2004 CHEVROLET KODIAK manual transmission

300,000 Miles (480 000 km)
❑Remove, disassemble, clean and inspect the air
brake air dryer (or every 3 years, or 10,800 hours,
whichever occurs first). Replace desiccant on
Bendix-Westinghouse units.
Footnotes
† = The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to
the completion of the vehicle’s useful life. We, however,
urge that all recommended maintenance services be
performed at the indicated intervals and the
maintenance be recorded.
(1)= If your vehicle has an Allison automatic
transmission, your GM owner’s manual is supplemented
by an Allison Transmission
®Operator’s Manual.
Always refer to these manuals for related maintenance
services.
(2)= Refer to the Caterpillar
®Diesel Engine Operation
and Maintenance Manual for oil recommendations
and change intervals.
(3)= An Emission Control Service.
(4)= A Noise Emission Control Device.
(5)= Applies only to vehicles sold in the United States.(6)= Check fluid level in brake master cylinder, power
steering pump, axle, transmission and hydraulic
spring parking brake pump (if equipped). A low fluid
level in the brake master cylinder can indicate
worn brake linings and should be checked accordingly.
(7)= Inspect brake lines and hoses for proper
hook-up, binding, leaks, cracks, chafing, etc. Inspect
disc brake pads for wear and rotors for surface
condition. Inspect caliper assemblies. Check brake
pedal for excessive free play or travel (or every
6 months, whichever occurs first) and have serviced if
needed. Check brakes more often if driving habits
and conditions result in frequent braking.
(8)= Inspect parking brake drum and linings for wear or
cracks and check linkage and adjustment.
(9)= This vehicle has the GM Oil Life System. This
system will show you when to change the engine oil and
filter – usually between 3,000 miles (5 000 km) and
7,500 miles (12 000 km) since your last oil change.
Under severe conditions, the indicator may come on
before 3,000 miles (5 000 km). Never drive your vehicle
more than 7,500 miles (12 000 km) or 12 months
without an oil and filter change.
Remember to reset the Oil Life System whenever the oil
is changed. For more information, seeChange Engine
Oil Light on page 3-39.
6-19

(11)= Inspect rear axle air shift motor for fluid leaks.
Remove plug to check fluid level. Inspect air lines
and hoses for proper hook-up, binding, leaks, etc.
Inspect at 1,000 miles (1 600 km) and 22,500 miles
(36 000 km) and then every 22,500 miles (36 000 km)
thereafter.
(12)= Chassis Lubrication Service: Lubricate all grease
fittings in front suspension, front axle and steering
linkage. DO NOT lubricate kingpin bushings with air
pressure equipment; instead, use a hand grease gun to
ensure complete purge and eliminate sealer cap
distortion. Front axle tie rod ends, both upper and lower
kingpin fittings and both steering linkage relay rod
ends should be greased with the vehicle loaded on the
ground and wheels turned straight ahead, NOT with
the vehicle on a hoist. Apply kingpin bushing lubricant to
both upper and lower kingpin grease fittings until new
lubricant purges from between the upper shim pack and
thrust bearing. Lubricate transmission and shift
linkage, hood latches and hood hinges, parking brake
lever pivot, clevis pins and linkage, disc brake caliper
rails, clutch linkage and release bearing (if equipped),
bearing pads, propshaft universal joints, brake camshaft
bracket, slack adjusters, pedal shaft, clutch cross
shaft, clutch pedal springs and clutch cable bushing at
transmission. Lubricate suspension, axle and steeringlinkage more often when operating under dusty or
muddy conditions and in excessive off-road use.
Frequently power-washed vehicles will require more
frequent lubrication.
(13)= Check steering system:
•Look for damaged, loose or missing parts. Inspect
the steering linkage relay rod and tie rod ends for
looseness or lack of lubricant. Also look for
parts showing signs of wear or lack of lubrication.
Replace parts as needed. Also check steering gear
mounting bolts, pitman arm nut, gear housing
upper cover and side cover attaching bolts, steering
column mounting bolts and cardan joint clamp
bolts; tighten if necessary. (See service manual.)
•Inspect power steering hoses, tubes and fittings for
leaks. Hoses and lines must not be twisted, kinked
or tightly bent. Make sure clips, clamps, supporting
tubes and hoses are in place and properly
secured.
•Check steering gear for leakage around pitman
shaft and housing. If leakage is evident (lubricant
oozing out, not just oily film), leak should be
corrected immediately.
6-20

Part C: Recommended Fluids and
Lubricants
Fluids and lubricants identified below by name, part
number or specification may be obtained from your
dealer.
Usage Fluid/Lubricant
Engine Oil
(Gasoline
Engine)Engine oil which meets GM
Standard GM6094M and displays
the American Petroleum Institute
Certified for Gasoline Engines
starburst symbol. To determine the
proper viscosity for your vehicle’s
engine, see “Engine Oil” in the
Index.
Engine Oil
(DURAMAX™
Diesel Engine)Engine oil with the letters CI-4 or
CH-4 is best for your vehicle. The
CI-4 or CH-4 designation may
appear either alone or in
combination with other API
designations, such as API CI-4/SL.
These letters show American
Petroleum Institute levels of quality.
To determine the preferred viscosity
for your vehicle’s diesel engine, see
“Engine Oil” in the Index.
Usage Fluid/Lubricant
Engine Oil
(Caterpillar
®
Diesel Engine)See the Caterpillar
®Operation &
Maintenance Manual for engine oil
recommendations.
Engine Coolant
(Caterpillar
®
Diesel Engine)See the Caterpillar
®Operation &
Maintenance Manual for engine
coolant recommendations.
Engine Coolant
(Gasoline
Engine &
DURAMAX™
Diesel)50/50 mixture of clean, drinkable
water and use only
DEX-COOL
®Coolant. See “Engine
Coolant” in the Index.
Hydraulic Brake
SystemDelco Supreme 11 Brake Fluid or
equivalent DOT-3 brake fluid.
Windshield
Washer SolventGM Optikleen
®Washer Solvent.
Clutch Bearing
LubricantClutch Bearing Lubricant (GM Part
No. 12378484 or equivalent NLGI #3
consistency).
Exhaust Brake
Ball Joint Cap
LubricantHigh-Temperature Grease (GM Part
No. U.S. 1051344, in Canada
903037) or NLGI #3 consistency.
Power Steering
SystemDEXRON
®-III Automatic
Transmission Fluid.
6-29

Usage Fluid/Lubricant
Manual
Transmission
(Except ZF
6–Speed)Synthetic Manual Transmission Fluid
(GM Part No. U.S. 12345724, in
Canada 10953510).
Manual
Transmission
(ZF 6–Speed)TranSynd™ Synthetic Transmission
Fluid (GM Part No. U.S. 12378515,
in Canada 88900701).
Automatic
TransmissionSee the Allison
Transmission
®Operator’s Manual for
correct transmission fluid.
Key Lock
CylindersMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474).
Chassis
LubricationChassis Lubricant (GM Part No. U.S.
12377985, in Canada 88901242) or
lubricant meeting requirements of
NLGI #2, Category LB or GC-LB.
Front Wheel
Bearing Grease
(Except Oil
Filled Hubs)Wheel bearing lubricant meeting
requirements of NLGI #2, Category
GC or GC-LB (GM Part No. U.S.
1051344, in Canada 993037).
Usage Fluid/Lubricant
Front Wheel
Bearing Grease
with Oil Filled
HubsSAE 75W-90 Synthetic Axle
Lubricant for Medium Duty Trucks
(GM Part No. U.S. 12345841, in
Canada 10953512t).
Rear Axle and
Rear HubsSAE 75W-90 Synthetic Axle
Lubricant for Medium Duty Trucks
(GM Part No. U.S. 12345841, in
Canada 10953512).
Rear Axle Shift
Motor LubricantRefrigerant Oil (GM Part No.U.S.
5416939, in Canada 10953496).
Propshafts and
SplinesWheel bearing lubricant meeting
requirements of NLGI #2, Category
GC or GC-LB (GM Part No. U.S.
1051344, in Canada 993037).
Cab — Door
Hinges and
LatchesMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474).
Weatherstrip
ConditioningDielectric Silicone Grease (GM Part
No. U.S. 12345579, in Canada
992887).
Weatherstrip
SqueaksSynthetic Grease with Teflon,
Superlube (GM Part No. U.S.
12371287, in Canada 10953437).
6-30

Reporting Safety Defects to the
Canadian Government
If you live in Canada, and you believe that your vehicle
has a safety defect, you should immediately notify
Transport Canada, in addition to notifying General
Motors of Canada Limited. You may write to:
Transport Canada
330 Sparks Street
Tower C
Ottawa, Ontario K1A 0N5
Reporting Safety Defects to
General Motors
In addition to notifying NHTSA (or Transport Canada) in
a situation like this, we certainly hope you’ll notify us.
Please call us at 1-800-862-4389, or write:
GM Medium Duty Truck
Customer Assistance Center
P.O. Box 44947
Detroit, MI 48244In Canada, please call us at 1-800-263-3777 (English)
or 1-800-263-7854 (French). Or, write
General Motors of Canada Limited
Customer Communication Centre, 163-005
1908 Colonel Sam Drive
Oshawa, Ontario L1H 8P7
Service Publications Ordering
Information
Service Manuals
Service Manuals have the diagnosis and repair
information on engines, transmission, axle, suspension,
brakes, electrical, steering, body, etc.
RETAIL SELL PRICE: $120.00
7-7

Driving on Snow or Ice....................................4-26
Driving Through Deep Standing Water...............4-20
Driving Through Flowing Water.........................4-20
Dual Tire Operation.........................................5-69
E
Eaton®Fuller®Five and Six-Speed
Transmissions and TTC Spicer Seven-Speed
Transmissions.............................................2-30
Eaton
®Fuller®Nine and Ten-Speed
Non-Synchronized Manual Transmissions........2-32
Electric Air Compressor...................................5-51
Electrical Connections......................................4-36
Electrical System
Add-On Equipment......................................5-86
Fuses and Circuit Breakers...........................5-87
Fusible Links..............................................5-87
Headlamp Wiring.........................................5-86
Power Windows and Other Power Options......5-87
Windshield Wiper Fuses...............................5-87
Elevated Idle/Exhaust Restrictor........................2-21
Engine
Air Cleaner/Filter.........................................5-30
Battery.......................................................5-55
Change Engine Oil Light...............................3-39
Check and Service Engine Soon Light............3-37Engine (cont.)
Checks Before Operating..............................2-22
Coolant..............................................5-32, 5-35
Coolant Heater............................................2-23
Coolant Temperature Gage...........................3-35
Diesel Engine Exhaust Brake........................2-25
Drive Belt Routing......................................5-103
Exhaust.....................................................2-37
Fan Noise..................................................5-43
Oil .....................................................5-20, 5-25
Overheating................................................5-36
Overspeed Warning Light..............................3-39
Reduced Power Light...................................3-41
Shutdown Warning Light...............................3-39
Starting Your Diesel.....................................2-14
Starting Your DURAMAX™ Diesel..................2-19
Starting Your Gasoline..................................2-12
Engine Alarm and Automatic Shutdown..............2-16
Engine Coolant Level Check.............................6-24
Engine Cooling System Service........................6-26
Engine Cover Check.......................................6-28
Engine Oil Additives................................5-23, 5-29
Engine Oil Level Check...................................6-24
Engine Road Speed Governor..........................3-25
Engine Speed Limiting.....................................3-25
Engine Starter Over-Crank Protection.................2-12
Event Data Records (EDR)................................ 7-5
Exhaust Brake Indicator Light...........................3-40
5

Exhaust Restrictor (Diesel Engines)...................2-18
Exhaust System Check....................................6-27
Express-Down Feature.....................................2-10
Extender, Safety Belt.......................................1-26
Exterior Lamps...............................................3-13
F
Filter
Engine Air Cleaner......................................5-30
Filter Minder Gage..........................................3-44
Finding a Station............................3-46, 3-49, 3-53
Finish Care....................................................5-80
Finish Damage...............................................5-83
Fixed Mast Antenna........................................3-59
Flat Tire........................................................5-75
Flat Tire, Changing.........................................5-76
Fluid
Automatic Transmission................................5-31
Manual Transmission....................................5-32
Power Steering...........................................5-43
Windshield Washer......................................5-44
Fluid Leaks Check..........................................6-28
FM ...............................................................3-57
Folding the Rear Seat (Crew Cab).................... 1-7
Footnotes......................................................6-19
Fore-and-Aft Adjustment.................................... 1-4Four-Wheel and Six-Wheel Drum Brakes
(Air Only)...................................................5-49
Four-Wheel Disc Brakes
(Hydraulic Only)..........................................5-49
Front Wheel Bearings with Oil-Filled Hubs..........5-67
Fuel............................................................... 5-6
Additives...................................................... 5-7
Diesel Engine Fuel........................................ 5-8
Filling a Portable Fuel Container....................5-18
Filling Your Tank..........................................5-17
Filter..........................................................5-64
Filter Replacement.......................................5-15
Fuels in Foreign Countries............................5-16
Gage.........................................................3-42
Gasoline Octane........................................... 5-6
Gasoline Specifications.................................. 5-6
Primary Filter and Water Separator................5-65
Running Out of Fuel....................................5-15
Secondary Filter and Water Separator/Heater....5-66
Very Cold Weather Operation........................5-10
Water in Fuel..............................................5-10
Water in Warning Light.................................3-43
What Fuel to Use.......................................... 5-8
Fuel Filter (Diesel Engines)..............................5-65
Fuel Filter (Gasoline Engines)...........................5-64
Fuel Priming..................................................5-13
Fuses
Fuses and Circuit Breakers...........................5-87
Windshield Wiper.........................................5-87
6

G
Gage
Air Pressure...............................................3-44
Check Gages Warning Light..........................3-42
Engine Coolant Temperature.........................3-35
Filter Minder...............................................3-44
Fuel..........................................................3-42
Hourmeter..................................................3-45
Oil Pressure...............................................3-37
Speedometer..............................................3-25
Tachometer.................................................3-26
Transmission Temperature.............................3-40
Voltmeter Gage...........................................3-30
Gasoline
Octane........................................................ 5-6
Specifications............................................... 5-6
Gasoline Engine, Starting.................................2-12
Gasoline Engine Warm-Up...............................2-14
Glass, Mirrors, Lamps and/or Reflectors
Condition Check..........................................6-27
H
Hazard Warning Flashers................................... 3-5
Headlamp High/Low-Beam Changer.................... 3-8
Headlamp Wiring............................................5-86Headlamps On Reminder.................................3-13
Heavy-Duty Trailer Wiring Package....................4-35
Height Adjustment............................................. 1-6
High Idle System (Caterpillar
®Diesel and
Gasoline Engines).......................................2-16
Highway Hypnosis...........................................4-23
Hill and Mountain Roads..................................4-23
Hood
Checking Things Under................................5-18
Latches......................................................5-19
Hood Latches Check.......................................6-28
Horn............................................................... 3-6
Hourmeter Gage.............................................3-45
How to Add Coolant to the Coolant
Surge Tank.................................................5-39
How to Add Fluid............................................5-32
How to Check................................................5-69
How to Check and What to Use...............5-31, 5-32
How to Check Fluid........................................5-61
How to Check Lubricant...................................5-61
How To Check Power Steering Fluid..................5-43
How to Inspect the Engine Air Cleaner/Filter.......5-30
How to Use This Manual...................................... ii
How to Wear Safety Belts Properly...................1-13
Hydraulic Brake System
Warning Lights............................................3-32
Hydraulic Brake Systems................................... 4-6
Hydraulic Brakes.............................................2-33
Hydroplaning..................................................4-20
7