2004 DODGE SPRINTER display

128 UNDERSTANDING YOUR INSTRUMENT PANELSwitching off preselected times:
Press the buttonH repeatedly until no memory is
displayed – no preselected time is activated.
Setting the Heating Period
Settings between 1 minute and 120 minutes may be set
for heating periods to run when the ignition is
switched off.
Do not switch on the heater.
Press the buttoný until the current heating period
begins to flash.
Use either the buttonýorþ to set the desired
heating period. The new heating period will be saved
as soon as the display disappears.
Auxiliary Heater Operation
The symbolö appears in the timer display as soon
as the heater is switched on. After about 20 to
50 seconds, the heater runs with the complete flow of
heat, so that the operating temperature is reached as
soon as possible.Heat operation:
Different operating conditions will be in effect
depending on the heat level required.
The integrated control unit adjusts the heat flow using
the following operating levels:
Water heater: High – Low – Off
Air heater: Power – High – Medium – Low – Off
Safety Equipment
For safety reasons, the heater will automatically switch
off if faults occur which cause the device to overheat.
Tips for Coping with Problems; refer to "Auxiliary
Heater – Tips for Coping with Problems".
The integrated control unit contains a diagnostic
system which detects and stores faults. The error can
be read by means of the vehicle diagnosis. If a fault
occurs while the heater is switched on, the
symbolö will flash and the error code for that fault
will be displayed in the timer.
The fault should be corrected as soon as possible by an
authorized Sprinter Dealer.Freightliner-all.book Pag e 128 Monday, December 1, 2003 2:54 PM

136 STARTING AND OPERATING1. Apply the parking brake.
2. Automatic transmission, shift selector lever to "P"
or "N" position, refer to "Automatic Transmission".
3. Do not depress the accelerator pedal.
4. Turn the key to position 2 in the ignition lock.
The preheater indicator lampq lights up.5. Turn the key clockwise to the stop as soon as the
preheater indicator lamp
q
goes out.
If the engine is at its normal operating temperature,
the preheater indicator lamp will only light up briefly.
Release the key as soon as the engine is running.
NOTE: The key must be returned to position 0 in the
ignition lock before repeating the starting procedure.
If the displayÁ lights up alternately withî in
the multi-function display, there is an immobilizer
malfunction or the key used has not been
programmed.
The: engine oil level warning lamp and the#
battery charge warning lamp must go out after the
engine is started.
If either lamp remains on, stop the engine at once and
have the cause traced and repaired by an authorized
Sprinter Dealer.
During the trip, check the displays and the warning/
indicator lamps in the instrument cluster at regular
intervals.
For instrument cluster and indicator lamps.Maximum Engine SpeedThe maximum engine speed for all vehicles is
4,200 rpm.
Freightliner-all.book Pag e 136 Monday, December 1, 2003 2:54 PM

STARTING AND OPERATING 141
5
Selector Lever PositionThe current selector lever position (1) is indicated in
the gear range indicator display. The automatic gear
shifting process can be adapted to specific operating
conditions using the selector lever.
v
Park Position
The park position is to be used when parking the
vehicle. Engage only with the vehicle stopped.
The park position is not intended to serve as a
brake when the vehicle is parked. Rather, the
driver should always use the parking brake in
addition to placing the selector lever in park
position to secure the vehicle.
NOTE: With a malfunction in the vehicle’s electrical
system the selector lever could remain locked in
position "P". To unlock the selector lever manually,
refer to "Transmission Selector Lever, Manually
Unlocking".
t Reverse Gear
Shift to reverse gear only with the vehicle
stopped.
s Neutral
No power is transmitted from the engine to the
drive axle. When the brakes are released, the
vehicle can be moved freely (pushed or towed).
Do not engage "N" while driving as you may
otherwise lose control of the vehicle.
Freightliner-all.book Pag e 141 Monday, December 1, 2003 2:54 PM

142 STARTING AND OPERATINGNOTE: Coasting the vehicle, or driving with selector
lever in "N" can result in transmission damage that is
not covered by the Sprinter Warranty.
wThe transmission automatically upshifts through
5th gear. Position "D" provides optimum driving
characteristics under all normal operating
conditions.Gear Selection for Special CircumstancesThe transmission gear ranges for special circumstances
can be selected by pushing the selector lever to the
right or the left with the selector lever in position "D".
The gear range currently selected is indicated in the
instrument cluster display.
Briefly press selector lever in the ç direction:
The transmission downshifts, one gear range at a time,
in the order "4", "3", "2", "1".
Press and hold selector lever in the ç direction:
The transmission will shift to a gear range which
favorably accelerates or decelerates the vehicle. This
way downshiftings can be caused.Briefly press selector lever in the æ direction:
The transmission will shift from the current gear range
to the next higher gear range. If the transmission is
already in gear range "D", an additional upshift of one
gear is not possible.
Press and hold selector lever in the æ direction:
The transmission will shift from the current gear range
directly to gear range "D".
NOTE: With transmission in gear range "D", "4"
or "3",
upshifting from 1st to 2nd to 3rd gear is delayed
depending on vehicle speed and engine temperature.
This allows the catalytic converter to heat up more
quickly to operating temperatures.
During the brief warm-up period this delayed upshift
and increased engine noise might be perceived as a
malfunction. However, neither the engine nor
WARNING!
On slippery road surfaces, never downshift in order
to slow the vehicle down. This could result in drive
wheel slip and reduced vehicle control. Your vehi-
cle’s ABS will not prevent this type of loss of control.
Freightliner-all.book Pag e 142 Monday, December 1, 2003 2:54 PM

250 MAINTENANCE SCHEDULES
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S8
MA INTENA NCE - WITH A SSYST MA INTENA NCE
COMPUTERASSYST provides you with information on the best
possible timing for maintenance work.
NOTE: The engine manufacturer strongly
recommends the use of synthetic engine oils, such as
Mobil 1 SAE 0W-40.
When the next maintenance service is due, this will be
indicated in the multi-function display with the
symbol
9 Oil service
9 Maintenance service - displayed in km/miles
or days.
9
If the display shows the number of days, the symbol
È will also appear in the multi-function display.
You should have the maintenance performed within
the stated period/distance.
The service indicator will be reset by your Sprinter
Dealer after an oil service and/or maintenance service
has been performed.
REGULA R CHECK-UPSTo maintain the safe operation of your vehicle, it is
recommended that you perform the following tasks on
a regular basis (i.e., weekly or whenever the vehicle is
refueled). Check:
 Engine oil level
 Brake system, clutch mechanism – fluid level
 Battery – acid level
 Windshield washer system and headlamp cleaning
system – fluid level
 Mechanical assemblies (e. g. ,engine, transmission,
etc.) – check for leaks
 Condition of tires and tire pressures
 All exterior lights
Freightliner-all.book Pag e 250 Monday, December 1, 2003 2:54 PM

INDEX 263
10
Service Brake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 146
Bulbs
Bulb Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . 233
Front Lamp Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . 233
CCapacities . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 244
Care of Vehicle
Engine Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . 221
Headlamps, Taillamps, Turn Signal Lenses . . . . 222
Vehicle Washing . . . . . . . . . . . . . . . . . . . . . . . . . . . 222
Care of vehicle
Paintwork, painted body components . . . . . . . . 221
Power washer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 220
Tar stains . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 221
Catalytic Converter . . . . . . . . . . . . . . . . . . . . . . . . . . . 183
Central Locking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Locking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Central Locking Switch. . . . . . . . . . . . . . . . . . . . . . . . . 13
Locking and Unlocking . . . . . . . . . . . . . . . . . . . . . . 15
Locking Status Display . . . . . . . . . . . . . . . . . . . . . . 14To Program the Automatic Lock Feature . . . . . . . 15
Chains, Snow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 170
Changing a Bulb
Additional Brake Lamp . . . . . . . . . . . . . . . . . . . . . 240
Exit Lamps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 243
Front Lamp Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . 233
Interior Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . 242
Interior Lighting with Interior Sensor
Protection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 243
License Plate Lamp . . . . . . . . . . . . . . . . . . . . . . . . . 240
Reading Lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 242
Side-Marker Lamp . . . . . . . . . . . . . . . . . . . . . . . . . 241
Side-Mounted Turn Signal . . . . . . . . . . . . . . . . . . 241
Taillamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 238
Changing the Tire . . . . . . . . . . . . . . . . . . . . . . . . . . . . 187
Charging the Battery . . . . . . . . . . . . . . . . . . . . . . . . . . 217
Checking Coolant Level . . . . . . . . . . . . . . . . . . . . . . . 213
Checking Weights of Vehicle and Trailer. . . . . . . . . 179
Cigar Lighter. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 76Freightliner-all.book Pag e 263 Monday, December 1, 2003 2:54 PM

264 INDEXCleaning
Cup Holder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 224
Hard Plastic Trim Items . . . . . . . . . . . . . . . . . . . . . 225
Instrument Cluster . . . . . . . . . . . . . . . . . . . . . . . . . 224
Light Alloy Wheels . . . . . . . . . . . . . . . . . . . . . . . . . 224
Plastic and Rubber Parts . . . . . . . . . . . . . . . . . . . . 225
Seat Belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 224
Steering Wheel and Gear Selector Lever . . . . . . . 224
Upholstery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 224
Wiper Blade . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 223
Climate Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 116
Clock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89
Comfort Tire Pressures . . . . . . . . . . . . . . . . . . . . . . . . 169
Compartments in Front Doors. . . . . . . . . . . . . . . . . . . 79
Constant RPMs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 137
Consumer Assistance
Be Reasonable with Request . . . . . . . . . . . . . . . . . 256
If You Need Assistance . . . . . . . . . . . . . . . . . . . . . 256
Prepare a List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 256
Prepare for the Appointment . . . . . . . . . . . . . . . . 256Coolant Level Indicator Lamp . . . . . . . . . . . . . . . . . . . 98
Coolant Temperature Gauge . . . . . . . . . . . . . . . . . . . . 93
Corrosion Protection . . . . . . . . . . . . . . . . . . . . . . . . . . 219
Cup Holder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 78
DDe-Fogging . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 112
Dehumidification . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 117
De-Icing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 112
Diesel Fuels for Use at Very Low Temperatures. . . 171
Displaying Engine Oil Level . . . . . . . . . . . . . . . . . . . 106
Doors
Front Doors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Rear Cargo Doors . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Sliding Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Draining Fuel Filter with Water Separator . . . . . . . 175
Driver’s Airbag. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41EElectric Sun Roof . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74
Electrical Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 225
Fuse and Relay Optional Equipment . . . . . . . . . . 230
Freightliner-all.book Pag e 264 Monday, December 1, 2003 2:54 PM

INDEX 265
10
Fuse, Relay, and Diode Assignments - Optional
Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 231
Relay Assignment, Standard Equipment . . . . . . 230
Standard Fuse and Relay Equipment . . . . . . . . . 226
Electrical Outlet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77
Electronic Brake Force Distribution . . . . . . . . . . . . . 155
Electronic Brake Force Distribution Lamp. . . . . . . . 148
Electronic Stability Program . . . . . . . . . . . . . . . . . . . 157
Emission Label, Vehicle/Engine . . . . . . . . . . . . . . . . . . 6
Emission Related Component . . . . . . . . . . . . . . . . . . 208
Emissions Control System . . . . . . . . . . . . . . . . . . . . . 183
Engine Break-in Recommendations . . . . . . . . . . . . . . 46
Engine Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 221
Engine Control Unit Indicator Lamp . . . . . . . . . . . . . 99
Engine Coolant. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 212
Engine Oil Consumption . . . . . . . . . . . . . . . . . . . . . . . 47
Engine Oil Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 210
Indicator in Instrument Cluster . . . . . . . . . . . . . . 108
Engine Oil Level - Display in Instrument Cluster . 105
Engine Oil Level Indicator Lamp . . . . . . . . . . . . . . . . 97Engine Oils . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 209
Engine oils . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 210
Engine Speed, Maximum . . . . . . . . . . . . . . . . . . . . . . 136
Engine, Stopping . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 138
Exhaust Gas, Inhalation of . . . . . . . . . . . . . . . . . . . . . . 48
FFog Lamp Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62
Folding Seat at Partition . . . . . . . . . . . . . . . . . . . . . . . . 57
Fording . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 183
Front Seat Passenger Airbag . . . . . . . . . . . . . . . . . . . . 42
Fuel Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 175
Fuel Filter with Water Separator . . . . . . . . . . . . . . . . 170
Fuel Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 94
Fuel Tank Capacity . . . . . . . . . . . . . . . . . . . . . . . . . . . 173
Fuels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 170
Bleeding the Diesel Fuel System . . . . . . . . . . . . . . 176
Diesel Fuels for Use at Very Low
Temperatures . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 171
Draining Fuel Filter with Water Separator . . . . . 175
Fuel Filter with Water Separator . . . . . . . . . . . . . 170
Freightliner-all.book Pag e 265 Monday, December 1, 2003 2:54 PM