2004 SAAB 9-3 torque

246 Car careWhen the car has to be lifted, the jack must
be positioned at one of the four jacking
points (front or rear) under the sill members.
If a floor jack is used, the lifting plate must
be positioned under the normal jacking
points, see illustration. If the car is equipped
with a towbar, the jack can also be placed
under this.
1 Wind the jack up to a suitable height
before placing it under the jacking point.
Each jacking point is indicated by an
arrow on the sill (see illustration).
Make sure that the jack fully engages
the jacking point in the underside of the
sill member and that the entire foot of the
jack is steady and flat on the ground.
The jack must not stand on snow, ice or
similar.
Wind up the jack until it just begins to lift
the car.2 It is not necessary to remove the wheel
cover.
If, none the less, you wish to remove the
wheel cover, take hold of the outer edge
and pull it straight out.
Loosen the wheel bolts half a turn.
3 Wind the jack to raise the wheel clear of
the ground. Remove the wheel bolts and
lift off the wheel.4 Clean any rust or dirt from the contact
surfaces between the wheel and brake
disc. Do not wipe away the grease in the
wheel hub.
5 Add a thin layer of grease on the bolts
before fitting, see page 248. Fit the
wheel and screw in the bolts in the
sequence shown on page 248 (opposite
pairs).
Tighten the bolts enough for the bolts
and wheel to be seated correctly.
6 Lower the car and tighten the wheel
bolts to torque in sequence as shown on
the following page.
Tightening torque:
Light-alloy wheels: 80 ft.lb. (110 Nm).
Steel wheels: 80 ft.lb. (110 Nm).NOTICEApply the jack only to the jacking points
indicated on the body.
Jacking points
Marking of jacking points
ProCarManuals.com

247 Car care
7 Retighten the wheel bolts after twenty or
so miles.
Tightening torque:
Light-alloy wheels: 80 ft.lb. (110 Nm).
Steel wheels: 80 ft.lb. (110 Nm).
We advise against using wheels with large
ventilation slots in winter, as the brake com-
ponents are then more exposed to slush,
road salt and grit.
If you fit wheels of a different dimension, the
speedometer can be reprogrammed to
ensure it is as accurate as possible. Contact
a Saab dealer.Driving with tire chains, see
page 176 NOTICE
 Do not overtighten the bolts using a
impact wrench: not only can this
damage the wheels but it can also
make it impossible to undo the bolts
using the wheel wrench in the car’s
toolkit.
 When refitting a wheel cover, make
sure that the valve protrudes through
the marked recess in the wheel cover.
Do not wipe away the grease in the wheel
hub.
Clean any rust or dirt from the contact sur-
faces between the wheel and brake disc.
Jacking points for floor jack
ProCarManuals.com

271 Technical data
Fuel
Engines
Recommended oil viscosities.
Viscosity is a measurement of the oils thickness. The thickness
influences, among other things, the fuel economy. For best
function Saab recommends:
For gasoline engines, SAE 0W-30 engine oil.
Some oil companies have engine oils meeting our requirements
(GM-LL-A-025) but with other viscosities than what we recom-
mend as a first choice. Those engine oils are also accepted.
Extra engine oil additives.
Don't add anything to your oil. The recommended oils are all
you will need for good engine performance and protection.
When to change engine oil.
Your vehicle has a display (SID) where time for service will be
shown. Based not only on mileage but also on driving condi-
tions the mileage at which a service will be indicated can vary
considerably.
Under normal circumstances the service indication will come on
at or around 15 000 miles or 2 years.
For this service system to work it is of outmost importance that
the right engine oil is used.
When the message for service is displayed you need to have
the required service done as soon as possible.
After the service your service personnel will reset the service in-
dicator. It is important to reset the service indicator in order to
optimize the time to the next service.
Oil capacity, including filter (oil change) __ 6.3 qts. (6.0 l)Fuel tank capacity ___________________ 16.05 U.S. gal. (61 l)
For optimum performance
Saab recommends:
2.0t (175 hp) ______________________ Unleaded 90 AON
2.0 Turbo (210 hp) _________________ Unleaded 90 AON
2.0t EcopowerRating, EEC at 5500 rpm ____________ 175 hp (129 kW)
Maximum torque, EEC at 2500 rpm ____ 195 ft.lb. (265 Nm)
Compression ratio _________________ 9.5:12.0 Turbo EcopowerRating, EEC at 5300 rpm ____________ 210 hp (155 kW)
Maximum torque, EEC at 2500 rpm ____ 221 ft.lb. (300 Nm)
Compression ratio _________________ 9.5:1
ProCarManuals.com

273 Technical data
Automatic transmission Suspension
SteeringType _____________________________ Electronically con-
trolled, 5-speed,
fully-automatic with
hydraulic torque
converter, planetary
gears and integral
final drive.
Lock-up function in
selector positions 3,
4 and 5.
Selector lever positions _______________ P, R, N, D, M
Oil capacity, total ____________________ 7.6 qts. (7.2 litres)
Oil type ___________________________ Saab 3309
Clutch type ________________________ Hydraulic plate
clutches, brake
bands and one-way
couplings
Speed (mph/km/h) at 1000 rpm in top gear:
2.0t and 2.0T _____________________ 28–30/46–49Spring type, front and rear ____________ Coil springs
Maximum deflection of springs:
Front ____________________________ 7.0'' (178 mm)
Rear ____________________________ 8.3'' (212 mm)
Dampers, front and rear ______________ Gas-filled dampers
Steering __________________________ Power-assisted
steering gear of
rack-pinion type and
telescopic jointed
steering column
Number of turns, lock to lock___________ 3.0
Oil type ___________________________ Power steering fluid
CHF 11S
ProCarManuals.com

286 IndexPinch protection, sunroof
_________ 122
Plates and labels, location ________ 278
Polishing and waxing
____________ 251
Poly-V-belt
____________________ 205
Position lights ___________________ 91
Power steering fluid, checking
_____ 201
Power steering fluid, grade
________ 273
Pressure gauge
_________________ 80
Pressure, tires
__________________ 231
Profiles, customized settings
_______ 83
QQuality grading, tires
_____________ 235
Quick guide, remote control
________ 41
RRain sensor
_____________________ 96
Raising the soft top manually,
Convertible ____________________ 60
Reading lights, Convertible
_________ 70
Rear fog light
___________________ 93
Rear seats, folding down
_________ 134
Rear towing eye
________________ 185
Rear window heating
____________ 102
Rearview mirrors
________________ 128
Recirculation
___________________ 101
Recommendations for automatic
transmission, towing a trailer
_____ 179Recommendations for manual
gearbox, towing a trailer
_________ 180
Recommended fuel grades ________ 147
Recommended snow chains _______ 275
Refueling
______________________ 147
Remote control
__________________ 40
Remote locking malfunction
________ 42
Replacement, wheel
_____________ 236
Reporting safety defects __________ 265
Rev counter
_____________________ 78
Reversing lights
_________________ 94
Roll bars, Convertible
_____________ 68
Roll-over protection, Convertible
_____ 68
Roof lighting
___________________ 123
Roof lighting, changing
___________ 217
Running-in
_____________________ 151
SSAHR, head restraint
_____________ 20
SDM
_________________________ 266
SID
___________________________ 83
SPA __________________________ 170
Saab Information Display
__________ 83
Saab Parking Assistance _________ 170
Saab Trionic engine management
system
______________________ 194
Safety belts _____________________ 11
Seatbelts
_______________________ 11
Seatbelts in rear seat, Convertible
___ 67
Seatbelts, care
_________________ 248Seatbelts, checking
______________ 248
Seats
__________________________ 16
Securing a load
_________________ 137
Sentronic, manual gear selection
___ 158
Service costs
___________________ 263
Service information
______________ 264
Service intervals
________________ 262
Service record retention
__________ 263
Signalling, horn
_________________ 116
Ski hatch
______________________ 136
Spare wheel ___________________ 243
Speed ratings, tires
______________ 239
Speedometer
____________________ 79
Starting the engine
______________ 142
Steering wheel adjustment
________ 116
Steering wheel lock
______________ 142
Steps for determining correct load
limit
_________________________ 242
Storage compartments
___________ 126
Sun visor
______________________ 124
Sunroof
_______________________ 120
Switches _______________________ 91
TTCS
__________________________ 163
Technical data
__________________ 268
Textile carpeting, cleaning
_________ 249
Tie down eyes
__________________ 137
Tightening torque, wheels
_________ 247
Tire chains
_____________________ 237
ProCarManuals.com