2005 HONDA S2000 clutch

Check the brake f luid level in the
reservoirs monthly.
Always use Honda Heavy Duty
Brake Fluid DOT 3. If it is not
available, you should use only DOT 3
or DOT 4 f luid, f rom a sealed
container, as a temporary
replacement.The f luid level should be between
theMINandMAXmarksontheside
of the reservoir. If the level is at or
below the MIN mark, your brake
system needs attention. Have the
brake system inspected f or leaks or
worn brake pads.The f luid level should be between
theMINandMAXmarksontheside
of the reservoir. If it is not, add
brake f luid to bring it up to that level.
Use the same fluid specified for the
brake system.
Replace the brake f luid according to
the time recommendation in the
maintenance schedule.
Brake f luid marked DOT 5 is not
compatible with your vehicle’s
braking system and can cause
extensive damage. Using any non-Honda brake f luid can
cause corrosion and decrease the lif e
of the system. Have the brake
system f lushed and ref illed with
Honda Heavy Duty Brake Fluid
DOT 3 as soon as possible.
A low f luid level can indicate a leak
in the clutch system. Have this
system inspected as soon as possible.
Brake System
Clutch System
Brake and Clutch Fluid
Maint enance
139
MAX
MIN MAX
MIN

Diagnosing why the engine won’t
start f alls into two areas, depending
on what you hear when you press
the ENGINE START button.You hear nothing, or almost
nothing. The engine’s starter
motor does not operate at all, or
operates very slowly.
You can hear the starter motor
operating normally, or the starter
motor sounds like it is spinning
f aster than normal, but the engine
does not start up and run. When you press the ENGINE
START button, you do not hear the
normal noise of the engine trying to
start. You may hear a clicking sound
or series of clicks, or nothing at all.
Check these things:
Check the transmission interlock.
The clutch pedal must be pushed
all the way to the f loor or the
starter will not operate.
Turn the ignition switch to ON (II).
Turn on the headlights, and check
their brightness. If the headlights
areverydimordonotcomeonat
all, the battery is discharged. See on page . Press the ENGINE START button,
then release it. If the headlights do
not dim, check the condition of the
fuses.If thefusesareOK,thereis
probably something wrong with
the electrical circuit f or the
ignition switch or starter motor.
You will need a qualif ied
technician to determine the
problem. (See
on page .)
166 179
Nothing Happens or the Starter
Motor Operates Very Slowly
Jump Starting Emergency
Towing
If theEngineWon’tStart
164

µ
µ
µ
µ
µ
µ
µµ
µ
µ
µ
No. Amps. No. Amps. Circuits Protected
No. Amps. Circuits Protected Circuits Protected
1
2
3
4
5
6
7
8
9
10
11
12
13 40 A
20 A
30 A
20 A
40 A
20 A 14
15
16
17
18
19
20
21
22
23
24
2520 A
15 A
10 A
20 A
15 A
20 A
20 A
30 A
100 A 40 A Magnetic Clutch Relay
Right Headlight
ACG S
Hazard Warning Lights
Cooling Fan
Not used
Stop
Lef t Headlight
ABS F/S
ABS Motor
Battery
IG1 Main
1
2
3
4
5 20 A
70 A
60 A Rear Window Defogger
Not used
Not used
EPS
Air Pump Lighting 1 Relay
Lighting 2 Relay
Horn Relay
Power Window Motor
Right Roof Motor
Not used
Backup ACC
Lef t Roof Motor
Heater Motor
Condenser Fan
Not used
Condenser Fan Relay
Cooling Fan Relay
Fuse Locations
178
(AUXILIARY FUSE BOX)
UNDER-HOOD FUSE BOXES
(PRIMARY FUSE BOX)

Î
................
DANGER, Explanation of . ii
...................................
Dashboard .3, 38
................
Daytime Running Lights . 48
Daytime Running Lights .......................................
Indicator .42
.................................
Dead Battery .166
............
Defects, Reporting Safety . 196
................
Def ogger, Rear Window . 50
................
Defrosting the Windows . 77
..........................
Dif f erential Fluid .138
....................................
Dimensions .184
...............
Dimming the Headlights . 48
Dipstick ..................................
Engine Oil .103
..........................
Directional Signals .48
........
Disc Brake Wear Indicators . 118
.....................
Disposal of Used Oil .134 ...................
Do Not Tow a Trailer . 119
Doors ..............
Locking and Unlocking . 54
.......................
Monitor Indicator .41
......................
Power Door Locks .54
..........
DOT Tire Quality Grading . 186
Downshif ting, Manual .............................
Transmission .115
...........
Driver and Passenger Safety . 5
...........................................
Driving .111
....................................
Economy .104
........................
Driving Guidelines .112
..............................
Economy, Fuel .104
..................................
Emergencies .157
.............
Battery, Jump Starting . 166
...........
Brake System Indicator . 172
................
Changing a Flat Tire . 159
.....
Charging System Indicator . 170
..................
Checking the Fuses . 174
...
Closing the Convertible Top . 173
.........
Hazard Warning Flashers . 49
............................
Jump Starting .166
.....
Low Oil Pressure Indicator . 170
.....................................
Child Saf ety .23
..............................
Booster Seats .32
...................................
Child Seats .28
.....
Important Saf ety Reminders . 26
..........................
Larger Children .31
.......................
Risk with Airbags .24
.............................
Small Children .27
.......................................
Child Seats .28
.......................
Cleaning Seat Belts .145
.................................................
Clock .45
...................................
Clutch Fluid .139
........................
CO in the Exhaust .189
............
Cold Weather, Starting in . 114
......................
Compact Spare Tire .158
...............
Consumer Inf ormation . 194
.............
Controls, Instruments and . 37
..............................
Convertible Top .61
...............
Convertible Top Cover . 63
..
Lowering the Convertible Top . 61
................................
Maintenance .65
.....
Raising the Convertible Top . 64
Coolant ........................................
Adding .134
....................................
Checking .104
.........................
Proper Solution .134
...................
Temperature Gauge . 45Crankcase Emission Control
........................................
System .189
................
Cruise Control Indicator . 41
..............
Cruise Control Operation . 95
......................................
Cup Holder .69
.............
Customer Service Of f ice . 194
Index
D
E
II

CONT INUED
.....................................
Fan, Interior .75
...........................................
Features .73
....................
Filling the Fuel Tank . 101
Filters .........................
Dust and Pollen .146
...............................................
Oil .132
.............
Flashers, Hazard Warning . 49
...................
Flat Tire, Changing a . 159
Fluids ..........................................
Brake .139
.........................................
Clutch .139
..............
Manual Transmission . 137
..................
Windshield Washer . 136
..........
FM Stereo Radio Reception . 81
..........................
Four-way Flashers .49
.................................................
Fuel .100
......................
Fill Door and Cap .101
...........................................
Gauge .45
.....................
Low Fuel Indicator .42
................
Octane Requirement . 100
...............................
Oxygenated .100 ........................
Tank, Ref ueling .101
...............................
Fuel Economy .104
..............
Fuel Station Procedures . 101
.....................
Fuses, Checking the .174
...
Malf unction Indicator Lamp . 171
..................
Overheated Engine . 167
.......................................
Towing .179
...........................
Emergency Brake .67
......................
Emergency Flashers .49
......................
Emergency Towing .179
............
Emergency Trunk Opener . 55
.......................
Emissions Controls .189
.............
Emissions Testing, State . 192
Engine ............
Adding Engine Coolant . 134
....
Coolant Temperature Gauge . 45
.........................
If It Won’t Start .164
Malf unction Indicator ................................
Lamp .41, 171
........
Oil Pressure Indicator . 40,170
..............
Oil, What Kind to Use . 131
...............................
Overheating .167
............................
Specif ications .184
............................
Speed Limiter .116
...............................
Start Button .114
.......................................
Starting .114
......................
Ethanol in Gasoline .100
...
Evaporative Emission Controls . 189
...............................
Exhaust Fumes .35 Expectant Mothers, Use of Seat
........................................
Belts by .14
...............
Gas Mileage, Improving . 104
..........................................
Gasohol .100
.........................................
Gasoline .100
...........................................
Gauge .45
.....................
Low Fuel Indicator .42
................
Octane Requirement . 100
........................
Tank, Ref ueling .101
.............................................
Gauges .44
...
Engine Coolant Temperature . 45
...............................................
Fuel .45
Gearshif t Lever Positions ..............
Manual Transmission . 116
Gross Vehicle Weight Rating .............................
(GVWR) .108, 184
Index
F
G
INDEX
III

.............
Halogen Headlight Bulbs . 140
..............
Hazard Warning Flashers . 49
Headlights ........................................
Aiming .140
............
Daytime Running Lights . 48
..................
High Beam Indicator . 42
...........................
Reminder Tone .48
........
Replacing Halogen Bulbs . 140
...................................
Turning on .48
.........
Heating and Cooling System . 74
............................
High Beam Lever .48
.......................
Hood, Opening the .102
..................................................
Horn .46
...........................
Hydraulic Clutch .139
Identif ication Number, .......................................
Vehicle .182
Ignition ..............................................
Keys .51
...........................................
Switch .53
............
Timing Control System . 190
........................
Immobilizer System .52 .........
Important Safety Precautions . 6
Indicators ..............
ABS (Anti-Lock Brake) . 41
Brake (Parking and Brake ............................
System) .40, 172
................
Charging System . 40,170
.............................
Cruise Control .41
....................................
Door-open .41
DRL(Daytime Running ......................................
Lights) .42
EPS (Electrical Power ..................................
Steering) .41
...................................
High Beam .42
........
Key (Immobilizer System) . 42
......................................
Low Fuel .42
................
Low Oil Pressure . 40,170
...............
Maintenance Required . 43
Malf unction Indicator ................................
Lamp .41, 171
.......................................
Seat Belt .40
...............................................
SRS .41
..................................
Trunk-open .41
Turn Signal and Hazard ...................................
Warning .42
.........
Indicators, Instrument Panel . 40...................
Inf lation, Proper Tire . 149
........
Recommended Pressures . 150
...................................
Inside Mirror .66
.............................
Inspection, Tire .150
....................
Installing a Child Seat .28
............................
Instrument Panel .39
........
Instrument Panel Brightness . 49
...........................................
Interiors .40
........................................
Introduction . i
.......................
Label, Certif ication .182
.................
Lane Change, Signaling . 48
..................
Lap/Shoulder Belts . 12,16
..................................................
Keys .51
................
Jacking Up the Vehicle . 160
.......................................
Jack, Tire .159
................................
Jump Starting .166
Index
I J
K
L
H
IV