2005 KIA Rio ignition

3-37
Safety Belt Warning Light and Chime
As a reminder to the driver and passenger, safety belt
warning light will illuminate for approximately 6 sec-
onds each time you turn the ignition switch ON.
If the driver’s lap/shoulder belt is not fastened when
the key is turned ON, the safety belt warning chime
sounds for approximately six seconds and the safety
belt warning light illuminates for approximately six
seconds.
AN7B03016
Safety belt warning light
Front Lap/Shoulder Belt
To fasten the front lap/shoulder belt:
1. Grasp the buckle and tongue plate.
2. Slowly pull the lap/shoulder belt out from the
retractor.
1GQA2084A
RIO ENG CNA 3.qxd 7/29/05 5:13 PM Page 37

3-47
(Continued)
 Always wear your safety belt. It can help
keep you away from the air bags during
heavy braking just before a collision.
 Air bags are designed to inflate only in
severe frontal collisions and will generally
not provide protection in side or rear
impacts, rollovers or less severe frontal colli-
sions. They will also not provide protection
from later impacts in a multi-impact colli-
sion.
 If your vehicle has been subjected to flood
conditions (e.g. soaked carpeting/standing
water on the floor of the vehicle, etc.) or if
your vehicle has become flood damaged in
any way, do not attempt to start the vehicle
or put the key in the ignition before discon-
necting the battery. This may cause air bag
deployment, which could result in serious
personal injury or death. Have the vehicle
towed to an authorized Kia dealer for
inspection and necessary repairs.
Air Bag System ComponentsThe main components of your vehicle’s SRS are:
 One air bag in the steering wheel for the driver, and
another in the dashboard for the front passenger.
 A diagnostic system that continually monitors sys-
tem operation.
 An indicator light to warn you of a possible problem
with the system.
 Emergency power backup in case your car’s electri-
cal system is disconnected in a crash.
1B3102002E
Driver’s side
air bag
RIO ENG CNA 3.qxd 7/29/05 5:13 PM Page 47

Knowing Your Vehicle3-50YOU MUST ALWAYS SIT AS FAR BACK FROM
THE STEERING WHEEL AIR BAG AS POSSI-
BLE, WHILE STILL MAINTAINING A COM-
FORTABLE SEATING POSITION FOR GOOD
VEHICLE CONTROL, IN ORDER TO REDUCE
THE RISK OF INJURY OR DEATH IN A COLLI-
SION.
WARNING - Air Bag Injuries
 Sit as far back from the steering wheel as
possible without interfering with your con-
trol of the vehicle. Positioning yourself too
close to the steering wheel can result in seri-
ous or even fatal injuries if the air bag
deploys.
 Never place objects over the air bag storage
compartments or between the air bags and
yourself. Due to the speed and force of the
air bag inflation, such objects could hit your
body at high speed and cause severe bodily
injury and even death.
Noise and SmokeWhen the air bags inflate, they make a loud noise and
they leave smoke and powder in the air inside of the
vehicle. This is normal and is a result of the ignition of
the air bag inflator.
After the air bags inflate, you may feel substantial dis-
comfort in breathing due both to the contact by your
chest with both the safety belt and the air bag, as well
as from breathing the smoke and powder. We strongly urge you to open your doors and/or windows
as promptly as possible after impact in order to reduce
discomfort and prevent prolonged exposure to the smoke
and powder.
WARNING - Hot Metal Parts
When the air bags deploy, the air bag inflators
in the steering wheel and/or in the dashboard
are very hot. To prevent injury, do not touch the
air bag storage area’s internal components
immediately after an air bag has inflated.
RIO ENG CNA 3.qxd 7/29/05 5:13 PM Page 50

Knowing Your Vehicle3-52 Air Bag Warning LightThe purpose of the air bag warning light in your instru-
ment panel is to alert you of a potential problem with
your Air Bag – Supplemental Restraint System (SRS).
WARNING - Front Passengers
 NEVER use a child restraint in the front
seat. There is a very significant risk of seri-
ous or fatal injuries to a child in a child
restraint if the right front passenger air bag
inflates.

In the front seat, a rear-facing child restraint
would be positioned too close to where the
air bags are stored and in the event an air
bag deploys, the air bag would impact the
rear-facing child restraint and cause serious
injuries or death.
 Failure to observe the instructions provided
with the child restraint system could
increase the risk and/or severity of injury in
an accident.
Have the system checked if:
 The light does not illuminate when you turn the
ignition ON.
 The light stays ON after the engine starts.
 The light comes ON or flashes while you are dri-
ving.
A-BAG-W
AIR BAG WARNING LIGHT
RIO ENG CNA 3.qxd 7/29/05 5:13 PM Page 52

4-1
DRIVING YOUR VEHICLEIgnition Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-2
Starting the Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-4
Manual Transaxle . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-7
Automatic Transaxle . . . . . . . . . . . . . . . . . . . . . . . . . . .4-9
Brake System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-15
Power Steering . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-22
Tilt Steering . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-22
Instrument Cluster . . . . . . . . . . . . . . . . . . . . . . . . . . .4-23
Gauges . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-25
Warnings and Indicators . . . . . . . . . . . . . . . . . . . . . .4-27
Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-33
Daytime Running Lights(DRL) . . . . . . . . . . . . . . . . . .4-35
Wipers and Washers . . . . . . . . . . . . . . . . . . . . . . . . . .4-36
Rear Window Defroster . . . . . . . . . . . . . . . . . . . . . . . .4-38
Interior Features . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-40
Climate Control System . . . . . . . . . . . . . . . . . . . . . . .4-44
Windshield Defrosting and Defogging . . . . . . . . . . . .4-50
4
RIO ENG CNA 4.qxd 7/29/05 5:06 PM Page 1

Ignition SwitchIgnition Switch and Anti-Theft Steering
Column LockIgnition Switch Position
LOCK
The steering wheel is locked to protect against theft.
The ignition key can be removed only in the LOCK
position. For vehicles equipped with an automatic
transaxle, it also locks the gear shift lever in the
P (Park) position.
ACC (Accessory)
Turning the ignition switch to this position unlocks the
steering wheel and will allow some of your vehicle’s
electrical accessories such as the radio to operate when
the engine is OFF.
ON
Turning the ignition switch to this position allows you
to test your vehicle’s warning lights (except the brake
system warning light) to make sure they work before
you start the engine. The ignition key returns to the
ON position once the engine is started and remains in
this position while the engine is running.
Do not leave the ignition switch in the ON position for
extended periods with the engine OFF because the bat-
tery will discharge.
Driving Your Vehicle4-2
AS2B04001
✽
NOTICE
This spark ignition system meets all require-
ment of the Canadian interference - Causing
Equipment Regulations.
RIO ENG CNA 4.qxd 7/29/05 5:06 PM Page 2

START
Turn the ignition key to the START position to start the
engine. The engine will crank until you release the key,
then it returns to the ON position. Also, the brake
warning indicator illuminates to check the bulb in this
position.
Difficulty in turning the ignition key to the START posi-
tion can be caused by pressure on the switch from the
steering column. To allow the ignition key to turn,
move the steering wheel right or left to release the ten-
sion and then turn the key.
Automatic Transaxle
When turning the ignition switch to the LOCK posi-
tion, the shift lever must be in the P (Park) position.
Manual Transaxle
When turning the ignition switch to the LOCK posi-
tion, push the key inward at the ACC position and turn
the key toward the LOCK position.
4-3
WARNING
• Never turn the ignition switch to LOCK or
ACC while the vehicle is moving. This could
result in loss of directional control and
braking function, which could cause an
immediate accident.
 Never reach for the ignition switch, or any
other controls, through the steering wheel
while the vehicle is in motion. Failure to
observe this warning can result in loss of
vehicle steering and braking control, which
may result in an accident.
✽
NOTICE
For safety, the engine will not start if the
clutch pedal is not depressed fully on manual
transaxle equipped models.
RIO ENG CNA 4.qxd 7/29/05 5:06 PM Page 3

Starting the Engine1. Make sure the parking brake is applied.
2.Manual Transaxle- Depress the clutch pedal fully
and shift the transaxle into NEUTRAL. Keep the
clutch pedal depressed while cranking the engine.
The starter will not operate if the clutch pedal is not
fully depressed.
Automatic Transaxle- Place the transaxle shift
lever in P (Park). Depress the brake pedal fully.
You can also start the engine if the shift lever is in
the N (Neutral) position.
3. Turn the ignition switch to START and hold it there
until the engine starts (a maximum of 10 seconds),
then release the key.
In extremely cold weather, below minus 18°C (0°F), or
after the vehicle has not been operated for several
days, let it warm up without depressing the accelerator.
Whether the engine is cold or warm, it should be start-
ed without depressing the accelerator.If the engine fails to start using this procedure, attempt
the following.
The engine fails to start when the engine is cold
(engine coolant temperature is below 32°F/0°C):
A no start condition may be caused by an engine that
has become flooded (has excessive fuel in the cylin-
ders). If this is the case, follow the starting procedure
below.
1. Make sure the parking brake is applied.Driving Your Vehicle4-4
✽
NOTICE
If the engine stalls while you are in motion,
do not attempt to move the shift lever to P
(Park).
If it is safe to do so considering traffic and
road conditions, you may put the shift lever
in the N (Neutral) position while still moving
and turn the ignition switch to the START
position in an attempt to restart the engine.
RIO ENG CNA 4.qxd 7/29/05 5:06 PM Page 4