2004 Peugeot Partner VU Dag brake

PRACTICAL INFORMATION91
22-12-2003
Refitting the wheel
Ð After positioning the wheel, lightly pre-tighten the bolts using the wheelbrace.
Ð Compress the jack and release it.
Ð Fully tighten the bolts using the wheelbrace.
Ð Replace the trim, starting at the valve passage hole, and press it on using the
palm of the hand.
Replacing the wheel in the carrier
Ð Replace the chock 2 in the wheel.
Ð Replace the wheel in the carrier.
Ð Lift the wheel then the carrier and reposition the hook.
Ð Do not forget to fully tighten the spare wheel carrier retaining bolt.
Ð Stow the wheelbrace 1 and the jack.
For your safety, always change a wheel:
Ð on level, stable and non slippery ground,
Ð with the handbrake applied,
Ð with first or reverse gear engaged,
Ð with the vehicle chocked,
Ð never go underneath a vehicle raised using a jack (use an axle stand).
After changing the wheel
Ð Have the tightening of the bolts and the pressure of the spare tyre checked as soon as possible
by a PEUGEOT dealer.
Ð Have the punctured tyre repaired and replace it on thevehicle as soon as possible.

Rear lights
1 - Fog lamp (P 21 W).
2 - Direction indicators (P 21 W).
3 - Reversing lights (P 21 W).
4 - Brake lights/Side lights (P 21/5 W).Ð Open the rear door.
Ð Unscrew the nut
A.
Ð Push the light unit gently towards the interior of the vehicle to unclip the two side retaining clips.
Ð Remove the light unit and disconnect it.
Ð Unclip the bulb holder by pressing the tabs B.
Ð Change the faulty bulb.
PRACTICAL INFORMATION
94
22-12-2003
Number plate lights (W 5 W) Unclip the translucent protector to gain access to the bulb.

PRACTICAL INFORMATION95
22-12-2003
Third brake light (tailgate) (W 5 W) 
With the tailgate open, unscrew the two nuts.
 Unclip the support to gain accessto the bulbs.
 Change the faulty bulb. Third brake light (rear left door) (W 5 W) 
Remove the housing cover by pressing the tab A(round
section) at the end of the light.
 Pull the housing cover rearwards. 
Squeeze the two tabs B to
remove the bulb holder.
 Pull the faulty bulb and change it.
To refit, proceed in the reverse order.

PRACTICAL INFORMATION99
22-12-2003
Fuse N¡ Rating
Functions
1 10 A Pre-heat unit (diesel) - Brake and clutch switches - Reversing lights.
2 15 A Fuel pump.
3 10 A ABS control unit.
4 10 A Engine control unit.
5Ð Not used.
6 15 A Front fog lamps.
7 20 A Headlamp wash pump.
8 20 A Fan assembly relay - Engine control unit.
9 15 A Left-hand dipped beam.
10 15 A Right-hand dipped beam.
11 10 A Left-hand main beam.
12 10 A Right-hand main beam.
13 15 A Horns.
14 10 A Front and rear windscreen wash pumps.
15 30 A Oxygen sensor - Air flow sensor.
16 30 A Air pump relay.
17 30 A Front windscreen wiper.
18 40 A Air conditioning fan.

PRACTICAL INFORMATION97
22-12-2003
Fuse N¡ Rating
Functions
1 15 A Rear wiper (hinged doors) - Rear 12 V sockets.
4 20 A Multi-function display - Instrument panel - Audio equipment - Steering wheel controls.
5 15 A Alarm siren.
6 10 A Diagnostic socket.
7 15 A Alarm.
9 30 A Heated seats.
10 40 A Rear screen and mirror demisting.
11 15 A Rear windscreen wiper (tailgate).
12 30 A Front electric windows.
14 10 A Engine fuse box - Steering wheel controls - Rain sensor.
15 15 A Instrument panel - Multi-function display - Audio equipment.
16 30 A Locking/unlocking controls for doors, bonnet and boot.
20 10 A Right-hand brake light.
21 15 A Left-hand brake light.
22 20 A Front courtesy light - Map reading light - Lighter - Front 12 V socket -
Electric mirror.

TECHNICAL DATA
Engine1.1 litre 1.4 litre
Model 600 kg 600 kg 800 kg
Gearbox Manual Manual Manual
Model codes GBHFXB GBKFWB GCKFWB
¥ Kerb weight 1 108 1 108 1 110
¥ Gross vehicle weight (GVW) 1 690 1 690 1 890
¥ Gross train weight (GTW)* 2 440 2 590 2 790 ¥ Unbraked trailer 500 500 500
¥ Braked trailer (within GTW) 750 900 900
¥ Recommended nose weight Ð Ð Ð
WEIGHTS AND TOWING LOADS (IN KG)
* In the case of a towing vehicle, the speed is limited to 60 mph (100 km/h).
Engine 1.9 litre D 2 litre Turbo HDI
Model 600 kg 800 kg 600 kg 800 kg
Gearbox Manual Manual Manual Manual
Model codes GBWJYB/K GCWJYB PLC GBRHYB GCRHYB ¥ Kerb weight 1 163 1 225 1 211 1 211
¥ Gross vehicle weight (GVW) 1 755 1 955 1 790 1 990
¥ Gross train weight (GTW)* 2 855 3 055 2 890 3 090
¥ Unbraked trailer 500 500 500 Ð
¥ Braked trailer (within GTW) 1 100 1 100 1 100 Ð
¥ Recommended nose weight Ð Ð Ð Ð
22-12-2003
108