2005 MERCEDES-BENZ E WAGON air condition

Contents
Control system .................................. 153
Multifunction display .................... 153
Multifunction steering wheel ........ 154
Menus .......................................... 156
Standard display menu ................ 158
AUDIO menu ................................ 158
NAV* menu .................................. 160
Distronic* menu........................... 160
Vehicle status message
memory menu .............................. 161
Settings menu .............................. 162
Trip computer menu..................... 178
TEL menu* ................................... 179
Automatic transmission ..................... 183
One-touch gearshifting................. 185
Gear ranges ................................. 186
Gear selector lever position ......... 187
Automatic shift program .............. 188
Driving tips ................................... 189
Emergency operation
(Limp Home Mode) ...................... 190Good visibility ..................................... 191
Headlamp cleaning system* ......... 191
Rear view mirror ........................... 191
Sun visors ..................................... 193
Roller sunblind* in the rear doors . 194
Rear window defroster .................. 195
Dual-zone automatic climate control .. 196
Deactivating the dual-zone
automatic climate control system. 201
Setting the temperature................ 201
Adjusting air distribution............... 201
Adjusting air volume ..................... 202
Defrosting ..................................... 203
Air recirculation mode .................. 204
Air conditioning............................. 206
Residual heat and ventilation* ...... 2074-zone automatic climate control* ..... 208
Deactivating the 4-zone
automatic climate control system 213
Setting the temperature ............... 214
Adjusting air distribution .............. 214
Adjusting air volume ..................... 215
Defrosting ..................................... 215
Maximum cooling MAX COOL ....... 216
Air recirculation mode .................. 216
Air conditioning ............................ 218
Residual heat and ventilation ....... 219
Rear air conditioning..................... 219
Power windows .................................. 221
Opening and closing the windows 221
Synchronizing power windows ...... 223
Summer opening feature .............. 223
Convenience closing feature......... 224
Power tilt / sliding sunroof* ................ 225
Opening and closing the power
tilt / sliding sunroof ....................... 225
Synchronizing the power
tilt / sliding sunroof ....................... 227

ContentsTechnical data.................................. 437
Parts service ...................................... 438
Warranty coverage ............................. 439
Loss of Service and Warranty
Information Booklet...................... 439
Identification labels............................ 440
Layout of poly-V-belt drive ................. 441
E 320 / E 500 ............................... 441
Engine ................................................ 442
Rims and tires .................................... 443
Same size tires ............................. 444
Mixed size tires ............................ 445
Minispare wheel ........................... 446
Electrical system................................ 447
Main dimensions................................ 448
Weights .............................................. 449Fuels, coolants, lubricants etc. .......... 450
Capacities .................................... 450
Engine oils.................................... 453
Engine oil additives ...................... 453
Air conditioning refrigerant .......... 453
Brake fluid .................................... 453
Premium unleaded gasoline ......... 454
Gasoline additives ........................ 454
Fuel requirements ........................ 455
Coolants....................................... 455
Windshield and headlamp washer
system ......................................... 458
Technical terms............................... 459Index................................................. 465

11 Introduction
Operator’s Manual
Important notice for California retail
buyers and lessees of Mercedes-Benz automobiles
Under California law you may be entitled to
a replacement of your vehicle or a refund
of the purchase price or lease price, if
Mercedes-Benz USA, LLC and / or its au-
thorized repair or service facilities fail to fix
one or more substantial defects or mal-
functions in the vehicle that are covered by
its express warranty after a reasonable
number of repair attempts. During the pe-
riod of 18 months from original delivery of
the vehicle or the accumulation of
18 000 miles (approximately 29 000 km)
on the odometer of the vehicle, whichever
occurs first, a reasonable number of repair
attempts is presumed for a retail buyer or
lessee if one or more of the following oc-
curs: (1) the same substantial defect or mal-
function results in a condition that is
likely to cause death or serious bodily
injury if the vehicle is driven, that de-
fect or malfunction has been subject to
repair two or more times, and you have
directly notified Mercedes-Benz USA,
LLC in writing of the need for its repair,
(2) the same substantial defect or mal-
function of a less serious nature than
category (1) has been subject to repair
four or more times and you have direct-
ly notified us in writing of the need for
its repair, or(3) the vehicle is out of service by reason
of repair of the same or different sub-
stantial defects or malfunctions for a
cumulative total of more than
30 calendar days.
Written notification should be sent to us,
not a dealer, at Mercedes-Benz USA, LLC,
Customer Assistance Center, One
Mercedes Drive, Montvale,
NJ 07645-0350.

95 Safety and Security
Driving safety systems
Note on driving with the SBC

Following extended periods of only
minor loads to your brake system, you
should occasionally apply the brakes
when traveling at high speeds. This
improves the grip of the brake pads.


After driving on wet or snow-covered
roads, you should apply your brakes
firmly before parking your vehicle. This
produces heat which serves to dry the
brake disks and help prevent corro-
sion.


On long and steep grades, shift to a
lower gear (gear range1, 2, or 3) to
prevent the brakes from overheating
and to reduce brake wear.


After hard braking, it is advisable to
drive on for some time so that the air
stream will cool down the brakes fast-
er.


Only Mercedes-Benz approved compo-
nents (e.g. brake pads) should be
installed on your vehicle. Brake pads
not approved by Mercedes-Benz may
impair the safety of your vehicle.Four wheel electronic traction system
(4MATIC) with the ESP
Models with all-wheel-drive only.
The 4MATIC improves vehicle’s ability to
use available traction, e.g. during winter
operation in mountains under snowy
conditions, by applying power to all four
wheels.
Warning!
G
Be very careful not to endanger other road
users when you apply the brakes.
Warning!
G
If you see the ESP warning lampv flash-
ing in the speedometer, proceed as follows:

While driving off, apply as little throttle
as possible


While driving, ease up on the accelera-
tor


Adapt your speed and driving style to
the prevailing road conditions
Failure to observe these guidelines could
cause the vehicle to skid.
The ESP cannot prevent accidents resulting
from excessive speed.

200 Controls in detailDual-zone automatic climate controlThe climate control is operational whenev-
er the engine is running. You can operate
the climate control system in either the au-
tomatic or manual mode. The system cools
or heats the interior depending on the se-
lected interior temperature and the cur-
rent outside temperature.Nearly all dust particles, pollutants and
odors are filtered out before outside air en-
ters the passenger compartment through
the air distribution system.
The air conditioning will not engage (no
cooling) if the AC
OFF
mode is activated or
AC mode is deactivated (
page 206).
Warning!
G
When operating the climate control, the air
that enters the passenger compartment
through the air vents in the footwell can be
very hot or very cold (depending on the set
temperature). This may cause burns or frost-
bite to unprotected skin in the immediate
area of the air vents. Always keep sufficient
distance between unprotected parts of the
body and the footwell air vents. If necessary
change the air flow using the air distribution
controls (
page 198) to direct the air away
from the footwell air vents.
Warning!
G
Follow the recommended settings for heat-
ing and cooling given on the following pag-
es. Otherwise the windows could fog up,
impairing visibility and endangering you and
others.
iSevere conditions (e.g. strong air pollu-
tion) may require replacement of the fil-
ter before its scheduled interval. A
clogged filter will reduce the air volume
to the interior.
If the vehicle interior is hot, ventilate
the interior before driving off.
Keep the air intake grille in front of the
windshield free of snow and debris.
Do not obstruct air flow by placing ob-
jects on the air flow-through exhaust
slots below the rear window.

201 Controls in detail
Dual-zone automatic climate control
Deactivating the dual-zone automatic climate control system
Deactivating
Press button M (
page 198) or
button´ (
page 199).
Reactivating

Press button M (
page 198) or
button´ (
page 199) again.
or

Press any button on the climate control
panel (
page 198) or (
page 199).
Setting the temperature
Use temperature controls1 and6
(page 198) or (
page 199) to separate-
ly adjust the air temperature on each side
of the passenger compartment. You
should raise or lower the temperature set-
ting in small increments, preferably start-
ing at 72°F (22°C).
Increasing

Turn the temperature control1 or6
(page 198) or (
page 199) slightly
to the right.
The climate control system will corre-
spondingly adjust the interior air tem-
perature.
Decreasing

Turn the temperature control1 or6
(page 198) or (
page 199) slightly
to the left.
The climate control system will corre-
spondingly adjust the interior air tem-
perature.
Adjusting air distribution
Use air distribution control4
(page 198) or (
page 199) to adjust the
air distribution.
iWhen the air conditioning is switched
off, the outside air supply and circula-
tion are also switched off. Only choose
this setting for a short time. Otherwise
the windows could fog up.
Symbol
Function
a
Directs air through the center,
side and rear passenger com-
partment air vents
Z
Directs air to the windows
X
Directs air into the entire
vehicle interior
Y
Directs air to the footwells

203 Controls in detail
Dual-zone automatic climate control
Adjusting center air vents:
The thumbwheels for left2 and right6
(page 197) center air vents are automat-
ically positioned for optimum interior air-
flow. In this position, center air vent4
(page 197) and adjustable left and right
center vents3 and5 (
page 197) are
fully opened.
Windshield fogged on the outside

Switch the windshield wipers on
(page 52).

Press the Ubutton.
The indicator lamp on the button
comes on.
Defrosting
Activating
Press buttonP (
page 198)
or0 (
page 199).
The indicator lamp on the button
comes on.The air conditioning switches
automatically to the following func-
tions:


maximum blowing and heating
power


air flows onto the windshield
and the front side windows


the air recirculation mode is
switched off
Deactivating

Press buttonP (
page 198)
or0 (
page 199).
The indicator lamp on the button goes
out. Defrosting is turned off.
iThese settings should only be selected
for a short time.

205 Controls in detail
Dual-zone automatic climate control
Deactivating
Press buttonO (
page 198) or
(
page 199).
The indicator lamp on the button goes
out.The air recirculation mode is deactivated
automatically:


after five minutes if the outside temper-
ature is below approximately 41°F
(5°C)


after five minutes if the air conditioning
is turned off


after 30 minutes if the outside temper-
ature is above approximately 41°F
(5°C)
At outside temperatures above 79°F
(26°C), the system will not automatically
switch back to outside air. A quantity of
outside air is added after approximately
30 minutes.
iThe air recirculation mode is activated
automatically at high outside tempera-
tures.
If you have turned off the air condition-
ing (
page 206) or the outside
temperature is below 41°F (5°C), the
air recirculation mode will not switch
on automatically.
iIf you keep buttonO pressed, the
side windows and tilt/sliding sunroof*
will return to their previous position.