2005 MITSUBISHI LANCER EVOLUTION IX window

BODY – GENERAL, WINDOW GLASS CHANNEL, DOOR-OPENING WEATHER STRIP42-1
SECTION 42
BODY
CONTENTS
General........................................................1 Window glass channel, door-opening
weather strip ...........................1
General
Servicing guidelines have been amended in conjunction with the changes listed below. Other servicing guidelines remain
unchanged.
•Addition of front door opening inner lower weather strip
•Addition of front and rear door opening inner weather strip
Window glass channel, door-opening weather strip

Removal and fitting

Note
: position of clips
Cross section A – A
front door trim
clip
Removal of the front door opening inner
lower weather strip
1. Front door opening inner lower weather
strip
Procedure for removing the front door
opening inner weather strip
•Front scuff plate
•Cowl side trim
•Lower centre pillar trim2. Front door opening inner weather strip
Procedure for removing the rear door
opening inner weather strip
•Rear scuff plate
•Lower centre pillar trim
3. Rear door opening inner weather strip

LAYOUT DIAGRAMS - INSTRUMENT PANEL1-15
C-214 (5) Blower relay
C-215 (15) Floor harness (RH) / J/B junction
C-216 (3) Roof harness / J/B junction
C-217 (4) Dummy connector
C-218 (4) Dummy connector
C-219 (4) Fuel pump relay 2
C-220 (4) Intercooler water spray relay
C-221 (4) Fuel pump relay 1C-222 (5) Power window relay
C-223 (2) Instrument panel harness / J/B junction
C-224 (20) ETACS-ECU
C-225 (24-grey) ETACS-ECU
C-226 (24) ETACS-ECU
C-228 (5) Steer sensor
(Front side)
Instrument panel harness
Dedicated fuse
Floor harness (RH)
Roof harness(Rear side)

LAYOUT DIAGRAMS - DOORS1-18
E-01 (7) Remote control door mirror (RH)
E-02 (14) Power window main switch
E-03 (6-black) Door lock actuator (front : RH)
E-04 (6-grey) Power window motor (front : RH)
E-05 92) Front door speaker (RH)
E-06 (8) Power window sub-switch (front : LH)E-07 (7) Remote control door mirror (LH)
E-08 92) Front door speaker (LH)
E-09 (6-grey) Power window motor (front : LH)
E-10 (6-black) Door block actuator (front : LH)
DOORS
Connector Symbol
(Passenger side) (Driver side)Front doors
Front door
harness (LH)Front door
harness (RH)

LAYOUT DIAGRAMS - DOORS 1-19
E-101 (6-grey) Power window motor (rear : RH)
E-102 (8) Power window sub-switch (rear : RH)
E-103 (6-black) Door lock actuator (rear : RH)E-104 (6-grey) Power window motor (rear : LH)
E-105 (8) Power window sub-switch (rear : LH)
E-106 (6-black) Door lock actuator (rear : LH)
Rear doors
(Passenger side) (Driver side)
Rear door
harness (LH)Rear door
harness (RH)

PART INSTALLATION POSITIONS - ECU2-8
Glove box
Power window main
switch (built-in ECU)Sunroof motor ASSY
(built-in ECU)
Power window main
switch (built-in ECU)

PART INSTALLATION POSITIONS - SOLENOID VALVES2-10
SOLENOID VALVES
Fuel pump relay 1
Intercooler water
spray relay
Fuel pump relay 2Fuel pump relay 1
Blower relay
Power window relay
Oil feeder control
valveFuel pressure
solenoid valve
Purge control
solenoid valve

3-1
SECTION 3
CIRCUIT DIAGRAMS
CONTENTS
J/B ............................................................3-4
J/C ............................................................3-6
Central Junction....................................3-11
Power Supply ........................................3-18
Starting System ....................................3-23
Ignition ...................................................3-24
Charging ................................................3-26
Engine Control ......................................3-28
Cooling ..................................................3-36
Lighting
Headlights (excl. discharge type).....................3-38
Headlights (discharge type) .............................3-42
Tail lights, position lights, licence plate
lights, lighting monitor report buzzer................3-46
Cabin lights, boot compartment lights,
ignition key cylinder illumination light,
door ajar indicator light ....................................3-50
Fog lamps ........................................................3-54
Headlight levelling system ...............................3-58
Signals
Turn signal lights, hazard warning lights .........3-60
Reversing lights ...............................................3-64
Stop lights ........................................................3-65
Horn .................................................................3-66
Meters
Needle meters..................................................3-68
Remaining fuel warning light, oil pressure
warning light, brake warning light,
seatbelt warning light .......................................3-70
Door Opening / Closing Control
Power windows ................................................3-72
Central door locking
(vehicle without keyless entry) .........................3-78
Central door locking
(vehicle with keyless entry) ..............................3-80
Temperature Control
Heater ..............................................................3-86
Manual air-conditioning ....................................3-90
Fully automatic air-conditioning .......................3-96
Vision / Safety
Windscreen washer / wipers ..........................3-104
Rear washer / wiper .......................................3-108
Demister
(vehicle with heater or manual A/C) ...............3-110
Demister, door mirror heating elements
(vehicle with full auto A/C)..............................3-112
Electric stowable remote control
door mirrors ....................................................3-114
Accessories
Spare audio connectors .................................3-118
Clock ..............................................................3-120
Cigarette lighter, ashtray illumination lamp ....3-121
Cont. on next page

CIRCUIT DIAGRAMS - J/B3-4
J/B
Power
window
relay
Water
spray
relay
Dummy
connectorDummy connector
J/B side connector Note :
The connector numbers correspond to the layout diagrams,
and to the instrument panel and respective circuit diagrams. Demister
relayBlower
relayFuel
pump
relay 2
Fuel
pump
relay 1 Generic fuse