2004 YAMAHA TT600RE engine

CHARGING SYSTEM
7-38
ELEC
3. Charging voltage
•Connect the inductive rev counter to the
spark plug cable.
•Connect the pocket tester (DC 20V) to the
battery, as shown.
Tester terminal (+) ➔ Battery terminal (+)
Tester terminal (-) ➔Battery terminal (-)
•Start the engine and rev to about 5,000 rpm.
•Check the charging voltage.
Charging voltage:
14.0V at 5,000 rpm
4. Stator coil resistance.
•Disconnect the AC generator connector
from the harness.
•Connect the pocket tester ( Ωx 1) to the sta-
tor coils.
Stator coils (1)
Tester terminal (+) ➔White cable (1)
Tester terminal (-) ➔White cable (2))
*
NOTE:
Use a fully charged battery.
OUT OF SPECIFICATIONS
IN COMPLIANCE WITH
SPECIFICATIONS
Replace the battery.
ProCarManuals.com

LIGHT SYSTEM
7-46
ELEC
LIGHT SYSTEM INSPECTION NOTE:
To proceed to the control of the light system, start the engine and then stop it by the emergency engine
stop switch. In this way the light relay remains excited and it is possible to check the light system.
1. The front headlight and the high beam light fail to turn on.
CONTINUITY
DISCONTINUITY
Replace the bulb and/or the bulbholder.1. Bulb and bulbholder.
•Check the continuity of the bulb and bulb-
holder.
Refer to “BULB INSPECTION” section.
2. Voltage.
•Connect the pocket tester (DC 20V) to the
front headlight connectors and the high
beam switch.
Headlight: Tester terminal (+) ➔
Green (2) or Yellow (1) cable
Tester terminal (–) ➔Black cable (3)
High beam light: Tester terminal (+) ➔Yellow cable (4)
Tester terminal (–) ➔Black cable (5)
[A] When the lights switch (commutator) is at
position “HI”.
[B] When the lights switch (commutator) is at position “LO”.
OUT OF SPECIFICATION
The circuit from the main switch to the bulbhol-
der connector is defective. Repair.
A
B
ProCarManuals.com

TRBL
SHTG
?
CHAPTER 8°
TROUBLESHOOTING
FAILURE TO START/DIFFICULTIES IN STARTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-1
FUEL SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-1
ELECTRICAL SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-2
POOR ENGINE COMPRESSION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-2
POOR PERFORMANCE AT IDLE SPEED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-3
UNSATISFACTORY PERFORMANCE AT MEDIUM-HIGH SPEED . . . . . . . . . . . . . . . . . 8-3
DIFFICULTIES IN SHIFTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-4
SHIFTING IMPOSSIBLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-4
THE SHIFT PEDAL FAILS TO MOVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-4
DISENGAGING GEARS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-4
CLUTCH SLIDES OR FAILS TO RELEASE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-5
CLUTCH SLIDES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-5
CLUTCH FAILS TO RELEASE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-5
DEFECTIVE BRAKES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-6
POOR BRAKING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-6
OIL LEAKS OR MALFUNCTIONING OF FRONT FORK . . . . . . . . . . . . . . . . . . . . . . . . . 8-6
OIL LEAKS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-6
MALFUNCTIONING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-6
UNSTABLE STEERING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-7
DEFECTIVE FUNCTIONING OF LIGHTS AND INDICATORS . . . . . . . . . . . . . . . . . . . . . 8-8
POOR HEADLIGHT ILLUMINATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-8
FREQUENT BURNING OF BULB . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-8
DIRECTION INDICATORS FAIL TO TURN ON . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-8
DIRECTION INDICATORS FAIL TO TURN OFF . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-8
DELAYED TURNING ON OF INDICATORS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-9
EXCESSIVE INDICATOR INTERMITTENCE FREQUENCY . . . . . . . . . . . . . . . . . . . 8-9
THE HORN FAILS TO WORK . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-9
OVERHEATING OF ENGINE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-9
ProCarManuals.com

FAILURE TO START/
DIFFICULTIES IN STARTING
8-2
TRBL
SHTG
?
Spark plug
Ignition coil
Ignition unit
Switches and cables PROBABLE CAUSES•Electrodes gap not correct
•Electrodes worn
•Feed cable interrupted
•Wrong thermal grading of spark plug
•Defective spark plug cap
•Primary or secondary winding interrupted
•High voltage cable defective
•Defective coil
•Defective unit
•Defective pick-up coil
•Woodruff key broken
Starter motor
•Starter motor defective
•Starter motor relay defective
•Diodes defectives
•Starter one-way bearing defective
•Main switch defective
•Emergency stop engine switch defective
•Harness with cable interrupted
•Neutral switch defective
•Sidestand switch defective
•Clutch switch defective
•Starter switch defective
ELECTRICAL SYSTEM
Cylinder and cylinder head
Piston and piston rings
Crankcase and valves, crankshaft PROBABLE CAUSES
•Spark plug tightening insufficiently
•Cylinder head or cylinder insufficiently tightened
•Cylinder head gasket broken
•Cylinder gasket broken
•Cylinder worn, damaged or seized
•Piston rings wrongly assembled
•Piston rings worn, yielded or broken
•Piston rings stuck together
•Piston seized or damaged
•Poor crankcase sealing
•Crankshaft oil seal edge damaged
•Poor valve sealing
•Valve and seat with insufficient contact
•Valve timing wrongly
•Valve spring broken
•Crankshaft seized
•Camshaft seized
POOR ENGINE COMPRESSION
ProCarManuals.com

DIFFICULTIES IN SHIFTING
8-4
TRBL
SHTG
?
Clutch
Engine oil PROBABLE CAUSES•Clutch cable wrongly set
•Wrong position of push lever
•Irregular engagement of push lever and push
rod
•Pressure plate deformed
•Clutch springs not preloaded uniformly
•Reference marks not aligned
•Push rod broken
•Clutch gear assy nut loose or push rod deformed
•Primary driven gear bearing defective
•Driven plates deformed
•Driving plates deformed
•Clutch cable damaged
•Oil level over maximum
•Incorrect gradation (high viscosity)
•Degradation
SHIFTING IMPOSSIBLE
DIFFICULTIES IN SHIFTING
Shift shaft
Shift cam, shift fork PROBABLE CAUSES•Shift shaft deformed
•Groove with impurities or foreign bodies
•Shift fork stuck
•Shift fork guide bar deformed
THE SHIFT PEDAL FAILS TO MOVE
Transmission•Transmission gears struck
•Gears stuck by impurities or foreign bodies
•Wrong transmission assembly
Shift shaft
Shift fork PROBABLE CAUSES•Shift lever set wrongly
•Shift cam
stop lever fails to return freely
•Shift forks worn
Transmission
•Gear clutches worn
DISENGAGING GEARS
Shift cam
•Shaft cam with thrust free play
•Shift cam groove worn
ProCarManuals.com

CLUTCH SLIDES OR FAILS TO RELEASE
8-5
TRBL
SHTG
?
Clutch
Engine oil PROBABLE CAUSES•Clutch cable wrongly set
•Clutch springs loose
•Clutch spring yielded
•Friction plates worn
•Clutch plates worn
•Clutch improperly assembled
•Oil level below minimum
•Incorrect gradation (low viscosity)
•Degradation
CLUTCH SLIDES
CLUTCH SLIDES OR FAILS TO RELEASE
Refer to “SHIFTING IMPOSSIBLE” section.
CLUTCH FAILS TO RELEASE
ProCarManuals.com

DEFECTIVE FUNCTIONING OF LIGHTS AND INDICATORS/ OVERHEATING OF ENGINE
8-9
TRBL
SHTG
?
PROBABLE CAUSES
•Indicator lamp relay defective
•Insufficient battery capacity
(battery almost flat)
•Incorrect bulb
•Main switch or direction indicator switch defec-
tive
DELAYED TURNING ON OF INDICATORS
PROBABLE CAUSES
•Battery flat
•Main switch or horn switch defective
•Horn wrongly set
•Defective horn
•Harness cut off
THE HORN FAILS TO WORK
OVERHEATING OF ENGINE
PROBABLE CAUSES
•Incorrect bulb
•Indicator lamp relay defective
EXCESSIVE INDICATOR
INTERMITTENCE FREQUENCY
Ignition system
Fuel feed system PROBABLE CAUSES
•Incorrect electrode gap of spark plug
•Spark plug thermal gradation wrong
•Ignition unit defective
•Incorrect carburetor main jet (incorrect setting)
•Incorrect fuel level
•Air filter element obstructed
Engine compression
•Excess of carbon deposits
Engine oil
•Incorrect oil level
•Incorrect oil viscosity
•Incorrect oil gradation
Brake
•Pads fail to return freely (remains blocked)
ProCarManuals.com

TT600RE WIRING DIAGRAM
467C4B5CAMP403D494A4856 172320-2
GWLY
BB
B
BBLWRB
R
B
B
B
RLBOrRBLYGW
Or
B
LW
MAIN HARNESSB
B
B
Y Y
LBG
LGRBLYGWLWLBOrRB
LW
GY
GY
RBBr
Br
187
GB
12V10W
BL12V5WB
Y G
12V60/55WBGYA
A
12V10W
A
GB
BrBBrB
B
GBB
GBB
GBB
BrB
12V10WB
B
BrL
GB
12V10WB
B
187
BY
B
R
B
BrL
WWB
OFF
BrL
W
B
W
BB
B
B
BLB
BBrB
G
B
BrB
Br
OFF
B
EXT. CORD
Br
GY
BL
G Y
GYB
B
L
GB
BrB
LR
LR SbB
RW
-
LR
L
BrL
GBSbB
BrB
YBrBrB
YBrGB
B
Ch
DgBrY
BrB
HIGH
TURN
NEU.ILL.
B
BrL
BrL
LB
BY
LY
LB
LYGW
B
RBOr
205
B
RBLBrL
Br
PARKOFFON
ON
ON
Sb
L
GB
GY G
Y
RBLYBY
LYBY
RUN
LW
B
B
LY
BY
LBrRR
LWRB
GB
R
B
GW
BrBrW
WB
Br
LY
WB
Sb
B
GWLY
(BLUE)B
B
LYB
OFF
BrRB
LWRB
Y
P
G
GB BBrWBrL
BrB
W
WW
GYBr
GY
Y
P
G
GB BBrWBrL
BrB
Y
N
RL
LOWHIGH
BrW BrWBr
PPBr
LY
B
GWLY
Or
RBBr
LW
BY
BY
START
OFF
R
B
GWLY
W
W
W
W
W
W
WRW
W
W
Sb
B
Sb
B
BrBB
-
-
B
LR
WRW
B
-
A
L
L
GY
LB
Br
WB
RB
MAIN HARNESS
AHEAD LIGHT
B
B
BrB

17
16
11
12
13
14
15
91029
8
5
3
12
64
28
20
21
22
19
2325
24
30
31
27
267
32
18
ELECTRICAL SYSTEM
DIAGRAM1 AC generator/Pickup coil
2 Rectifier/Regulator
3 Battery
4 Starter relay
5 Starting motor
6 Fuse
7 Main switch
8 Right handlebar switch
9 Engine stop switch
0 Starter switch
q Diode
w Clutch switch
e Sidestand switch
r Neutral switch
t Diode
y Ignitor unit
u Ignition coil
i Left handlebar switch
o Horn switch
p Diode
a Pass switch
s Dimmer switch
d Flasher switch
f Horn
g Flasher relay
h Headlight
j Flasher light
k Relay assy
l Front brake switch
; Rear brake switch
z Tail/stop light
x Meter
COLOR CODE
B ...........Black
Br ..........Brown
Ch .........Chocolate
Dg .........Dark green
G...........Green Gy .........Gray
L............Blue
Lg..........Light green
O...........Orange
P ...........Pink R...........Red
Sb .........Sky blue
W..........White
Y ...........Yellow
B/L ........Black/Blue B/W.......Black/White
B/Y........Black/Yellow
Br/B.......Brown/Black
Br/L .......Brown/Blue
Br/W......Brown/White Br/Y.......Brown/Yellow
L/B ........Blue/Black
L/R ........Blue/Red
L/W .......Blue/White
L/Y ........Blue/Yellow R/B........Red/Black
R/G .......Red/Green
R/W.......Red/White
R/Y........Red/Yellow
ProCarManuals.com