2004 CHRYSLER 300 M maintenance schedule

Once a Month
•
Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transaxle and add
as needed.
•Check all lights and all other electrical items for correct
operation.
•Check rubber seals on each side of the radiator for
proper fit.
At Each Oil Change
•
Change the engine oil filter.
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the CV joints and front and rear suspension
components.
•Check the automatic transmission fluid level.
•Check the coolant level, hoses, and clamps.
•Rotate the tires at each oil change interval shown on
Schedule “A” 6,000 miles (10 000 km) or every other
interval shown on Schedule “B” 6,000 miles (10 000
km).
242 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

SCHEDULE “B”
Follow schedule “B” if you usually operate your vehicle
under one or more of the following conditions. Change
the automatic transmission fluid and filter every 60,000
miles (96 000 km) if the vehicle is usually operated under
one or more of the conditions marked with an.
•Day or night temperatures are below 32° F (0° C).
•Stop and go driving.
•Extensive engine idling.
•Driving in dusty conditions.
•Short trips of less than 10 miles (16.2 km).
•More than 50% of your driving is at sustained high
speeds during hot weather, above 90° F (32° C).
•Trailer towing.
•Taxi, police or delivery service (commercial ser-
vices).
•Off-road or desert operation.
•If equipped for and operating with E-85 (ethanol)
fuel.
NOTE:IfANYof these apply to you then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first and follow schedule “B” of the
Maintenance Schedulessection of this manual.
SCHEDULE “B” 243
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 93,000 96,000 99,000 100,000 102,000 105,000
(Kilometers) (149 000) (154 000) (158 000) (160 000) (163 000) (168 000)
Change engine oil and engine oil filter. X X X X X
Inspect theair cleaner filterand replace if re-
quired.*XXX X
Replace theair cleaner filter.X
Inspect the front and rear brake linings and
rotors.X
Flush and replace the engine coolant. X
Replace theengine timing belt(Federal Emis-
sions).X
Replace theengine timing belt(California
Emissions).X
Replace thespark plugs.X
Adjust the drive belt tension.X
Change the differential fluid. X
* This maintenance is recommended by the manufacture
to the owner but is not required to maintain the emis-
sions warranty.
‡ This maintenance is not required if previously replaced.Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
SCHEDULE “B” 249
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 78,000 84,000 90,000 96,000 102,000
(Kilometers) (125 000) (134 000) (144 000) (154 000) (163 000)
[Months] [78] [84] [90] [96] [102]
Change engine oil and engine oil filter. X X X X X
Inspect theair cleaner filterand replace if re-
quired.*XX XX
Replace theair cleaner filter.*X
Adjust the drive belt tension. X
Inspect the front and rear brake linings and rotors. X
Replace thespark plugs.X
Check and replace, if necessary, thePCV valve.*‡ X
Replace theengine timing belt(Federal Emissions
equipped vehicles only).X
Replace theengine timing belt(California Emis-
sions equipped vehicles only).X
Flush and replace the engine coolant at 60 months
or 100,000 miles.X
* This maintenance is recommended by the manufacture
to the owner but is not required to maintain the emis-
sions warranty.
‡ This maintenance is not required if previously replaced.Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
252 SCHEDULE “A”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Cruise...........................72,114
Daytime Running...................... 68
Dimmer Switch, Headlight............... 68
Dome............................... 74
Door Ajar........................... 114
Exterior Check........................ 48
Fog .............................67,233
Front Replacement.................... 230
Hazard Warning Flasher................ 182
Headlight Switch...................... 66
Headlights........................66,230
High Beam Indicator................... 114
Illuminated Entry...................... 14
Instrument Cluster..................... 65
Interior...........................14,64
Low Fuel........................... 113
Low Washer Fluid..................... 114
Malfunction Indicator............... 115,198
Map Reading......................... 65
Oil Pressure......................... 113
Park.............................66,233
Passing............................. 68
Reading............................. 74Seat Belt Reminder.................... 114
Security Alarm........................ 24
Service Engine Soon................... 198
Side Marker......................... 230
Theft Alarm.......................... 10
Traction Control.................70,113,164
Trunk Ajar.......................... 113
Turn Signal....................... 114,233
Voltage............................. 116
Locks
Cylinder Maintenance.................. 16
Door.............................14,15
Glove Compartment.................... 13
Lubricants............................ 211
Luggage Carrier........................ 179
Luggage Rack......................... 179
Lumbar Support........................ 59
Maintenance Free Battery................. 208
Maintenance Schedule................... 240
Light Duty ScheduleB................ 243
ScheduleA......................... 250
ScheduleB......................... 243
272 INDEX

Pets.................................. 46
Pets, Transporting....................... 46
Power
Distribution Center.................... 228
Door Locks.......................... 14
Outlet.............................. 105
Seats............................... 57
Steering............................ 163
Steering, Checking.................... 210
Sunroof............................. 86
TrunkLid ............................ 26
Windows............................ 25
Pregnant Women and Seat Belts............. 32
Programmable Electronic Features.....76,79,81,83
Programming Transmitters........20,76,79,81,83
Radial Ply Tires........................ 168
Radiator Cap.......................... 216
Radio.......................... 119,126,132
Radio Broadcast Signals.................. 118
Radio Operation.....................143,145
Radio Remote Controls.................. 142
Radio, Satellite......................... 137Rear Seat, Folding....................... 62
Reclining Front Seats..................... 58
Recommended Fluids, Lubricants and Genuine
Parts............................... 237
Reformulated Gasoline................... 175
Refrigerant............................ 209
Reminder, Lights On..................... 66
Remote Keyless Entry.................... 18
Remote Trunk Release.................... 26
Replacement Tires...................... 172
Reporting Safety Defects................. 259
Restraint, Head......................... 62
Restraints, Occupant..................... 27
Rotation, Tires......................167,173
Safety Checks Inside Vehicle............... 48
Safety Checks Outside Vehicle.............. 48
Safety, Exhaust Gas...................... 47
Safety Tips............................. 47
Satellite Radio......................... 137
Satellite Radio Antenna.................. 139
Schedule, Maintenance................... 240
Scheduled Maintenance.................. 201
274 INDEX