2004 JEEP LIBERTY manual transmission

²Do not let passengers sit in the vehicle when it is on a
jack.
²Do not get under the vehicle when it is on a jack.
²Failure to follow the ªTire Changing Procedureº may
result in personal injury or damage to your vehicle.
²Only use the jack in the positions indicated.
JUMP STARTING PROCEDURE
NOTE:Check the charge indicator on the battery. If the
indicator is light or yellow, replace the battery.
1. Wear eye protection and remove any metal jewelry
such as watch bands or bracelets that might make an
unintended electrical contact.
2. When boost is provided by a battery in another
vehicle, park that vehicle within booster cable reach but
without letting the vehicles touch. Set the parking brake,place the automatic transmission in P (Park), or manual
transmission in N (Neutral), and turn the ignition to OFF
for both vehicles.
3. Turn off the heater, radio and all unnecessary electrical
loads.
4. Connect one end of a jumper cable to the positive
terminal of the discharged battery. Connect the other end
of the same cable to the positive terminal of the booster
battery.
5. Connect the other cable, first to the negative terminal
of the booster battery and then connect the other end to
a non-paint metal surface on the engine of the vehicle
with the discharged battery. Make sure you have a good
contact on the engine.
6. Start the engine in the vehicle which has the booster
battery, let the engine idle a few minutes, then start the
engine in the vehicle with the discharged battery.
WHAT TO DO IN EMERGENCIES 279
6

NPower Steering Fluid Check..............300
NDriveline And Steering Component
Lubrication..........................301
NBody Lubrication.....................301
NWindshield Wiper Blades................301
NWindshield Washers...................302
NExhaust System......................302
NCooling System.......................303
NHoses And Vacuum/Vapor Harnesses.......307
NBrake System........................308
NAutomatic Transmission................311
NHydraulic Clutch Fluid
Ð Manual Transmission................313
NManual Transmission..................313NTransfer Case........................313
NFront/Rear Axle Fluid..................315
NAppearance Care And Protection From
Corrosion...........................315
mFuse Panel...........................320
NInterior Fuses........................320
N
Underhood Fuses (Power Distribution Center). 323
mVehicle Storage........................324
mReplacement Bulbs......................324
mFluid Capacities........................326
mRecommended Fluids, Lubricants And Genuine
Parts................................327
NEngine.............................327
NChassis............................328
284 MAINTAINING YOUR VEHICLE

Hydraulic Clutch Fluid Ð Manual Transmission
The clutch hydraulic system is a sealed maintenance free
system. In the event of leakage or other malfunction, the
system must be replaced.
Manual Transmission
Selection of Lubricant
Use only manufacturer's recommended manual trans-
mission fluid, refer to Recommended Fluids, Lubricants,
and Genuine Parts for correct fluid type.
Fluid Level Check
Check the fluid level by removing the fill plug. The fluid
level should be between the bottom of the fill hole and a
point not more than 3/16º (4.76 mm) below the bottom of
the hole.
Add fluid, if necessary, to maintain the proper level.
Frequency of Fluid Change
Under normal operating conditions, the fluid installed at
the factory will give satisfactory lubrication for the life of
the vehicle. Fluid changes are not necessary unless the
lubricant has become contaminated with water. If con-
taminated with water, the fluid should be changed im-
mediately.
Transfer Case
Fluid Level Check
Inspect the transfer case for fluid leaks. If a fluid leak is
evident, the transfer case fluid level can be checked by
removing the fill plug (B) located at the back of the
transfer case.
MAINTAINING YOUR VEHICLE 313
7

Cavity Fuse Description
37 10 Amp Red Airbag Control Module
38 10 Amp Red ABS Controller/Shifter As-
sembly
39 10 Amp Red Hazard Flasher (Turn
Signals)/Backup Lamp
Switch (Manual Transmission
Only)/Transmission Range
Switch (Automatic Transmis-
sion Only)
Underhood Fuses (Power Distribution Center)
Your vehicle is equipped with an electrical power distri-
bution center located in the engine compartment near the
battery. This power center houses plug-in ªCartridgeº
fuses which replace in-line fusible links. The power
center also contains ªMiniº fuses and plug-in full and
micro ISO relays. A label inside the latching cover of thecenter identifies each component for ease of replacement,
if necessary. ªCartridgeº fuses and relays can be obtained
from your authorized dealer.
MAINTAINING YOUR VEHICLE 323
7

Chassis
Component Fluid, Lubricant, or Genuine Part
Automatic Transmission MopartATF+4 Automatic Transmission Fluid
Manual Transmission MopartManual Transmission Lubricant (P/N 04874464)
Transfer Case MopartATF+4 Automatic Transmission Fluid
Axle Differential (front-rear) MopartSAE 75W-140 (API GL5) Synthetic Gear Lubricant or equivalent.
The 8.25 Corporate Rear Axle should use a SAE 75W-90 Gear Lubricant.
For trailer towing, the lubricant should be replaced with SAE 75W-140
Synthetic Gear Lubricant. Models equipped with Trac-LokŸ require a fric-
tion modifier additive.
Brake Master Cylinder MopartDOT 3, SAE J1703 should be used. If DOT 3, SAE J1703 brake
fluid is not available, then DOT 4 is acceptable. Use only recommended
brake fluids.
Power Steering Reservoir MopartATF+4 Automatic Transmission Fluid
Ball Joints, Prop Shafts, U-Joints,
Yokes, & Wheel BearingsMopartMulti-Purpose Lube NLGI Grade 2 EP, GC-LB
328 MAINTAINING YOUR VEHICLE

At Each Oil Change
²Change the engine oil filter.
²Inspect the exhaust system.
²Inspect brake hoses.
²Check the coolant level, hoses, and clamps.
²Inspect manual transmission fluid level Ð if
equipped.
²Rotate the tires at each oil change interval shown on
Schedule ªAº 6,000 miles (10 000 km) or every other
interval shown on Schedule ªBº 6,000 miles (10 000
km).
²After completion of off-road operation, the underside
of the vehicle should be thoroughly inspected. Exam-
ine threaded fasteners for looseness.
332 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Flashers
Hazard Warning....................... 272
Turn Signal.......................... 151
Flat Tire Changing....................... 274
Flooded Engine Starting................... 211
Fluid Capacities......................... 326
Fluid Leaks............................. 70
Fluid Level Checks....................... 70
Automatic Transmission................. 311
Clutch Fluid.......................... 313
Engine Oil........................... 290
Manual Transmission................... 313
Power Steering........................ 300
Fog Lights............................. 102
Folding Rear Seat........................ 94
Four Wheel Drive....................... 222
Operation........................... 222
Shifting..........................225,230
Systems..........................222,226Four-Way Hazard Flasher.................. 272
Front Axle............................. 315
Fuel................................. 259
Filler Cap............................ 262
Filler Door........................... 262
Gasoline............................ 259
Gauge.............................. 157
Materials Added....................... 262
Octane Rating........................ 259
Requirements......................259,326
Tank Capacity........................ 326
Fuel System Caution..................... 263
Fuses................................ 320
Garage Door Opener..................... 125
GasCap .............................. 262
Gasoline.............................. 259
Gasoline, Reformulated................... 260
Gasoline/Oxygenate Blends................ 260
INDEX 363
10

Lug Nuts............................. 278
Luggage Carrier......................... 142
Luggage Rack.......................... 142
Maintenance Free Battery.................. 298
Maintenance Procedures................... 290
Maintenance Schedule.................... 330
Light Duty Schedule9A9................. 342
Light Duty Schedule9B9................. 333
Schedule9A9......................... 342
Schedule9B9.......................... 333
Maintenance, Sunroof..................... 132
Malfunction Indicator Light..............152,288
Manual, Service......................... 354
Manual Transmission..................213,313
Fluid Level Check...................... 313
Lubricant Selection..................... 313
Shift Speeds.......................... 215
Map/Reading Lights..................... 111Master Cylinder......................... 310
Mini-Trip Computer...................... 120
Mirrors................................ 75
Automatic Dimming..................... 76
Electric Remote........................ 77
Heated.............................. 78
Outside.............................. 76
Rearview............................. 75
Vanity............................... 78
Modifications/Alterations, Vehicle............. 8
Monitor, Tire Pressure System............ 113,254
Mopar Parts.........................289,353
Multi-Function Control Lever............... 100
New Vehicle Break-In Period................ 68
Occupant Classification System............... 51
Occupant Restraints....................... 34
Octane Rating, Gasoline................... 259
INDEX 367
10