2004 MERCEDES-BENZ G500 headlamp

296 Practical hintsReplacing bulbsRear lamps Notes on bulb replacement


Use only 12 volt bulbs of the same type
and with the specified watt rating.


Switch lights off before changing a bulb
to prevent short circuits.


Always use a clean lint-free cloth when
handling bulbs.


Your hands should be dry and free of oil
and grease.


If the newly installed bulb does not
come on, visit an authorized
Mercedes-Benz Light Truck Center.


Have the LEDs for the following lamps
replaced by an authorized
Mercedes-Benz Light Truck Center.

The additional turn signals in the ex-
terior rear view mirrors


The high mounted brake lamp
Lamp
Type
6
High mounted brake
lamp
LED
7
Turn signal lamp
PY 21 W
Brake lamp
P 21 W
Tail, parking and
standing lamp
R 5 W
8
Backup lamp
P 21 W
9
License plate lamps
C 5 W
a
Rear fog lamp
P 21 W
b
Side marker lamp
T 4 W
Warning!
G
Keep bulbs out of reach of children.
Bulbs and bulb sockets can be very hot. Al-
low the lamp to cool down before changing
a bulb.
Halogen lamps contain pressurized gas. A
bulb can explode if you:

touch or move it when hot


drop the bulb


scratch the bulb
Wear eye and hand protection.
iHave the headlamp settings checked
regularly by a Mercedes-Benz Light
Truck Center.
Do not turn the headlamp adjusting
screws. If the adjusting screws are
turned, the headlamp setting must be
checked by a Mercedes-Benz Light
Truck Center.

297 Practical hints
Replacing bulbs
Replacing bulbs for front lamps
Headlamp assembly (halogen)Removing
Left headlamp, right headlamp laterally re-
versed1Securing screw (trim panel)
2Head lamp trim panel
3Headlamp
Switch off the lights.

Unscrew securing screws1.

Remove head lamp trim panel2 and
seal.4Securing screw (headlamp)

Unscrew headlamp-securing
screws4.

Remove headlamp3.
Installing

Insert headlamp3 and screw in head-
lamp-securing screws4.

Install head lamp trim panel2 and
seal and screw in securing screws1.
iFor vehicles with brush guard*:
Fold the brush guard* down before re-
placing bulbs (
page 293).
G55AMG:
Remove the protective grille before re-
placing the bulbs.

334 Technical dataFuels, coolants, lubricants, etc.Engine oils
Engine oils are specifically tested for their
suitability in our engines. Therefore, use
only engine oils recommended by
Mercedes-Benz. Information on approved
engine oils is available in the Factory Ap-
proved Service Products pamphlet, or at
your authorized Mercedes-Benz Light
Truck Center.Please follow the FSS and Service Booklet
recommendations for scheduled oil chang-
es. Failure to do so could result in engine
damage not covered by the
Mercedes-Benz Limited Warranty.
Model
Capacity
Fuels, coolants, lubricants, etc.
Cooling system
approx. 12.7 US qt (12.0 l)
MB Anticorrosion/Antifreeze
Air conditioning system
R-134a refrigerant and
special PAG lubricant oil (never R-12)
Windshield/rear window washer system
and headlamp cleaning system
approx. 7.9 US qt (7.5 l)
MB Windshield Washer Concentrate
and water
1
1Use MB Windshield Washer Concentrate “S” and water for temperatures above freezing point or MB Windshield Washer Concentrate “S” and commercially available
premixed windshield washer solvent / antifreeze for temperatures below freezing point. Follow suggested mixing ratios (page 339).
!Always check the oil filler cap
(page 232) for important informa-
tion pertaining to the engine oil need-
ing to meet a specific Mercedes-Benz
specification (e.g. MB 229.5). If such
information is printed on the oil filler
cap, only use an engine oil from the list
of approved engine oils in the Factory
Approved Service Products pamphlet
that meets the specification indicated
on the oil filler cap.
Using engine oils of other specification
may cause the FSS to incorrectly deter-
mine the next service interval and will
result in engine damage not covered by
the Mercedes-Benz Limited Warranty.

339 Technical data
Fuels, coolants, lubricants, etc.
Windshield/rear window washer sys-tem and headlamp cleaning system
The windshield washer reservoir is located
in the engine compartment on the front
passenger side. It holds approximately
5.3 US qt (5.0 l). The headlamp cleaning
system is also supplied from the wind-
shield washer reservoir. 
Refill the reservoir with MB Windshield
Washer Concentrate “S” to and water
(or concentrate and commercially
available premixed windshield washer
solvent / antifreeze, depending on am-
bient temperatures) (
page 339).Washer fluid mixing ratio
For temperatures above freezing point use
MB Windshield Washer Concentrate “S”
and water:


1 part “S” to 100 parts water
[40 ml “S” to 1 gallon (4 liters) water]
For temperatures below freezing point use
MB Windshield Washer Concentrate “S”
and commercially available premixed
windshield washer solvent / antifreeze:


1 part “S” to 100 parts solvent
[40 ml “S” to 1 gallon (4 liters) solvent]
Warning!
G
Washer solvent/antifreeze is highly flamma-
ble. Do not spill washer solvent/antifreeze
on hot engine parts, because it may ignite
and burn. You could be seriously burned.

349 Index
A
ABS 25, 74, 343
LOW RANGE mode 75
Malfunction indicator lamp 252, 253
Messages in display 261
Warning lamp 252, 253
Accelerator position, automatic
transmission 144
Accident
In case of 50
Activating
Air conditioning (cooling) 162
Air recirculation mode 160
Anti-theft alarm system 82
Central locking (control system) 133
Defrost 160
Easy-entry/exit feature 133
ESP 81
Exterior headlamps 46
Exterior lamps 105
Exterior rear view mirror parking
position 153Hazard warning flasher 108
Headlamps 46
High beams 108
Ignition 33
Rear fog lamp 106
Rear window defroster 155
Windshield wipers 47
Adding
Coolant 233
Engine oil 231
Additional turn signals 295
Adjusting 34
Air distribution 159
Air volume 159
Backrest tilt 36
Exterior rear view mirror 38
Head restraint height 36
Head restraint height, rear seats 96
Head restraint tilt 36
Instrument cluster illumination 112Interior rear view mirror 38
Mirrors 38
Multicontour seat* 97
Seat cushion length 97
Seat cushion tilt 36
Seat fore and aft adjustment 35
Seat height 36
Seats 34
Steering column in/out 37
Steering column up/down 37
Steering wheel 37
Air conditioning (cooling)
Turning off 162
Turning on 162
Air conditioning refrigerant 335
Air distribution
Adjusting 159
Air pressure see Tire inflation pressure
Air recirculation mode 160
Activating 160
Deactivating 161

350 IndexAir volume
Adjusting 159
AIRBAG OFF indicator lamp 259
Airbags 57
BabySmart
TM airbag deactivation
system 68, 343
Front 61
Safety guidelines 60
Alarm
Audible 73, 82
Canceling 83, 84
Visual 82
Alarm system
Anti-theft 82
Anticorrosion/antifreeze 337
Antiglare
Automatic 152
Antilock brake system (ABS) 343
Anti-theft alarm system
Arming 82Canceling alarm 83
Disarming 83
Anti-theft systems 82
Anti-theft alarm system 82
Tow-away alarm 83
Aquaplaning see Hydroplaning
Armrest
Storage compartment below 184
Storage compartment in front of 184
Ashtrays 186
At the gas station 224
ATF (automatic transmission fluid) 232
AUDIO menu 120
Selecting radio station 121
Automatic antiglare for rear view
mirror 152
Automatic central locking
Activating/deactivating (control
system) 133
Automatic climate control
Deactivating 162
Automatic headlamp mode 105Automatic lighting control
Activating 109
Deactivating 109
Automatic locking when driving 91
Automatic transmission 140
Accelerator position 144
Emergency operation (Limp Home
Mode) 144
Fluid level 232
Gear ranges 142
Gear selector lever position 140, 142
Gear shifting malfunctions 144
Kickdown 144
Manual shifting 141
One-touch gearshifting 141
Transmission fluid 232
B
BabySmart
TM
Airbag deactivation system 68, 343
Compatible child seats 68, 343
Self-test 68

352 IndexCargo compartment
Tailgate 89, 90
Tie-down rings 182
Cargo compartment cover 175
Installing 176
Removing 176
Cargo tie-down rings 182
Catalytic converter 222
CD changer 284
CD player
Operating 121
Center console 27
AIRBAG OFF indicator lamp 259
Lower part 28
Upper part 27
Centigrade
Setting temperature units 127
Central locking
From inside 92
Switch 92Switching on/off (control
system) 133
Unlocking from inside 92
Certification label 326
Changing
Batteries (SmartKey) 288
Key setting 133
Charging
Vehicle battery 311
CHECK ENGINE malfunction indicator
lamp 256
Checking
Coolant level 225, 232
Oil level 226, 228
Checklist
Off-road driving 215
Child safety 65
Infant and child restraint systems 56,
62, 66
LATCH child seat anchors 70Child safety switch see Blocking of rear
door window operation
Cigarette lighter 188
Cleaning
Cup holders 248
Gear selector lever 248
Hard plastic trim items 248
Headlamps 153
Headliner 248
Illuminated door sill panels 249
Instrument cluster 248
Leather upholstery 249
Light alloy wheels 248
MB Tex upholstery 249
Plastic and rubber parts 249
Rear Parking Assist sensors* 247
Seat belts 248
Steering wheel 248
Windows 247
Windshield 48
Wiper blades 247
Wood trims 249

354 IndexCrossing obstacles 218
Cruise control 169, 344
Canceling 170
Driving downhill 170
Driving uphill 170
Fine adjustment 171
Setting current speed 170
Setting speed 171
Cruise control lever 169
Cup holder
In rear passenger footwell 186
Cup holders 185
Cleaning 248
In front passenger footwell 185
Next to the armrest 185
Customer Assistance Center (CAC) 343D
Daytime running lamp mode 106
Setting 129
Deactivating
Air conditioning (cooling) 162
Air recirculation mode 161
Alarm 83
Anti-theft alarm system 83
Central locking (control system) 133
Cruise control 170
Defrost 160
ESP 79
Exterior lamps 105
Exterior lamps delayed
switch-off 131
Hazard warning flasher 108
Headlamps 52
Immobilizer 82
Interior lighting delayed
switch-off 132
Rear window defroster 155
Tow-away alarm 84
Deep water see Standing waterDefogging
Windshield 160
Defrosting 160
Delayed switch-off
Exterior lamps 131
Interior lighting 132
Dialing
A number (telephone) 139
Differential locks 148, 344
Switching off 151
Switching on 150
Difficulties
While driving see Problems while driv-
ing
With starting 44
Digital speedometer 120
Direction of rotation (tires) 237
Discharged battery
Jump starting 313
Disconnecting
Vehicle battery 312
Display
Selecting 129