2005 MERCEDES-BENZ CLK320 COUPE fuel cap

356 Practical hintsWhat to do if …?Problem
Possible cause
Suggested solution
?
±
(USA only)
(Canada only)
The yellow engine
malfunction indi-
cator lamp comes
on while driving.
There is a malfunction in:

The fuel management system


The ignition system


The emission control system


Systems which affect emissions
Such malfunctions may result in ex-
cessive emissions values and may
switch the engine to its Limp-Home
Mode (emergency operation).

Have the vehicle checked as soon as possi-
ble by an authorized Mercedes-Benz Center.
An on-board diagnostic connector is used by
the service station to link the vehicle to the
shop diagnostics system. It allows the accu-
rate identification of system malfunctions
through the readout of diagnostic trouble
codes. It is located in the front left area of the
footwell next to the parking brake pedal.
A loss of pressure has been
detected in the fuel system. The fuel
cap may not be closed properly or
the fuel system may be leaky.

Check the fuel cap (
page 305).
If it is not closed properly:

Close the fuel cap.
If it is closed properly:

Have the fuel system checked by an autho-
rized Mercedes-Benz Center.
Your fuel tank is empty.

After refuelling, start, turn off, and restart the
engine three or four times in succession.
The Limp-Home mode is canceled. You do not
need to have your vehicle checked.

447 Technical data
Fuels, coolants, lubricants, etc.
Fuels, coolants, lubricants, etc.
CapacitiesVehicle components and their respective
lubricants must match. Therefore only use
products tested and approved by
Mercedes-Benz.Please refer to the Factory Approved Ser-
vice Products pamphlet, or inquire at your
Mercedes-Benz Center.
Model
Capacity
Fuels, coolants, lubricants, etc.
Engine with oil filter
CLK 320
CLK 500
CLK 55 AMG
8.5 US qt (8.0 l)
7.5 US qt (7.0 l)
9.0 US qt (8.5 l)
Approved engine oils
Automatic transmission
CLK 320
CLK 500
CLK 55 AMG
8.0 US qt (7.5 l)
9.3 US qt (8.7 l)
9.3 US qt (8.7 l)
MB Automatic Transmission Fluid
Rear axle
CLK 320
CLK 500
CLK 55 AMG
1.28 US qt (1.2 l)
1.5 US qt (1.4 l)
1.5 US qt (1.4 l)
Hypoid gear oil SAE 85 W 90
Power steering
approx. 1.1 US qt (1.0 l)
MB Power Steering Fluid (Pentosin
CHF 11S)
Front wheel hubs
approx. 3.0 oz (85 g) each
High temperature roller bearing grease
Brake system
0.64 US qt (0.6 l)
MB Brake Fluid (DOT 4+)

448 Technical dataFuels, coolants, lubricants, etc.
Model
Capacity
Fuels, coolants, lubricants, etc.
Cooling system
CLK 320
CLK 500
CLK 55 AMG
approx. 10.7 US qt (10.0 l)
approx. 12.8 US qt (12.0 l)
approx. 12.8 US qt (12.0 l)
MB 325.0 Anticorrosion/Antifreeze
Agent
Fuel tank
including a reserve of
CLK 320
CLK 500
CLK 55 AMG
16.35 US gal (62.0 l)
2.11 US gal (8.0 l)
2.11 US gal (8.0 l)
2.64 US gal (10.0 l)
Premium unleaded gasoline:
Minimum Posted Octane 91
(Avg.of96RON/86MON)
Air conditioning system
R-134a refrigerant and special PAG lu-
bricant oil (never R-12)
Windshield washer and
headlamp cleaning system*
6.4 US qt (6.0 l)
MB Windshield Washer Concentrate
1
1Use MB Windshield Washer Concentrate “S” and water for temperatures above freezing point or MB Windshield Washer Concentrate “S” and commercially available
premixed windshield washer solvent / antifreeze for temperatures below freezing point. Follow suggested mixing ratios (page 454).

452 Technical dataFuels, coolants, lubricants, etc.Coolants
The engine coolant is a mixture of water
and anticorrosion / antifreeze, which
provides:

Corrosion protection


Freeze protection


Boiling protection (by increasing the
boiling point)
The cooling system was filled at the factory
with a coolant providing freeze protection
to approximately -22°F (-30°C) and corro-
sion protection.
If the antifreeze mixture is effective
to -22°F (-30°C), the boiling point of the
coolant in the pressurized cooling system
is reached at approx. 266°F (130°C).The coolant solution must be used
year-round to provide the necessary corro-
sion protection and increase boil-over pro-
tection. Refer to Maintenance Booklet for
replacement interval.
Coolant system design and coolant used
determine the replacement interval. The
replacement interval published in the
Maintenance Booklet is only applicable if
MB 325.0 anticorrosion/antifreeze solu-
tion or other Mercedes-Benz approved
products of equal specification (see Facto-
ry Approved Service Products pamphlet)
are used to renew the coolant concentra-
tion or bring it back up to the proper level.To provide important corrosion protection,
the solution must be at least 45% anticor-
rosion/antifreeze (equivalent to freeze
protection to approx. -22°F [-30°C]). If you
use a solution that is more than 55% anti-
corrosion/antifreeze (freeze protection to
approx. -49°F [-45°C]), the engine temper-
ature will increase due to the lower heat
transfer capability of the solution. There-
fore, do not use more than this amount of
anticorrosion/antifreeze.
If the coolant level is low, water and MB
Anticorrosion /Antifreeze should be used
to bring it up to the proper level (have cool-
ing system checked for signs of leakage).
Please make sure the mixture is in accor-
dance with label instructions.
The water in the cooling system must meet
minimum requirements, which are usually
satisfied by normal drinking water. If you
are not sure about the water quality,
consult an authorized Mercedes-Benz
Center.

454 Technical dataFuels, coolants, lubricants, etc.Windshield washer system and headlamp cleaning system*
Both the windshield washer and headlamp
cleaning system are supplied from the
windshield washer fluid reservoir.
The washer fluid reservoir has a capacity of
approx. 6.4 US qt (6.0 l).

Refill the reservoir with MB Windshield
Washer Concentrate “S” and water (or
concentrate and commercially avail-
able premixed windshield washer
solvent / antifreeze, depending on
ambient temperatures).Windshield and headlamp washer fluid
mixing ratio
For temperatures above freezing point, use
MB Windshield Washer Concentrate “S”
and water:


1 part “S” to 100 parts water
(1.34 fl oz [40 ml] “S” to 1 gallon [4.0 l]
water)
For temperatures below freezing point, use
MB Windshield Washer Concentrate “S”
and commercially available premixed
windshield washer solvent / antifreeze:


1 part “S” to 100 parts solvent
(1.34 fl oz [40 ml] “S” to 1 gallon [4.0 l]
solvent)
Warning!
G
Washer solvent/antifreeze is highly flam-
mable. Do not spill washer
solvent/antifreeze on hot engine parts, be-
cause it may ignite and burn. You could be
seriously burned.

464 IndexBattery, vehicle 314, 420
Charging 422
Disconnecting 421
Messages in display 373
Reconnecting 422
Reinstalling 422
Removing 421
Bead 338
Bi-Xenon headlamps* 455
Block heater (Canada only) 343
Blocking
Rear window operation 82
Bolts
For spare wheel 396
Brake assist system (BAS) 455
Brake fluid 450
Message in display 374
Brake lamp bulbs 405
Brake lamp, high mounted 405
Brake pads
Message in display 374
Brakes 296
Warning lamp 355
Break-in period 294Bulbs, replacing 404
Additional turn signals 404
Backup lamps 405
Brake lamps 405
Fog lamps 404
Front lamps 404
High beam (Bi-Xenon*) 404
High beam (Halogen) 404
High beam flasher (Bi-Xenon*) 404
High beam flasher (Halogen) 404
High mounted brake lamp 405
License plate lamps 405, 410
Low beam (Bi-Xenon*) 404
Low beam (Halogen) 404
Parking lamps 404, 405, 407, 409
Rear fog lamp 405, 410
Side marker lamps 404, 409
Standing lamps 404, 405, 407, 409
Tail lamp assemblies 405, 410
Turn signal lamps 404, 405
Button
Audio system 210C
CAC (Customer Assistance Center) 455
Calling up
Maintenance service indicator 345
Range (distance to empty) 162
CAN system 455
Canceling
Cruise control 257
Capacities
Fuels, coolants, lubricants, etc. 447
Cargo tie-down rings 271
Catalytic converter 303
CD changer* 225
CD operation 225
CD player
Operating 144
Center console 27
Front passenger front
air bag off indicator lamp 360
Lower part 28
Upper part 27
Centigrade
Setting temperature units 149

470 IndexF
Fahrenheit
Setting temperature units 149
Fastening the seat belts 43
Fine adjustment
Cruise control 259
First aid kit 389
Flat tire 412
Collapsible tire
(CLK 55 AMG only) 394
Lowering the vehicle 418
Minispare wheel
(except CLK 55 AMG) 393
Mounting the spare wheel 413
Preparing the vehicle 412
Flexible Service System (Canada vehicles)
see Maintenance service system
Flexible Service System (FSS) 456
Floormats*
Removing 278
Installing 278Fog lamp, rear 128, 405
Fog lamps
Replacing bulbs 404
Fog lamps, front
Messages in display 382
Replacing bulbs 405
Switching on 128
Front air bags 65
Front lamps
Messages in display 382–384
Replacing bulbs 404, 406
Switching on 124
Front passenger front
air bag off indicator lamp 77, 360
Front seat head restraints
Installing 114
Power seat 114
Removing 114
Front seats
Seat heating* 119
Ventilation* 120
FSS (Canada vehicles) see
Maintenance service system
FSS (Flexible Service System) 456Fuel 306
Additives 451
Fuel reserve warning lamp 359
Gasoline additives 451
Premium
unleaded gasoline 306, 448, 450
Requirements 451
Reserve warning 25
Technical data 447
Fuel additives 451
Fuel cap
Message in display 356
Fuel consumption statistics
After start 161
Since last reset 161
Fuel filler flap 305
Locking 305
Opening 399
Unlocking 305
Fuel requirements 451
Fuel reserve tank
Message in display 381
Fuel tank
Capacity 448
Filler flap 305

471 Index
Fuels, coolants, lubricants etc.
Capacities 447
Functions (control system) 138, 141
Resetting 147
Fuse box 430, 431
Fuse chart 430
Fuse extractor 430
Fuses 429
Aids for changing fuses 430
Auxiliary fuse box in trunk 432
Fuse box in engine compartment 431
Fuse box in
passenger compartment 430
Fuse chart 430
Fuse extractor 430
Spare fuses 430G
Garage door opener 29, 287
Gasoline see Fuel
Gasoline additives 451
GAWR 338
Gear range 456
Automatic transmission 168
Limiting 168
Shifting into optimal 167
Gear range limit
Canceling 167
Gear selector lever 25, 165, 400
Cleaning 351
Lock 47
Message in display 372
Position 25
Position
(Automatic transmission) 165, 169
Unlocking manually 400Global
Locking 96
Locking with KEYLESS-GO* 101
Unlocking 96
Unlocking with KEYLESS-GO* 101
Global Positioning System (GPS) 456
Glove box 23, 272
Closing 272
Opening 272
Good visibility 178
GPS 456
Gross Axle Weight Rating see GAWR
Gross Vehicle Weight Rating see GVWR
Gross Vehicle Weight see GVW
GVW 338
GVWR 339