2004 CHEVROLET SSR trailer

If No Steam Is Coming From Your
Engine
If you get an engine overheat warning but see or hear
no steam, the problem may not be too serious.
Sometimes the engine can get a little too hot when you:
Climb a long hill on a hot day.
Stop after high-speed driving.
Idle for long periods in traffic.
Tow a trailer. See “Driving on Grades” under
Towing a Trailer on page 4-39.
If you get the overheat warning with no sign of steam,
try this for a minute or so:
1. In heavy traffic, let the engine idle in NEUTRAL (N)
while stopped. If it is safe to do so, pull off the road,
shift to PARK (P) or NEUTRAL (N) and let the
engine idle.
2. Turn on your heater to full hot at the highest fan
speed and open the window as necessary.If you no longer have the overheat warning, you can
drive. Just to be safe, drive slower for about 10 minutes.
If the warning doesn’t come back on, you can drive
normally.
If the warning continues, pull over, stop, and park your
vehicle right away.
If there’s still no sign of steam, idle the engine for
three minutes while you’re parked. If you still have
the warning, turn off the engine and get everyone out of
the vehicle until it cools down.
You may decide not to lift the hood but to get service
help right away.
5-27

Fuses Usage
28 Roof Door Module
29 Blank
31 Truck Body Controller
32 Remote Keyless Entry (RKE)
33 Windshield Wipers
34 Stoplamps
35 Blank
36Climate Control System, Driver’s
Door Unlock
37 Front Parking Lamps
38 Driver’s Side Turn Signal
39 Climate Control System
40 Truck Body Controller
41 Radio
42 Trailer Parking Lamps
43 Passenger’s Side Turn Signal
44 Blank
46 Accessory Power Outlets
47 Ignition
48 BlankFuses Usage
49 Blank
50 Truck Body Controller, Ignition
51 Brakes
52 Blank
Relays Usage
18 Locks
24 Unlock
30 Parking Lamps
45Rear Window Defogger, Outside
Power Heated Mirrors
Circuit
BreakersUsage
01 Roof & Door Module
02 Roof Pump
08 Power Seats
5-86

(g)A uid loss in any vehicle system could indicate a
problem. Have the system inspected and repaired
and the uid level checked. Add uid if needed.
(h)Change automatic transmission uid and lter if the
vehicle is mainly driven under one or more of these
conditions:
In heavy city traffic where the outside temperature
regularly reaches 90°F (32°C) or higher.
In hilly or mountainous terrain.
When doing frequent trailer towing.
Uses such as found in taxi, police or delivery
service.
(i)Drain, ush and rell cooling system. See Engine
Coolant on page 5-23for what to use. Inspect hoses.
Clean radiator, condenser, pressure cap and ller neck.
Pressure test the cooling system and pressure cap.Owner Checks and Services
These owner checks and services should be performed
at the intervals specied to help ensure the safety,
dependability and emission control performance of your
vehicle. Your GM Goodwrench dealer can assist you
with these checks and services.
Be sure any necessary repairs are completed at once.
Whenever any uids or lubricants are added to your
vehicle, make sure they are the proper ones, as shown
inRecommended Fluids and Lubricants on page 6-13.
At Each Fuel Fill
It is important to perform these underhood checks at
each fuel ll.
Engine Oil Level Check
Check the engine oil level and add the proper oil if
necessary. SeeEngine Oil on page 5-13for further
details.
Notice:It is important to check your oil regularly
and keep it at the proper level. Failure to keep your
engine oil at the proper level can cause damage
to your engine not covered by your warranty.
6-9

Driving On Grades..........................................4-50
Driving on Snow or Ice....................................4-27
Driving Through Deep Standing Water...............4-19
Driving Through Flowing Water.........................4-19
Driving with a Trailer.......................................4-48
Brake Pedal Travel.........................................5-35
E
Electrical System
Add-On Equipment......................................5-83
Fuses and Circuit Breakers...........................5-84
Headlamps.................................................5-83
Power Windows and Other Power Options......5-83
Windshield Wiper Fuses...............................5-83
Emergency Cargo Cover Release Handle...........2-34
Emissions Inspection and
Maintenance Programs.................................3-35
Engine
Air Cleaner/Filter.........................................5-19
Battery.......................................................5-36
Change Engine Oil Light...............................3-37
Check and Service Engine Soon Light............3-32
Coolant......................................................5-23
Coolant Temperature Gage...........................3-32
Cover........................................................5-18
Drive Belt Routing.......................................6-16Engine (cont.)
Engine Compartment Overview......................5-12
Exhaust.....................................................2-21
Oil .............................................................5-13
Overheating................................................5-26
Reduced Power Light...................................3-38
Starting......................................................2-15
Engine Compartment Fuse Block......................5-87
Engine Coolant Hot Idle Engine........................3-50
Engine Cover Insert........................................5-18
Engine Oil Additives........................................5-16
Engine Overheated Stop Engine.......................3-50
Erasing HomeLink
®Buttons..............................2-29
Event Data Recorders (EDR)............................7-10
Exit Lighting...................................................3-16
Express Down Window....................................2-10
Extender, Safety Belt.......................................1-20
Exterior Lamps...............................................3-12
F
Fan Knob......................................................3-20
Filter
Engine Air Cleaner......................................5-19
Finding a Program Type (PTY) Station.......3-65, 3-75
Finding a Station....................................3-63, 3-72
5

H
Hazard Warning Flashers................................... 3-3
Hdr (Header) Latch Switch Fault.......................3-51
Headlamp
Aiming.......................................................5-43
Headlamp High/Low-Beam Changer.................... 3-6
Headlamps....................................................5-44
Bulb Replacement.......................................5-43
Electrical System.........................................5-83
Front Turn Signal, Sidemarker
and Parking Lamps..................................5-45
Halogen Bulbs............................................5-44
Heated Seats................................................... 1-3
Highbeam On Light.........................................3-39
Highway Hypnosis...........................................4-24
Hill and Mountain Roads..................................4-24
Hitches..........................................................4-43
HomeLink
®Transmitter....................................2-26
HomeLink®Transmitter, Programming................2-27
Hood
Checking Things Under................................5-10
Release.....................................................5-10
Horn............................................................... 3-4
How to Add Automatic Transmission Fluid..........5-23
How to Add Coolant to the Coolant Surge Tank......5-30
How to Check................................................5-59
How to Check Lubricant...................................5-43How to Check Power Steering Fluid..................5-31
How to Check the Automatic Transmission Fluid.....5-21
How to Inspect the Engine Air Cleaner/Filter.......5-19
How to Use This Manual...................................... ii
How to Wear Safety Belts Properly...................1-12
Hydroplaning..................................................4-19
I
If No Steam Is Coming From Your Engine..........5-27
If Steam Is Coming From Your Engine...............5-26
If the Light is Flashing.....................................3-34
If the Light Is On Steady.................................3-34
If You Are Caught in a Blizzard.........................4-29
If You Are Stuck in Sand, Mud, Ice or Snow.......4-31
If You Decide To Pull A Trailer..........................4-40
Ignition Positions.............................................2-14
Infants and Young Children, Restraints...............1-24
Ination - Tire Pressure...................................5-58
Inator Kit, Tire...............................................5-67
Instrument Panel
Cluster.......................................................3-24
Overview..................................................... 3-2
Storage Area..............................................2-30
Instrument Panel Brightness.............................3-15
Integrated Windshield Antenna..........................3-87
Interior Lamps................................................3-15
7

M
Maintenance Schedule
Additional Required Services........................... 6-6
At Each Fuel Fill........................................... 6-9
At Least Once a Month................................6-10
At Least Once a Year..................................6-10
Introduction.................................................. 6-2
Maintenance Footnotes.................................. 6-8
Maintenance Record....................................6-17
Maintenance Requirements............................. 6-2
Normal Maintenance Replacement Parts.........6-15
Owner Checks and Services........................... 6-9
Recommended Fluids and Lubricants.............6-13
Scheduled Maintenance................................. 6-4
Using Your................................................... 6-3
Your Vehicle and the Environment................... 6-2
Maintenance When Trailer Towing.....................4-51
Making Turns.................................................4-49
Malfunction Indicator Light................................3-32
Manually Open Tonneau..................................3-51
Map Pocket...................................................2-30
Matching Transmitter(s) to Your Vehicle............... 2-5
Memory Seat.................................................2-52
Message
DIC Warnings and Messages........................3-48Mexico, Central America and Caribbean
Islands/Countries (Except Puerto Rico and
U.S. Virgin Islands) – Customer Assistance....... 7-5
Mirrors
Automatic Dimming Rearview with HomeLink
®. . . 2-23
Manual Rearview Mirror................................2-23
Outside Automatic Dimming Heated Mirror......2-25
Outside Convex Mirror.................................2-25
Outside Power Heated Mirrors.......................2-24
Mode Knob....................................................3-20
MyGMLink.com................................................ 7-4
N
New Vehicle Break-In......................................2-13
Normal Maintenance Replacement Parts............6-15
O
Odometer......................................................3-25
Odometer, Trip...............................................3-25
Off-Road Recovery..........................................4-13
9

Tlat (Tonneau Latch) Hall Switch Fault...............3-54
Tonn (Tonneau) Hall Switch Fault......................3-54
Tonn (Tonneau) Latd (Latched) Switch Fault.......3-54
Top Strap......................................................1-30
Top Strap Anchor Location...............................1-32
Torque Lock...................................................2-20
Total Weight on Your Vehicle’s Tires..................4-43
Towing
Recreational Vehicle.....................................4-32
Towing a Trailer..........................................4-39
Your Vehicle...............................................4-32
Traction
Control System (TCS).................................... 4-9
Control System Warning Light.......................3-31
Traction Active................................................3-54
Trailer
Recommendations.......................................4-38
Trailer Brakes.................................................4-48
Trailer Wiring Harness.....................................4-51
Trans (Transmission) Hot Idle...........................3-54
Transmission
Fluid, Automatic...........................................5-20Transmission Operation, Automatic....................2-16
Transmission, Transaxle, Transfer Case Unit
Repair Manual............................................7-13
Transportation Options...................................... 7-8
Trip Information..............................................3-46
Trip Odometer................................................3-25
Turn and Lane Change Signals.......................... 3-6
Turn Signal On...............................................3-55
Turn Signal/Multifunction Lever........................... 3-5
Turn Signals When Towing a Trailer..................4-49
U
Understanding Radio Reception........................3-87
Uniform Tire Quality Grading............................5-61
United States – Customer Assistance.................. 7-5
Unknown Speed.............................................3-55
Using Cleaner on Fabric..................................5-75
Using HomeLink
®...........................................2-29
Using Song List Mode.....................................3-83
14

V
Vehicle
Control........................................................ 4-6
Damage Warnings........................................... iv
Loading......................................................4-32
Symbols......................................................... iv
Vehicle Data Collection and Event Data
Recorders..................................................7-10
Vehicle Identication
Number (VIN).............................................5-82
Service Parts Identication Label...................5-82
Vehicle Personalization
DIC ...........................................................3-55
Memory Seat..............................................2-52
Vehicle Storage..............................................5-37
Ventilation Adjustment......................................3-22
Visors...........................................................2-11
W
Warning Lights, Gages and Indicators................3-23
Warnings
DIC Warnings and Messages........................3-48
Hazard Warning Flashers............................... 3-3
Other Warning Devices.................................. 3-4
Safety and Symbols......................................... iii
Vehicle Damage.............................................. iv
Washing Your Vehicle......................................5-77
Weight of the Trailer........................................4-41
Weight of the Trailer Tongue.............................4-42
What Kind of Engine Oil to Use........................5-14
What to Add..................................................5-34
What to Do with Used Oil................................5-17
What to Use..................................5-24, 5-31, 5-43
Wheels
Alignment and Tire Balance..........................5-63
Replacement...............................................5-63
15