2004 MITSUBISHI L200 wiper blades

INSTRUMENTS AND CONTROLS
4-17
Headlamp washer switch*
EE02A-La
The headlamp washer can be operated
with the ignition switch “ON” position and
the lamp switch at “ ” or “ ” position.
1 - Push the button once and the washer
fluid will be sprayed on to the head-
lamps for about 0.5 second.
NOTE
Check the headlamp washers periodically
to confirm that the washer fluid is being
sprayed properly on to the headlamp
lenses.
Precautions to observe when
using wipers and washers
EE13C-Af
(1) If the moving wipers become blocked
by ice or other deposits on the glass,
the motor may burn out even if the
wiper switch is turned to OFF. If ob-
struction occurs, park your vehicle in
a safe place, turn off the ignition, and
clean the deposits from the glass so
that the wipers operate smoothly.
(2) Do not use the wipers when the glass
is dry. They may scratch the glass
surface or the blades may prema-
turely wear out.
(3)
Before using the wipers in cold
weather, check that the wiper blades
are not frozen onto the glass. The mo-
tor may burn out if the wipers are used
with the blades frozen onto the glass.
(4) Avoid using the washer continuously
for more than 20 seconds. Do not
operate the washer when the fluid
reservoir is empty.
Otherwise, the motor may burn out.
(5) Periodically check the level of washer
fluid in the reservoir and refill if required
During cold weather, add a recom-
mended washer solution that will not
freeze in the washer reservoir. Failure
to do so could result in loss of washer
function and frost damage to the sys-
tem components.
(6) If the washer is used in cold weather,
the washer fluid sprayed against the
glass may freeze resulting in poor vis-
ibility. Heat the glass with the
defroster or demister before using the
washer.
E02A004
1
04engL2_240082_4 22-01-2004 13:20 Page 4-17

VEHICLE CARE
Window glassEK10A-A
The window glass can normally be
cleaned using only a sponge and water.
Glass cleaner can be used to remove oil,
grease, dead insects, etc. After washing
the glass, wipe dry with a clean, dry, soft
cloth. Never use the same cloth to wipe
the window glass as would be used to
wipe the paintwork; wax from the painted
surfaces could adhere to the glass and re-
duce its transparency and visibility.
Wiper bladesEK11A-A
Use a soft cloth and glass cleaner to re-
move grease, dead insects, etc., from the
wiper blades. Replace the wiper blades
when they no longer wipe properly.
Engine compartmentEK13A-Aa
Clean the engine compartment at the
beginning and end of winter. Pay particu-
lar attention to flanges, crevices and
peripheral parts where dust containing
road chemicals and other corrosive mater-
ials might collect.
If salt and other chemicals are used on the
roads in your area, clean the engine
compartment at least once every three
months.
Chassis and underbody protection
EK12A-Jc
Your vehicle’s underbody has been
treated at the factory in order to protect it
from rust and corrosion. Some areas have
been injected with anti-corrosion agents
and wax.
The effectiveness of these measures,
however, will be reduced by flying stones,
road chemicals, etc., as the vehicle is
driven. You should take your vehicle to
your authorized MITSUBISHI dealer every
12 months to have body sheet metal
inspected, and it is recommended to have
the underbody checked regularly (autumn
and spring) and have additional protection
treatment carried out as required.
As not all of the commercially available
materials are suitable for use on your
vehicle, it is recommended that you have
this work carried out by an authorized
MITSUBISHI dealer.
When washing the vehicle, especially in
winter, spray the underbody with water to
remove dirt and dust which might contain
salts, road chemicals, etc.
7-7
07engL2_240082_4 22-01-2004 13:09 Page 7-7

Engine oil ................................................................ 9-2
Automatic transmission fluid* .............................. 9-4
Engine coolant ....................................................... 9-5
Battery ..................................................................... 9-6
Brake fluid............................................................... 9-8
Power steering fluid* ............................................. 9-9
Clutch fluid* ............................................................ 9-9
Washer fluid............................................................ 9-10
Wheel condition ..................................................... 9-10
Tyre inflation pressure .......................................... 9-11
Tyre rotation ........................................................... 9-11
Snow tyres .............................................................. 9-12
Tyre chains ............................................................. 9-13
Fuel, engine coolant, oil and exhaust gas
leakage ............................................................. 9-14
Exterior and interior lamp operation .................... 9-14
Meter, gauge and indication/warning lamp
operation .......................................................... 9-14
Clutch pedal free play* .......................................... 9-14
Brake pedal free play ............................................. 9-15
Parking brake lever stroke .................................... 9-15
Hinges and latches lubrication ............................. 9-16
Wiper blades ........................................................... 9-16
Ventilation slots ..................................................... 9-17
Weatherstripping.................................................... 9-17
Additional equipment
(For regions where snow is encountered) .... 9-17
Maintenance
9
09engL2_240082_4 22-01-2004 13:12 Page 9-1

MAINTENANCE
Hinges and latches
lubrication
EM21A-A
Check all latches and hinges, and lubri-
cate if necessary by first cleaning and then
applying multipurpose grease.
Wiper bladesEL05A-F
If the blades are frozen to the windscreen
or rear window, do not operate the wipers
until the ice has melted and the blades are
freed, otherwise the wiper motor may be
damaged.
Wiper blade rubber replacement
1. Lift the wiper arm off the windscreen.
2. Pull the wiper blade until its stopper
(A) disengages from the hook (B).
Then, pull the wiper blade further to
remove it.
NOTE
Do not allow the wiper arm to fall onto the
windscreen; it could damage the glass.
9-16
L05A001A
BC
09engL2_240082_4 22-01-2004 13:13 Page 9-16

INDEX
Running-in recommendations ..................... 5-2
Safe driving techniques ............................. 1-16
Seat belts
Child restraint .......................................... 3-11
Inspection................................................ 3-20
Pregnant women restraint....................... 3-20
Seat belts .................................................. 3-8
Seat
Adjustment ................................................ 3-2
Armrest ..................................................... 3-7
Front seat .................................................. 3-3
Head restraints.......................................... 3-5
Heated seats ............................................. 3-7
Rear seat .................................................. 3-5
Snow tyres ................................................. 9-12
Spare wheel............................................... 8-12
Specifications ............................................ 10-2
Speedometer ............................................... 4-2
Starting ...................................................... 5-11
Starting the engine ........................... 5-11, 5-12
Steering
Power steering fluid ....................... 9-9, 10-26
Power steering system............................ 5-37
Steering lock ........................................... 5-11
Steering wheel height adjustment........... 5-36
Sun visors .................................................. 6-32
Supplemental restraint system
(SRS)-air bag .......................................... 3-20Washing....................................................... 7-4
Water temperature gauge ........................... 4-4
Waxing......................................................... 7-5
Weatherstripping ....................................... 9-17
Wheel
Caps........................................................ 8-15
Condition ................................................. 9-10
Windscreen wiper and washer switch ....... 4-15
Wiper blades ...................................... 7-7, 9-16 Tachometer ................................................. 4-3
Thermometer ............................................... 4-5
Tools..................................................... 8-3, 8-4
Towing ....................................................... 8-19
Trailer towing ............................................... 5-7
Transfer shift lever ..................................... 5-20
Transmission
Automatic transmission........................... 5-16
Fluid ............................................... 9-4, 10-26
Manual transmission ............................... 5-14
Tray under seat ......................................... 6-39
Tripmeter ..................................................... 4-3
Turn-signal
Indication lamps ........................................ 4-7
Switch ..................................................... 4-13
Tyre and wheels
Size................................... 10-8, 10-14, 10-22
Spare wheel ............................................ 8-12
Tyre chains ............................................. 9-13
Tyre inflation pressure ............................ 9-11
Tyre rotation .............................................. 9-11
UKW/MW/LW electronic tuning radio
with tape player ......................................... 6-2
Used engine oils safety instructions .......... 1-16
Vanity mirror .............................................. 6-32
Vehicle information code plate .................. 10-3
Ventilators.................................................. 6-18
Visor
Sun visors ............................................... 6-32
Voltage meter .............................................. 4-5
Washer fluid............................................... 9-10
10-29
10engL2_240082_4 22-01-2004 13:14 Page 10-29