2005 Hyundai Terracan diesel

6 OWNER MAINTENANCE
38
AMPERAGES15A 15A15A-
10A 10A
-
15A 15A15A15A 10A 10A10A 10A 10A 10A15A25A20A
NO. 10 NO. 11NO. 12NO. 13NO. 14NO. 15NO. 16NO. 17NO. 18NO. 19NO. 20NO. 21NO. 22NO. 23
NO. 24
NO. 25
NO. 26
NO. 27
NO. 28
NO. 29
DESCRIPTION
CIRCUIT PROTECTED
Fuel Heater and Sensor(Diesel Engine)
Headlamp(Low beam)Headlamp(High beam) -
A/C Compressor Relay, Triple Switch
TCI Fan Relay(COVEC-F/EGR)--ECM(Diesel Engine)ECM(Diesel Engine)
ECM(Diesel Engine), Air Heater Relay(Diesel Engine), EGR Solenoid(Diesel Engine)
Illuminations, Combination LampLicense Lamp, Combination Lamp
ABS Control Module, ABS Relay, EBD Relay
ECM(Diesel Engine), Headlamp Relay, Condenser Fan Relay
(Petrol/COVEC-F), EGR Solenoid(COVEC-F)ABS Control Module
Cruise Control Module
Front Wiper and Washer
Power Seat Switch
Power Outlet Relay
FUSE

7EMISSION CONTROL SYSTEMS
4
YH040B1-E About the Catalytic Converter ; For a Petrol Engine Exhaust gases passing through the catalytic converter cause it to operate at very high temperatures. As a re- sult, the introduction of large amountsof unburned petrol may cause it to overheat and create a fire hazard. This can be avoided by observing thefollowing: H020D01HP-GAT
; For a Diesel Engine
!WARNING
o Use only unleaded fuel.
o Maintain your engine in good con- dition. Extremely high converter temperatures can result from im-proper operation of the electrical, ignition or M.P.I. system.
o If your engine stalls, pings, knocks, or is hard to start, takeyour car to your Hyundai dealer as soon as possible and have thedifficulty corrected. o Avoid driving with a very low fuel
level. If you run out of petrol, it could cause the engine to misfire and result in excessive loading ofthe catalytic converter.
o Avoid idling the engine for peri- ods longer than 10 minutes.
o Your Hyundai should not be ei- ther pushed or pulled to get itstarted. This can cause the cata- lytic converter to overload.
o Take care not to stop your Hyundai over any combustible material such as grass, paper, leaves orrags.
o Do not touch the catalytic con- verter or any other part of the exhaust system whilst the engine is running.
o Remember that your Hyundai dealer is your best source of as-sistance.
Catalytic Converter H020A01HP-D
!
All Hyundai vehicles are equipped with oxidation type catalytic converter toreduce the carbon monoxide, hydro- carbons and particulate contained in the exhaust gas.
WARNING
o Use diesel only.
o Maintain your engine in good con- dition. Extremely high converter temperatures can result from im- proper operation of the electricalignition or electronic fuel injec- tion system.

7
EMISSION CONTROL SYSTEMS
5
o If your engine stalls, pings, or is
hard to start, take your car to your Hyundai dealer as soon as pos- sible and have the difficulty cor-rected.
o Avoid driving with a very low fuel level. If you run out of diesel, it could cause the engine to stop and result in damage to the cata-lytic converter.
o Avoid idling the engine for peri- ods longer than 10 minutes.
o Your Hyundai should not be ei- ther pushed or pulled to get itstarted. This can cause the cata- lytic converter to overload.
o Take care not to stop your Hyundai over any combustible material such as grass, paper, leaves orrags.
o Do not touch the catalytic con- verter or any other part of theexhaust system whilst the engine is running.
o Remember that your Hyundai dealer is your best source of as- sistance.
EGR SYSTEM
H020C01HP-EAT
; For a Diesel Engine
This system helps control oxides of
nitrogen by recirculating a part of the exhaust gas into the engine, there by reducing cylinder combustion tem-perature. The EGR system helps reduce NOx
(Oxides of Nitrogen) emission gas- ses.

8CONSUMER INFORMATION
2
The vehicle identification number (VIN) is unique to each individual vehicle and is the number (sometimes referredto as chassis number) used upon the vehicle registration document to iden- tify the vehicle.The VIN will be found stamped upona plate attached to the engine bulk-head. The engine number is stamped on theengine block as shown in the drawing.
ZI010C1-E TYRE INFORMATION The tyres supplied on your new Hyundai are chosen to provide thebest performance for normal driving.VEHICLE IDENTIFICATION NUMBER (VIN)
DI070A1-E
I010A01HP-E
ENGINE NUMBER
Petrol engine
I010B01HP
I010B03HP
Diesel Engine
I010B01A-AAT
TYRE
ZI010C1-E
TYRE INFORMATION
The tyres supplied on your new
Hyundai are chosen to provide the best performance for normal driving.

9 VEHICLE SPECIFICATIONS
2
PETROL
MF 68 AH
120 A (13.5 V)
J010A02HP-EAT MEASUREMENT
185 in.
73.2 in.
70.7 in. (72.4 in. )
108.3 in.60.2 in. 60.2 in.
Overall lengthOverall width Overall height Wheel baseWheel tread
Front Rear
J060A01HP-EAT FUEL SYSTEM J030A02HP-EATTYRE
Standard Spare
J050A02HP-AAT BRAKE Dual hydraulic with brake booster Ventilated disc Disc typeCable operated on rear wheel
TypeFront brake type Rear brake type Parking brake
ITEM Battery Alternator
J040A02HP-EAT ELECTRICAL
Fuel tank capacity
DIESEL
MF 100 AH
110 A (12 V)
Tyre Size
255/65 R16
Full Size
16.5 lmp.gal (75 litres)
*1:With Roof Bar
*1
Type
Ball and nut, torsion bar type(Integtal type) 0~1.18 in. (0~30mm) Vane type
J020A01HP-EAT POWER STEERING
Wheel free play Oil pump type
Inflation Pressure
200 kPa(29psi)

9
VEHICLE SPECIFICATIONS
3
Petrol
3.5 V6
6-Cyl., V-type DOHC
3.67 x 3.38 in. (93.0 x 85.8 mm)
3497
10
1 - 2 - 3 - 4 - 5 - 6 Auto lash Auto lash
CHAMPION: RC10PYPB4 NGK: PFR5N-11
0.039 ~ 0.043 in. (1.0 ~ 1.1 mm)
800
BTDC 5° ± 2°
ITEMS
Engine Type Bore x Stroke Displacement (cc)Compression Ratio Firing Order
Valve Clearance Cold(Intake/Exhaust) (mm) Hot Spark Plug Spark Plug Gap Idle Speed (rpm) Ignition TimingENGINE
J070A03HP-EAT
Diesel
2.9 CRDi
4-Cyl., In-line DOHC
3.82 x 3.86 in. (97.1 x 98 mm)
2902
16.5
1 - 3 - 4 - 2
- -
800 ± 100
Automatically Adjusted

9 VEHICLE SPECIFICATIONS
4
Q'ty (lmp.qts)(litre)
Drain and refill (With oil filter) : 3.78 (4.3) Drain and refill (With oil filter) : 5.28 (6.0)
MAX. 1L /1,000 miles (1,500 Km)
MAX. 1L /600 miles (1,000 Km)
Item
Engine Oil Engine oil consumption Oil & Grease Standard
API SG, SH SAE 20W-40, 20W-50 [ABOVE 14°F (-10°C)]
or ABOVE SAE 15W-40, 15W-50 [ABOVE 5°F (-15°C)]
SAE 10W-30 [-13°F ~ 104°F (-25°C ~ 40°C)] SAE 10W-40, 10W-50 [ABOVE -13°F (-25°C)] SAE 5W-20 [BELOW 14°F (-10°C)] *1, *2SAE 5W-30 [BELOW 50°F (10°C)] *1 SAE 5W-40 [BELOW 68°F (20°C)] *1
API CF-4 or ABOVE, SAE #30 [32°F~104°F (0°C~40°C)]
ACEA B4 or ABOVE SAE 20W-40 [ABOVE 14°F (-10°C)] SAE 15W-40 [ABOVE 5°F (-15°C)]SAE 10W-30 [-4°F ~ 104°F(-20°C ~ 40°C)]SAE 5W-30 [BELOW 50°F(10°C)] *1, *2
*1. Restricted by driving condition and dealing area*2. Not recommended for sustained high speed vehicle operationNormal driving condition Severe driving conditionLUBRICATION CHART
J080A08HP-EAT
Petrol Diesel

9
VEHICLE SPECIFICATIONS
5
Q'ty (lmp.qts)(litre)
2.82 (3.2) Petrol : 9.24(10.5), Diesel : 10.38 (11.8) 1.25(1.42)Part-time 4WD : 1.58(1.8) Full-time 4WD : 1.14(1.3) NO.7 : 2.29(2.6) NO.7.5 : 2.46(2.8) Petrol : 9.68 (11), Diesel : 7.92(9) 1.14 (1.3) As required
Oil & Grease Standard
HYUNDAI GENUINE PARTS MTF 75W/90 (API GL-4)MOBILE DEXRON-II ATF DEXRON-IIIHYPOID GEAR OIL API GL-5 or HIGHER, SAE 80W[BELOW -22°F (-30°C)]/90W[ABOVE -22°F (-30°C)] MOBIL INFILREX 33HYPOID GEAR OIL API GL-5 or HIGHER, SAE 80W[BELOW -22°F (-30°C)]/90W[ABOVE-22°F (-30°C)] Ethylene glycol base for aluminiumPSF-3 or ATF Dexron 2 DOT 3 or DOT 4 Equivalent
Item
Transmission FluidTransfer case oil Front axle gear oil Rear axle gear oil Coolant Power steering oil Brakes and clutch fluid
J080A08HP-EAT
Manual
Auto
With LSD Without LSD