2004 MERCEDES-BENZ G55AMG air condition

Contents
Transfer case ..................................... 145
Gear range ................................... 145
Switching transfer case................ 145
Differential locks ............................... 148
A few words about differentials
and differential locks.................... 149
Switching differential locks
on and off..................................... 150
Good visibility .................................... 152
Rear view mirror........................... 152
Headlamp cleaning system .......... 153
Sun visors .................................... 154
Rear window defroster ................. 155
Climate control .................................. 156
Setting the temperature ............... 158
Adjusting air distribution and
volume ......................................... 159
Defrosting .................................... 160
Air recirculation............................ 160
Residual engine heat utilization.... 161
Deactivating the climate control
system ......................................... 162
Air conditioning ............................ 162
Rear passenger compartment
adjustable air vents...................... 163Power windows .................................. 164
Opening and closing the windows. 164
Sliding/pop-up roof ............................ 166
Opening and closing the
sliding/pop-up roof....................... 166
Driving systems .................................. 169
Cruise control ............................... 169
Rear Parking Assist* ..................... 172
Loading............................................... 175
Roof rack ...................................... 175
Cargo compartment cover ............ 175
Enlarged cargo compartment........ 176
Split rear seat bench..................... 176
Partition net* (MB Accessory) ...... 178
Loading instructions ..................... 180
Cargo tie-down rings ..................... 182
Useful features ................................... 183
Interior storage spaces ................. 183
Ashtrays........................................ 186
Cigarette lighter ............................ 188
Electrical outlet ............................. 188
Telephone* ................................... 189
Tele Aid ......................................... 190
Garage door opener ...................... 198
Heated steering wheel .................. 203
Operation.......................................... 205
The first 1000 miles (1500 km) .......... 206
Driving instructions ............................ 207
Drive sensibly – save fuel ............. 207
Drinking and driving...................... 207
Pedals ........................................... 207
Power assistance .......................... 208
Brakes .......................................... 208
Driving off ..................................... 209
Parking ......................................... 209
Tires.............................................. 210
Hydroplaning ................................ 210
Tire traction .................................. 211
Tire speed rating ........................... 211
Winter driving instructions ............ 212
Standing water ............................. 213
Passenger compartment............... 213
Off-road driving ............................. 213
Control and operation of radio
transmitters .................................. 221
Driving abroad .............................. 222
Catalytic converter ....................... 222
Emission control ........................... 222
Coolant temperature .................... 223

Contents
Battery ............................................... 311
Charging the battery .................... 311
Disconnecting the battery ............ 312
Reconnecting the battery ............. 312
Jump starting ..................................... 313
Towing the vehicle ............................. 315
Transporting the vehicle............... 317
Towing the vehicle -
various problem scenarios ........... 317
Front towing eye .......................... 318
Rear towing eye ........................... 318
Freeing a stranded vehicle ........... 318
Fuses ................................................. 319
Fuse box in passenger
compartment ............................... 319
Fuse box in battery box................ 319
Fuse box in front passenger
footwell ........................................ 320
Fuse box in middle tunnel ............ 321
Technical data.................................. 323
Spare parts service............................. 324
Warranty coverage ............................. 325
Loss of Service and Warranty
Information Booklet ...................... 325
Identification labels ............................ 326
Layout of poly-V-belt drive .................. 327
G 500/G 55 AMG ......................... 327
Engine ................................................ 328
Rims and tires .................................... 329
Rims and Tires ............................. 329
Spare wheels ................................ 330
Electrical system ................................ 331
Main dimensions, vehicle weights
and ratings ......................................... 332
Main dimensions........................... 332
Vehicle weights and ratings .......... 332Fuels, coolants, lubricants, etc. .......... 333
Capacities ..................................... 333
Engine oils .................................... 334
Engine oil additives ....................... 335
Air conditioning refrigerant ........... 335
Brake fluid .................................... 335
Premium unleaded gasoline.......... 335
Fuel requirements......................... 336
Gasoline additives......................... 336
Coolants ....................................... 336
Anticorrosion/antifreeze .............. 337
Windshield/rear window washer
system and headlamp cleaning
system .......................................... 339
Consumer information........................ 340
Uniform tire quality grading .......... 340
Technical terms............................... 343Index................................................. 349

11 Introduction
Operator’s Manual
Important notice for California
retail buyers and lessees of Mercedes-Benz automobiles
Under California law you may be entitled to
a replacement of your vehicle or a refund
of the purchase price or lease price, if
Mercedes-Benz USA, LLC and / or its au-
thorized repair or service facilities fail to fix
one or more substantial defects or mal-
functions in the vehicle that are covered by
its express warranty after a reasonable
number of repair attempts. During the pe-
riod of 18 months from original delivery of
the vehicle or the accumulation of
18 000 miles (approx. 29 000 km) on the
odometer of the vehicle, whichever occurs
first, a reasonable number of repair at-
tempts is presumed for a retail buyer or
lessee if one or more of the following oc-
curs:(1) the same substantial defect or mal-
function results in a condition that is
likely to cause death or serious bodily
injury if the vehicle is driven, that de-
fect or malfunction has been subject to
repair two or more times, and you have
directly notified Mercedes-Benz USA,
LLC in writing of the need for its repair,
(2) the same substantial defect or mal-
function of a less serious nature than
category (1) has been subject to repair
four or more times and you have direct-
ly notified us in writing of the need for
its repair, or(3) the vehicle is out of service by reason
of repair of the same or different sub-
stantial defects or malfunctions for a
cumulative total of more than
30 calender days. Written notification
should be sent to us, not a dealer, at
Mercedes-Benz USA, LLC, Customer
Assistance Center, One Mercedes
Drive, Montvale, NJ 07645-0350.

158 Controls in detailClimate controlThe climate control is operational whenev-
er the engine is running. You can operate
the climate control system in either the au-
tomatic or manual mode. The system cools
or heats the interior depending on the se-
lected interior temperature and the cur-
rent outside temperature.Nearly all dust particles, pollutants and
odors are filtered out before outside air en-
ters the passenger compartment through
the air distribution system.
The air conditioning will not engage (no
cooling) if the AC
OFF
mode is selected
(
page 162).
Setting the temperature
Use temperature controls2 and3 to
separately adjust the air temperature on
each side of the passenger compartment.
You should raise or lower the temperature
setting in small increments, preferably
starting at 72°F (22°C).
Warning!
G
When operating the automatic climate con-
trol, the air that enters the passenger com-
partment through the air vents in the
footwell can be very hot or very cold (de-
pending on the set temperature). This may
cause burns or frostbite on unprotected skin
in the immediate area of the air vents. Al-
ways keep sufficient distance between un-
protected parts of the body and the footwell
air vents. If necessary, change the air flow
using the air distribution controls to direct
the air away from the footwell air vents
(page 159).
Warning!
G
Follow the recommended settings for heat-
ing and cooling given on the following pag-
es. Otherwise the windows could fog up,
impairing visibility and endangering you and
others.
iIf the vehicle interior is hot, ventilate
the interior before driving off.
Keep the air intake grille in front of the
windshield free of snow and debris.iWhen operating the climate control
system in automatic mode, you will
only rarely need to adjust the tempera-
ture, air volume and air distribution.

161 Controls in detail
Climate control
Deactivating
Press button O briefly.
The indicator lamp in the button goes
out.
The air recirculation mode is deactivated
automatically:


after 30 minutes if the outside temper-
ature is above about 41°F (5°C)


after 5 minutes if the outside tempera-
ture is below about 41°F (5°C)


after 5 minutes if economy mode
AC
OFF
is selected
Residual engine heat utilization
With the engine switched off, it is possible
to continue to heat or ventilate the interior
for a short while, depending on the temper-
ature setting of the climate control. Air vol-
ume and distribution are controlled
automatically.
Activating
Turn the SmartKey in starter switch to
position1 or0 or remove it from the
starter switch.

Press button °.
The indicator lamp in the button comes
on.
Set the left and right temperature to
your personal requirements.Deactivating

Press button ° again to switch off.
The indicator lamp in the button goes
out.
The residual heat is automatically turned
off:


when the SmartKey in starter switch is
turned to position2


after about 30 minutes


if the battery voltage drops
iThe air recirculation mode is activated
automatically at high outside tempera-
tures.
If you have turned off the air condition-
er or the outside temperature is below
41°F (5°C), the air recirculation mode
will not switch on automatically.

162 Controls in detailClimate controlDeactivating the climate control system
Deactivating
Set the air volume control switch to
position0.
Reactivating

Set the air volume control switch to any
speed.
Air conditioning
The air conditioning is operational while
the engine is running and cools the interior
air to the temperature set by the operator.
Deactivating
It is possible to deactivate the air condi-
tioning (cooling) function of the climate
control system. The air in the vehicle will
then no longer be cooled or dehumidified.
Press button°.
The indicator lamp on the button°
comes on.Activating
Moist air can fog up the windows. You can
dehumidify the air with the air conditioner.

Press button° again.
The indicator lamp on the button°
goes out.
The air conditioner uses the refrigerant
R134a. This refrigerant is free of CFCs
which are harmful to the ozone layer.
iCondensation may drip out from under-
neath the vehicle. This is normal and
not an indication of a malfunction.
!If the° button on the climate con-
trol panel starts to blink, this indicates
that the air conditioner is losing refrig-
erant. The compressor has turned itself
off. The air conditioner cannot be
turned on again.

Have the air conditioner checked at
the nearest authorized
Mercedes-Benz Light Truck Center.

210 OperationDriving instructionsTiresTread wear indicators (TWI) are required by
law. These indicators are located in six
places on the tread circumference and be-
come visible at a tread depth of approxi-
mately
1⁄16
in (1.6 mm), at which point the
tire is considered worn and should be re-
placed.
The tread wear indicator appears as a solid
band across the tread.Specified tire pressures must be main-
tained. This applies particularly if the tires
are subject to high loads (e.g. high speeds,
heavy loads, high ambient temperatures).
Hydroplaning
Depending on the depth of the water layer
on the road, hydroplaning may occur even
at low speeds and with new tires. Reduce
vehicle speed, avoid track grooves in the
road and apply brakes cautiously in the
rain.
!Set the parking brake whenever park-
ing or leaving the vehicle. In addition,
move gear selector lever to positionP.
In addition, when parking on hills, al-
ways set the parking brake and turn
front wheel towards the road curb.Warning!
G
If you feel a sudden significant vibration or
ride disturbance, or you suspect that possi-
ble damage to your vehicle has occurred,
you should turn on the hazard warning flash-
ers, carefully slow down, and drive with cau-
tion to an area which is a safe distance from
the road.
Inspect the tires and the vehicle underbody
for possible damage. If the vehicle or tires
appear unsafe, have it towed to the nearest
Mercedes-Benz Light Truck Center or tire
dealer for repairs.
Warning!
G
Although the applicable federal motor vehi-
cle safety laws consider a tire to be worn
when the tread wear indicators (TWI) be-
come visible at approximately
1⁄16in
(1.6 mm), we recommend that you do not al-
low your tires to wear down to that level. As
tread depth approaches
1⁄8in (3.0 mm), the
adhesion properties on a wet road are
sharply reduced.
Depending upon the weather and/or road
surface (conditions), the tire traction varies
widely.
Warning!
G
Do not drive with a flat tire. A flat tire affects
the ability to steer or brake the vehicle. You
may lose control of the vehicle. Continued
driving with a flat tire or driving at high
speed with a flat tire will cause excessive
heat build-up and possibly a fire.

212 OperationDriving instructionsWinter driving instructions
The most important rule for slippery or icy
roads is to drive sensibly and to avoid
abrupt acceleration, braking and steering
maneuvers. Do not use the cruise control
system under such conditions.
When the vehicle is in danger of skidding,
move gear selector lever to positionN. Try
to keep the vehicle under control by cor-
rective steering action.Road salts and chemicals can adversely af-
fect braking efficiency. Increased pedal
force may become necessary to produce
the normal brake effect.
Depressing the brake pedal periodically
when traveling at length on salt-strewn
roads can bring road-salt-impaired braking
efficiency back to normal.
If the vehicle is parked after being driven
on salt-treated roads, the braking efficien-
cy should be tested as soon as possible af-
ter driving is resumed.
For more information, see “Winter driving”
(
page 240).
iFor information on driving with snow
chains, see “Snow chains”
(page 241).
Warning!
G
On slippery road surfaces, never downshift
in order to obtain braking action. This could
result in drive wheel slip and reduced vehi-
cle control. Your vehicle’s ABS will not pre-
vent this type of control loss.
Do not engage the transfer case in position
LOW when driving on ice or packed snow. At
speeds below 18 mph (30 km / h) vehicle
steering is adversely affected by the LOW
RANGE – ABS (
page 75).
Warning!
G
Make sure not to endanger any other road
users when carrying out these braking ma-
neuvers.
Warning!
G
If the vehicle becomes stuck in snow, make
sure snow is kept clear of the exhaust pipe
and from around the vehicle with the engine
running. Otherwise, deadly carbon monox-
ide (CO) gases may enter vehicle interior re-
sulting in unconsciousness and death.
To assure sufficient fresh air ventilation,
open a window slightly on the side of the ve-
hicle not facing the wind.Warning!
G
The outside temperature indicator is not de-
s i g n e d t o s e r v e a s a n i c e - w a r n i n g d e v i c e a n d
is therefore unsuitable for that purpose. In-
dicated temperatures just above the freez-
ing point do not guarantee that the road
surface is free of ice.