replaced tire is greater than 1/2 of the
Gross Axle Weight Ratings (GAWR)
of either the front axle or the rear
axle, whichever is greater. As for the
maximum load of the tire, see the load
limit at maximum cold tire inflation
pressure mentioned on the sidewall
of the tire, and as for the Gross Axle
Weight Ratings (GAWR), see the Cer-
tification Label.

'05 Rav4_U (L/O 0409)
312
2005 RAV4 from Sep. '04 Prod. (OM42570U)
*1: Unladen vehicle*2: With steel wheel spare tire and half
spare tire cover
*3: With aluminum wheel spare tire and
half spare tire cover
*4: With full spare tire cover*5: With over fender*6: Two- wheel drive models*7: Four- wheel drive models*8: With roof rails*9: With automatic transmission*10: With manual transmission
Dimensions and weights
Overall length mm (in.)
Overall width mm (in.)
Overall height
*1mm (in.)
Wheelbase mm (in.)
Front tread mm (in.)
Rear tread mm (in.)
Vehicle capacity
weight (occupants
+ luggage) kg (lb.) 215/70R16 tires 235/60R16 tires
4205 (165.6)
4210 (165.7)
* 2
4215 (165.9)*3
4255 (167.5)*4
4220 (166.1)
4225 (166.3)*3
4255 (167.5)*4
1735 (68.3)
1785 (70.3)*51785 (70.3)
1670 (65.7)
1705 (67.1)
*8
2490 (98.0) 2490 (98.0)
1505 (59.3)
* 7
1510 (59.4)*61525 (60.0)
1495 (58.9)
* 7
1500 (59.1)*61520 (59.8)
345 (761)
* 7, 9
375 (826)*7, 10
417 (919)*6, 9
447 (985)*6, 10
345 (761)*7, 9
375 (826)*7, 10
417 (919)*6, 9
447 (985)*6, 10
1670 (65.7)*6
1680 (66.1)*7
1705 (67.1)*6, 8
1715 (67.5)*7, 8
Towing capacity (trailer
weight + cargo weight)
kg (lb.)680 (1500) 680 (1500)