2005 HONDA PILOT trailer

µµ
Follow the
Maintenance Schedule f or Severe
Conditions if you drive your vehicle
MAINLY under one or more of the
f ollowing conditions.
Driving less than 5 miles (8 km)
per trip or, in f reezing
temperatures, driving less than 10
miles (16 km) per trip.
Driving in extremely hot [over
90°F (32°C)] conditions.
Used primarily as a delivery
vehicle or taxi that is driven
mostly in stop-and-go traf f ic and/
or parked with the engine idling.
Service your vehicle according to the
time and mileage periods on one of
the Maintenance Schedules on the
f ollowing pages.
Always use unleaded gasoline with
theproperoctanerating(seepage ).
Drive your vehicle regularly over a
distance of several miles
(kilometers). Operate your vehicle on
reasonable roads within the legal
speed limit. Avoid exceeding your vehicle’s
load limit. This puts excess stress
on the engine, brakes, and many
other vehicle parts. The load limit
is shown on the tire inf ormation
label on the driver’s doorjamb.
The maintenance schedule assumes
you will use your vehicle as normal
transportation for passengers and
their possessions. You should also
f ollow these recommendation:
Trailer towing, driving with a roof
top carrier, or driving in
mountainous conditions.
Driving on muddy, dusty, or de-
iced roads.
If you only
drive under a ‘‘severe’’ condition, you
should f ollow the Normal Conditions
Maintenance Schedule.
Follow the
Maintenance Schedule f or Severe
Conditions.
146
OCCASIONALLY
Maintenance Schedule
Which Schedule to Follow
U.S. Owners
Maintenance Schedule
Canadian Owners
Maint enance
189
NOTE:

Î
Î
Î
Ì
194
At every 7,500 miles (12,000 km) up to 15,000 miles (24,000 km) or every 6 months, then every 15,000 miles (24,000
km) or 1 year.
Follow this schedule for rear differential fluid replacement if you use your vehicle for off-highway driving, trailer
towing, mainly in stop-and-go driving. Otherwise, use the fluid replacement schedule in the Maintenance Schedule
for Normal Conditions.
See timing belt on page for replacement information under special driving conditions.
See information on maintenance and emissions warranty, page .
1:
2:
3:
:
190
205
Maintenance Schedule for Severe Conditions

µµ
To thoroughly f lush the
transmission, the technician
should drain and ref ill it with
Honda ATF-Z1 (Automatic
Transmission Fluid), then drive
the vehicle f or a short distance.
Do this three times. Then drain
and ref ill the transmission a f inal
time.
Insert the dipstick all the way back
into the transmission.
The transmission should be drained
and ref illed with new f luid according
to the time and distance recommen-
dations in the maintenance schedule.
If you are not sure how to add f luid,
contact your dealer. Put a new washer on the f iller bolt,
then reinstall the f iller bolt and
tighten it securely. Tightening
torque:
The dif f erential should be drained
and ref illed with new f luid according
to the time and distance recommen-
dations in the maintenance schedule.
The timing belt should be replaced
at the intervals shown in the
maintenance schedule. Replace the
belt at 60,000 miles (100,000 km) if
you regularly drive your vehicle in
one or more of these conditions:
In very high temperatures
(over 110°F, 43°C).
In very low temperatures
(under 20°F, 29°C).
Frequently tow a trailer.
Check the f luid level with the
dif f erential at normal operating
temperature and the vehicle sitting
on level ground. Remove the
dif f erential f luid f iller bolt and
washer, and caref ully f eel inside the
bolt hole with your f inger. The f luid
level should be up to the edge of the
bolt hole. If it is not, slowly add
VTM-4 Dif f erential Fluid until it
starts to run out of the hole.
6.
Timing Belt
Dif f erential Oil
A utomatic T ransmission Fluid, Dif f erential Oil, T iming Belt
Maint enance
205
FILLER BOLT
CORRECT LEVEL
33 lbf·ft (45 N·m , 4.6 kgf·m)

Use the compact spare tire as a
temporary replacement only. Get
your regular tire repaired or replaced,
and put it back on your vehicle as
soon as you can.
Check the inf lation pressure of the
compact spare tire every time you
check the other tires. It should be
inf lated to:Replace the tire when you can see
the tread wear indicator bars. The
replacement should be the same size
and design tire, mounted on the
same wheel. The spare tire is not
designed to be mounted on a regular
wheel, and the spare wheel is not
designed f or mounting a regular tire.
Follow these precautions:
Never exceed 50mph ( 80km/h).
This tire gives a harsher ride and
less traction on some road sur-
f aces. Use greater caution while
driving.
Do not mount snow chains on it.
Do not use the compact spare tire
if you are towing a trailer.
Do not use your compact spare
tire on another vehicle unless it is
thesamemakeandmodel.
Turn of f the VSA system (see
page ). Driving with the
compact spare tire may activate
the VSA system. 172
On EX-L models
Compact Spare Tire
224
INDICATOR LOCATION MARK
TREAD WEAR INDICATOR BAR
60 psi (420 kPa , 4.2 kgf/cm)

If your vehicle needs to be towed,
call a prof essional towing service or
organization. Never tow your vehicle
with just a rope or chain. It is very
dangerous.The operator will load
your vehicle on the back of a truck.
Any other method of towing will
damage the drive system. When you
contact the towing agency, inf orm
them a f lat-bed is required. Refer to
on page
for non-emergency towing
inf ormation. 182
Emergency T owing
Emergency T owing
The only way you can saf ely tow
your vehicle is with f lat-bed
equipment. Towing Your Vehicle
Behind a Motorhome
T aking Care of t he Unexpect ed
237
Towing with only two tires on the
ground will damage parts of the 4WD
system. It should be transported on a
f lat-bed truck or trailer.

If you cannot drive the vehicle
without f ixing the problem, and you
do not have a spare fuse, take a fuse
of the same rating or a lower rating
f rom one of the other circuits. Make
sureyoucandowithoutthatcircuit
temporarily (such as the accessory
power socket or radio).
If you replace the blown f use with a
spare f use that has a lower rating, it
might blow out again. This does not
indicate anything wrong. Replace the
f use with one of the correct rating as
soon as you can.If the replacement fuse of the
same rating blows in a short time,
there is probably a serious
electrical problem with your
vehicle. Leave the blown fuse in
that circuit, and have your vehicle
checked by a qualif ied mechanic.
If a trailer light is burned out, check
if these f uses are blown when you
replace the light bulbs:
If thosefusesareOK,butthetrailer
lights still do not work, there are two
blown 7.5 amp f uses in the trailer
hitch wiring. To access the 7.5 amp
f uses:
Open the tailgate and remove the
cargo f loor lid.
Pull out the bottom of the tailgate
rubber seal.
Remove rear trim panel by pulling
up on the inside edge of the rear
trim panel, and unhooking the f our
clips and tabs.
Af ter replacing f uses, and reinstall
the rear trim panel in the reverse
order of removal. Primary under-hood f use box
fuses5,7,and24
Interior driver’s side f use box: 10
Interior passenger’s side f use box:
10
If the radio f use is removed, the
audio system will disable itself . The
nexttimeyouturnontheradioyou
will see ‘‘COdE’’ in the f requency
display. Use the preset buttons to
enter the f ive-digit code (see page ).
6.
1.
2.
3.
4.
123
On EX and EX-L model
Trailer Fuses
Fuses
240
Replacing a f use with one that has a
higher rating greatly increases the
chances of damaging the electrical
system. If you do not have a
replacement f use with the proper rating
f or the circuit, install one with a lower
rating.

µµ
No. Amps. Circuits Protected No. Circuits Protected
No. Amps. Circuits Protected No. Amps. Circuits Protected Amps.
1
2
3
4
5
6
7
8
9
10
11
12
13 20 A
30 A
20 A
15 A
15 A
20 A
20 A
20 A
40 A
40 A
30 A
40 A Spare Fuse
Spare Fuse
Right Headlight
ACG S
Hazard
Not used
Stop
Lef t Headlight
Radio
Power Window Motor
Power Seat
Rear Defroster
Back Up, ACC 14
15
16
17
18
19
20
21
22
23
24
Rear A/C
Heater Motor
Cooling Fan
Spare Fuse
Spare Fuse
Spare Fuse
Battery
Condenser Fan
MG Clutch
IGI Main
Trailer (accessory)
1
2
3
4
5
6 40 A
20 A
30 A
40 A
20 A
20 A ABS F/S Relay
VSA F/S Relay
VSA Motor
ABS Motor
4WD
Rear Accessory Socket 7
8
9
10
11 15 A
15 A
15 A
7.5 A
(15 A) ET CS
IG Coil
LAF
TPMS
(FR FOG)
30 A
40 A
30 A
7.5 A 10 A
15 A
120 A 30 A
7.5 A 50 A
Fuse Locations
T aking Care of t he Unexpect ed
241
PRIMARY UNDER-HOOD FUSE BOX
SECONDARY UNDER-HOOD FUSE BOX

CONT INUED
How Your Front Airbags.........................................
Work .25
...
How Your Side Airbags Work . 28
........................
SRS Components .23
.............................
SRS Indicator .30 ,58
....
START (Ignition Key Position) . 77
.......................
Starting the Engine .159
In Cold Weather at High ..................................
Altitude .159
................
With a Dead Battery . 230
..............
State Emissions Testing . 254
........
Steam Coming f rom Engine . 230
Steering Wheel ..................................
Adjustment .74
.............
Anti-theft Column Lock . 77
...............................
Buttons .122, 138
...................
Stereo Sound System . 106
....................
Storing Your Vehicle .222
..........................
Sunglasses Holder .96
..........................................
Sun Visor .96
Supplemental Restraint System ......................................
Servicing .32
.........................
SRS Indicator .30 ,58
...................
System Components . 23
..................................
Synthetic Oil .200 ......
Taillights, Changing Bulbs in . 210
.
Taking Care of the Unexpected . 223
....................................
Tape Player .119
Technical Descriptions ......
DOT Tire Quality Grading . 248
.....
Emissions Control Systems . 251
..........
State Emissions Testing . 254
Three Way Catalytic ...............................
Converter .253
.......................
Temperature Gauge .67
........
Temperature, Inside Sensor . 105
....................
Temperature, Outside . 67
...................
Tensioners, Seat Belts . 21
........
Testing of Readiness Codes . 254
..............
Tether Anchorage Points . 47
............................
Thef t Protection .123
..
Three Way Catalytic Converter . 253
..........................
Time, Setting the .124
..................
Tilt the Steering Wheel . 74
....................................
Timing Belt .205
....................................
Tire Chains .220
.........
Tire, How to Change a Flat . 225
Tire Pressure Monitoring ........................
System (TPMS) .165 ...............................................
Tires .216
..............................
Air Pressure .216
.........................
Checking Wear .217
..........................
Compact Spare .224
......
DOT Tire Quality Grading . 248
......................................
Inf lation .216
..................................
Inspection .217
..............................
Maintenance .218
...................................
Replacing .219
......................................
Rotating .218
...........................................
Snow .219
............................
Specif ications .247
...................
Tools, Tire Changing . 225
Towing .....................................
A Trailer .173
................
Emergency Wrecker . 237
....
Equipment and Accessories . 179
.......................
Traction Devices .220
Your Vehicle Behind a ............................
Motorhome .182
.............................
Weight Limit .175
......................
Trailer Driving Tips .180
Index
INDEX
T
VII