2004 Mercury Monterey automatic transmission fluid

IDENTIFYING COMPONENTS IN THE ENGINE COMPARTMENT
4.2L V6 engines
1. Brake fluid reservoir
2. Air filter assembly
3. Power distribution box
4. Battery
5. Automatic transmission fluid dipstick
6. Engine oil dipstick
7. Engine oil filler cap
8. Windshield washer fluid reservoir
9. Engine coolant reservoir
10. Power steering fluid reservoir
2004 Monterey(mty)
Owners Guide (post-2002-fmt)
USA English(fus)
Maintenance and Specifications
218

1. Start the engine and let it run until it reaches normal operating
temperature (the engine coolant temperature gauge indicator will be
near the center of the normal area between H and C).
2. While the engine idles, turn the steering wheel left and right several
times.
3. Turn the engine off.
4. Check the fluid level in the reservoir. It should be between the MIN
and MAX lines. Do not add fluid if the level is within this range.
5. If the fluid is low, add fluid in small amounts, continuously checking
the level until it reaches the correct operating range. Be sure to put the
cap back on the reservoir.
BRAKE FLUID RESERVOIR
The fluid level will drop slowly as
the brakes wear, and will rise when
the brake components are replaced.
Fluid levels between the“MIN”and
“MAX”lines are within the normal
operating range, there is no need to
add fluid. If the fluid levels are
outside of the normal operating
range, the performance of your
brake system could be
compromised, seek service from
your dealer immediately.
TRANSMISSION FLUID
Checking automatic transmission fluid
Refer to your scheduled maintenance guide for scheduled intervals for
fluid checks and changes. Your transaxle does not consume fluid.
However, the fluid level should be checked if the transaxle is not working
properly, i.e., if the transaxle slips or shifts slowly or if you notice some
sign of fluid leakage.
Automatic transmission fluid expands when warmed. To obtain an
accurate fluid check, drive the vehicle until it is warmed up
(approximately 30 km [20 miles]). If your vehicle has been
operated for an extended period at high speeds, in city traffic
during hot weather or pulling a trailer, the vehicle should be
turned off for about 30 minutes to allow fluid to cool before
checking.
2004 Monterey(mty)
Owners Guide (post-2002-fmt)
USA English(fus)
Maintenance and Specifications
239

Adjusting automatic transmission fluid levels
Before adding any fluid, make sure the correct type is used. The type of
fluid used is normally indicated on the dipstick and also in the
Lubricant specificationssection in this chapter.
Use of a non-approved automatic transmission fluid may cause
internal transaxle component damage.
If necessary, add fluid in 250 mL (1/2 pint) increments through the filler
tube until the level is correct.
If an overfill occurs, excess fluid
should be removed by a qualified
technician.
An overfill condition of
transmission fluid may cause shift and/or engagement concerns
and/or possible damage.
Do not use supplemental transmission fluid additives, treatments or
cleaning agents. The use of these materials may affect transmission
operation and result in damage to internal transmission components.
INFORMATION ABOUT UNIFORM TIRE QUALITY GRADING
New vehicles are fitted with tires
that have a rating on them called
Tire Quality Grades. The Quality
grades can be found where
applicable on the tire sidewall
between tread shoulder and
maximum section width. For
example:
•Treadwear 200 Traction AA Temperature A
These Tire Quality Grades are determined by standards that the United
States Department of Transportation has set.
Tire Quality Grades apply to new pneumatic tires for use on passenger
cars. They do not apply to deep tread, winter-type snow tires,
space-saver or temporary use spare tires, tires with nominal rim
diameters of 10 to 12 inches or limited production tires as defined in
Title 49 Code of Federal Regulations Part 575.104(c)(2).
U.S. Department of Transportation-Tire quality grades:The U.S.
Department of Transportation requires Ford to give you the following
information about tire grades exactly as the government has written it.
2004 Monterey(mty)
Owners Guide (post-2002-fmt)
USA English(fus)
Maintenance and Specifications
241

Item Ford part
nameFord part
numberFord
specification
Automatic
transaxle
(4F50N)Motorcraft
MERCONV
AT F
2
XT-5-QM MERCONV
Disc brake
caliper railsMotorcraft
Silicone Brake
Caliper Grease
and Dielectric
CompoundXG-3 ESE-M1C171-A
Constant
velocity jointsMotorcraft CV
Joint Grease
(High Temp.)XG-5 WSS-MIC258-A1
Windshield
washer fluidMotorcraft
Premium
Windshield
Washer
ConcentrateZC-32–A WSB-M8B16–A2
1Use only brake fluids certified to meet Ford specifications. DOT 3 fluid
is recommended. However, if DOT 3 is not available, DOT 4 fluid can be
used.
2Ensure the correct automatic transmission fluid is used MERCONand
MERCONV are not interchangeable. DO NOT MIX MERCONand
MERCONV. Refer to the scheduled maintenance guide to determine the
correct service interval.
Engine 4.2L OHV V6 engine
Cubic inches 256
Required fuel 87 octane
Firing order 1-4-2-5-3-6
Spark plug gap 1.3-1.4 mm (0.052-0.056 inch)
Ignition system EDIS
Compression ratio 9.27:1
2004 Monterey(mty)
Owners Guide (post-2002-fmt)
USA English(fus)
Maintenance and Specifications
257

A
Accessory delay ..........................59
AdvanceTrac ..............................159
Air bag supplemental restraint
system ........................129, 135, 137
and child safety seats ............131
description ..............129, 135, 137
disposal ....................................140
driver air bag ..........132, 136, 138
indicator light .................131, 140
operation .................132, 136, 138
passenger air bag ...132, 136, 138
side air bag ..............................135
Air cleaner filter .......................254
Air filter, cabin ............................36
Antifreeze
(see Engine coolant) ................224
Anti-lock brake system
(see Brakes) ..............................158
Anti-theft system ........................96
arming the system ....................96
disarming a triggered system ..96
Audio system (see Radio) ...17, 20
Automatic transaxle .................162
fluid, adding ............................239
fluid, checking ........................239
fluid, refill capacities ..............255
fluid, specification ..................258
Automatic transmission
driving an automatic
overdrive .................................164
Auxiliary power point .................57
Axle
lubricant specifications ..........256
B
Battery .......................................222acid, treating emergencies .....222
jumping a disabled battery ....194
maintenance-free ....................222
replacement, specifications ...254
servicing ..................................222
BeltMinder .................................123
Brakes ........................................157
anti-lock ...................................158
anti-lock brake system (ABS)
warning light ...........................158
fluid, checking and adding ....239
fluid, refill capacities ..............255
fluid, specifications .........256, 258
lubricant specifications ..256, 258
parking ....................................159
shift interlock ..........................162
Bulbs ............................................43
C
Capacities for refilling fluids ....255
Cargo net .....................................79
Cassette tape player .............17, 20
Cell phone use ............................65
Certification Label ....................259
Child safety restraints ..............141
child safety belts ....................141
Child safety seats ......................144
in front seat ............................145
in rear seat ..............................145
tether anchorage hardware ...148
Cleaning your vehicle
engine compartment ..............211
instrument panel ....................213
interior .....................................213
interior trim ............................213
plastic parts ............................212
washing ....................................210
2004 Monterey(mty)
Owners Guide (post-2002-fmt)
USA English(fus)
Index
Index
265

waxing .....................................210
wheels ......................................211
wiper blades ............................212
Clock ............................................57
Compass, electronic ....................49
calibration .................................51
set zone adjustment .................50
Console ........................................65
overhead ....................................49
Controls
power seat .................................98
steering column ........................64
Coolant
checking and adding ..............224
refill capacities ................228, 255
specifications ..................256, 258
Cruise control
(see Speed control) ....................61
Cupholder(s) .............................102
Customer Assistance ................177
Ford accessories for your
vehicle .....................................214
Ford Extended Service
Plan ..........................................203
Getting assistance outside
the U.S. and Canada ..............207
Getting roadside assistance ...177
Getting the service you
need .........................................201
Ordering additional owner’s
literature .................................208
The Dispute Settlement
Board .......................................203
Utilizing the
Mediation/Arbitration
Program ...................................206D
Daytime running lamps
(see Lamps) ................................38
Dipstick
automatic transmission
fluid ..........................................239
engine oil .................................219
Doors ...........................................52
lubricant specifications ..........256
power sliding ............................53
Driving under special
conditions ..................................165
through water .........................169
E
Emergencies, roadside
jump-starting ..........................194
Emission control system ..........236
Engine ........................................258
cleaning ...................................211
coolant .....................................224
idle speed control ...................222
lubrication
specifications ..................256, 258
refill capacities ........................255
service points ..........................218
starting after a collision .........178
Engine block heater .................157
Engine oil ..................................219
change oil soon warning,
message center .......................219
checking and adding ..............219
dipstick ....................................219
filter, specifications ........221, 254
recommendations ...................221
refill capacities ........................255
specifications ..................256, 258
Exhaust fumes ..........................157
2004 Monterey(mty)
Owners Guide (post-2002-fmt)
USA English(fus)
Index
266

R
Radio ......................................17, 20
Relays ........................................179
Remote entry system .................84
illuminated entry ..........39, 87–88
locking/unlocking doors .....82, 84
Roadside assistance ..................177
Roof rack .....................................80
S
Safety Belt Maintenance ..........128
Safety belts (see Safety
restraints) ..................116, 119–121
Safety Canopy ...........................137
Safety defects, reporting ..........209
Safety restraints ........116, 119–121
belt minder .............................123
extension assembly ................127
for adults .........................120–121
for children .....................140–141
Occupant Classification
Sensor ......................................117
safety belt maintenance .........128
warning light and chime 122–123
Safety seats for children ..........144
Seat belts
(see Safety restraints) .............116
Seats ............................................97
child safety seats ....................144
front seats ...................97, 99–100
memory seat .....................90, 100
second row seats ....................103
third row
seats .................103, 109, 113–114
SecuriLock passive anti-theft
system ..........................................94Servicing your vehicle ..............216
Spare tire (see Changing
the Tire) ............................187–188
Spark plugs, specifications ......254,
258
Specification chart,
lubricants ...........................256, 258
Speed control ..............................61
Starting your vehicle ........154–156
jump starting ..........................194
Steering wheel
controls ......................................64
tilting .........................................48
T
Tilt steering wheel ......................48
Tires ...................................241–242
changing ..................187–189, 194
snow tires and chains ............253
tire grades ...............................242
treadwear ................................242
Towing .......................................172
recreational towing .................176
trailer towing ..........................172
wrecker ....................................200
Transaxle
automatic operation ...............162
fluid, refill capacities ..............255
lubricant specifications ..........258
Transmission
brake-shift interlock (BSI) ....162
fluid, checking and adding
(automatic) .............................239
lubricant specifications ..........256
Turn signal ..................................41
V
Vehicle dimensions ...................258
2004 Monterey(mty)
Owners Guide (post-2002-fmt)
USA English(fus)
Index
269