2004 Peugeot Partner VU Dag engine oil

22-12-2003
PRACTICAL INFORMATION85
1.
Power steering reservoir
2. Windscreen and headlamp* wash reservoir
3. Coolant reservoir 4.
Brake fluid reservoir
5. Battery
6. Air filter 7.
Dipstick
8. Engine oil reservoir
* According to destination.
1.1 LITRE (60 bhp) and 1.4 LITRE (75 bhp) PETROL ENGINES

1.Power steering reservoir
2. Windscreen and headlamp* wash reservoir
3. Coolant reservoir 4.
Brake fluid reservoir
5. Battery
6. Air filter 7.
Dipstick
8. Engine oil reservoir
* According to destination.
1.9 LITRE (70 bhp) DIESEL ENGINE
PRACTICAL INFORMATION
86
22-12-2003

PRACTICAL INFORMATION87
22-12-2003
1.
Power steering reservoir
2. Windscreen and headlamp* wash reservoir
3. Coolant reservoir 4.
Brake fluid reservoir
5. Battery
6. Air filter 7.
Dipstick
8. Engine oil reservoir
* According to destination.
2 LITRE (90 bhp) TURBO DIESEL HDI ENGINE

PRACTICAL INFORMATION
88
22-12-2003
CHECKING THE LEVELS Oil level Check the level regularly and top up
between changes. The maximum consumption is 0.5 l per 1 000 km. Check the level with the vehicle on level ground, engine cold, using the oillevel gauge on the instrument panel orthe dipstick. Dipstick
There are two marks on the dipstick: A=maximum
Never fill past this mark.B= minimum
To maintain the reliability of engines and emissioncontrol systems, the useof additives in engine oilis prohibited. Viscosity selection In all cases, the oil selected must meet the manufacturer's requirements.
Brake fluid level:
Ð The level must always be between the DANGER and MAXI-
MUM marks in the reservoir.
Ð If the level drops substantially, contact a PEUGEOT dealer
immediately.
Fluid change:
Ð Must be carried out according to the manufacturer's servicing schedule.
Ð Use fluids recommended by the manufacturer, which fulfil DOT4standards.
Note: Brake fluid is harmful to health
and very corrosive. Avoid all contactwith the skin. Cooling system Use the fluid recommended by the
manufacturer. When the engine is warm, the tem- perature of the coolant is controlled
by the engine fan. As this fan canoperate with the ignition keyremoved and because the coolingsystem is pressurised, wait for atleast one hour after the engine hasstopped before carrying out anywork. Slacken the cap to the first notch torelease the pressure to prevent anyrisk of scalding. When the pressurehas dropped, remove the cap andtop up the level. Note:
The coolant does not need to
be changed. Used oil Do not dispose of used oil, brake fluid or coolant into drains or into theground. Power steering reservoir  Open the reservoir, with the engine at ambient temperature.The level should always beabove the MIN. mark and closeto the MAX. mark.
Windscreen and headlamp* wash level For best quality cleaning and for
your safety, we advise that youuse products recommended by
PEUGEOT.
* According to destination.
Oil change According to the information given in
"PEUGEOT SERVICING" .
Note: avoid used oil coming into
prolonged contact with the skin.

Only use products recom-
mended by PEUGEOT.
To ensure best per-
formance from components as important as the power steer-ing and the braking system,PEUGEOT selects and offersspecific products.
To prevent damage to the electrical units, avoid washingthe engine.
PRACTICAL INFORMATION 89
22-12-2003
RUNNING OUT OF FUEL (DIESEL) If you should run out of fuel, it is necessary to re-prime the circuit:
Ð fill the fuel tank with at least five
litres of diesel,
Ð operate the manual re-priming pump, under the bonnet under the
protective cover, until fuelappears in the transparent pipe,
Ð operate the starter until the engine starts.
FUEL SUPPLY CUT-OFF (PETROL) In a serious collision, a mechanism prevents fuel from reaching theengine.
To re-establish the fuel supply, press the switch on the corner of the front
right-hand suspension assembly,under the bonnet.
CHECKS Battery
At the start of winter, have your bat-
tery checked by a PEUGEOT deal-
er. Air filter and passenger compartment filter Have the filter elements replaced
regularly.
If you drive in dusty con-
ditions, change them twice asoften. Brake pads Brake pad wear depends on the style of driving, in particular for vehicles which are used in town,over short distances. It may be necessary to check the thickness of the pads, even betweenservices. Handbrake Where the handbrake travel is too great or there is a reduction in theperformance of the system, thehandbrake should be adjusted, evenbetween services. Have the system checked by a
PEUGEOT dealer. Oil filter
Change the filter regularly, in accor- dance with the servicing schedule. Manual gearbox This does not require an oil change. Check the level in accordance with themanufacturer's servicing schedule.

TECHNICAL DATA105
PETROL
Model codes GBHFXB GBKFWB
GCKFWB
ENGINES 1.1 litre 1.4 litre
Cubic capacity (cm 3
) 1 124 1 360
Bore x stroke (mm) 72 x 69 75 x 77
EU standard maximum power (kW)44.1 55
Maximum power at engine speed (rpm) 5 500 5 500
EU standard maximum torque (Nm) 94 120
Maximum torque at engine speed (rpm) 2 700 2 800
Fuel Unleaded Unleaded Catalytic converter YesYes
Gearbox Manual Manual
(5 speed) (5 speed)
Oil capacity (in litres)Engine (with cartridge replacement) 3.2 (1) - 3.4 (2) 3 (1) - 3.25 (2)
Gearbox-Final drive 22
ENGINES AND GEARBOXES (1) Draining by gravity - (2) Draining by suction
22-12-2003

TECHNICAL DATA
106
DIESEL
Model codes GBWJYB/K GBRHYB
GCWJYB PLC GCRHYB
ENGINES 1.9 litre 2 litre Turbo HDI
Cubic capacity (cm 3
) 1 867 1 997
Bore x stroke (mm) 82.2 x 88 85 x 88
EU standard maximum power (kW)51 66
Maximum power at engine speed (rpm) 4 600 4 000
EU standard maximum torque (Nm) 125 205
Maximum torque at engine speed (rpm) 2 500 1 900
Fuel Diesel Diesel
Catalytic Converter YesYes
Gearbox Manual Manual
(5 speed) (5 speed)
Oil capacity (in litres)
Engine (with cartridge replacement) 4.8 4.5
Gearbox-Final drive 1.9 1.9
ENGINES AND GEARBOXES
22-12-2003