2004 BMW MOTORRAD R 1150 R light

i
2
Introduction
General information and
controls
General view, left side ........... 4
General view, right side ......... 5
Cockpit ................................. 6
Telltale and warning lights ..... 7
Ignition switch and steering
lock .................................... 8-9
Trip meter/clock .................. 10
Hazard warning flashers ...... 11
Left handlebar fitting ........... 12
Right handlebar fitting ......... 13
Seat/helmet holder .............. 14
Seats ............................. 15-16
System case .................. 17-19Safety check
Checklist ........................ 20-21
Engine oil ....................... 22-23
Fuel ................................ 24-25
Handlebar levers ............ 26-27
Brake system -
general........................... 28-29
Brake system - without
BMW Integral ABS ......... 30-32
Brake system - with
BMW Integral ABS ......... 33-36
Clutch ................................. 37
Lights ............................. 38-40
Shock-absorber
adjustment .......................... 41
Suspension
spring preload ..................... 42
Wheels ........................... 43-44
Accessories and loads ... 45-47
Contents
10r28bkg3.book Seite 2 Dienstag, 25. Mai 2004 5:26 17

3
i
Introduction
Starting – Riding – Parking
Your first journey ........... 48-49
Important notes ............. 50-51
Side stand ..................... 52-53
Centre stand ................. 54-55
Running in ..................... 56-57
Before you start ............. 58-59
Starting ......................... 60-61
Telltale and warning
lights ............................. 62-63
Riding, gear shifts.......... 64-65
Brake system
- general ........................ 66-67
Brake system - with
BMW Integral ABS......... 68-74
BMW Integral ABS
- Fault table ......................... 75Arrive safely
Reliability ........................76-77
Service worldwide ............... 78
Environmental protection .... 79
BMW rider’s equipment ....... 80
BMW motorcycle
equipment ........................... 81
Training means extra
safety .................................. 82
Concluding thoughts ........... 83
Contents
10r28bkg3.book Seite 3 Dienstag, 25. Mai 2004 5:26 17

1
General information and controls
6
7
543216
8
1Reset knob for trip meter
(
b 10)
2 Speedometer
3 Odometer
4 Trip meter (
b 10)
5 Clock (
b 10) 6
Revolution counter (
b 56)
7 Ignition switch and steering
lock (
b 8)
8 Telltale and warning lights
(
b 7)
( ) Figure in brackets
bpage number with explanation
Cockpit
10r28bkg3.book Seite 6 Dienstag, 25. Mai 2004 5:26 17

1
General information and controls
7
1Telltale light, left turn indica-
tor repeater green
s
2 Warning light, fuel level/
when approx. 5 litres
(1.1 Imp.gal) remain in tank
orange
m (b 25, 62)
3 Telltale light, neutral
green
k (b 59)
4 Telltale light, high (main)
beam blue
q
5 Telltale light, right turn indi-
cator repeater green
t

Optional extra
6Warning light, battery
charge current red
r
(b 63)
7 Warning light, ABS red
lOE (b 63)
8 Warning light, general red
e (b 63)
9 Warning light, engine oil
pressure red
p (b 62)
( ) Figure in brackets
bpage number with explanation
* depending on national-market speci- fication
Telltale and warning lights
12435
9
8
6
7*
10r28bkg3.book Seite 7 Dienstag, 25. Mai 2004 5:26 17

1
General information and controls
9
Ignition switch and steering lock
Key positions
d Warning:
Never turn the key to OFF or
I while riding the
motorcycle!
ON Operating position,
ignition, lights and all
electrical circuits
switched on
R * Ignition and lights off,
steering lock disengaged
(handlebars can be turned
freely to left or right)
* The key can be removed in these
positions
 Turn the handlebars to full left lock.
e Attention:
Engage the steering lock with
the handlebars in this position
only.
OFF* Ignition and lights off,
steering locked
I**Parking light on,
steering locked
L Note:
Switch the parking light on
only for limited periods. Note
state of battery charge.
10r28bkg3.book Seite 9 Dienstag, 25. Mai 2004 5:26 17

1
General information and controls
111
Hazard warning lights
L Note:
You cannot activate the hazard
warning flashers if the ignition is
switched off.
Do not use the hazard warning
flashers for longer than abso-
lutely necessary.
Note state of battery charge.
Switching on the hazard
warning lights
 Switching on the ignition
– Hazard warning switch lights
up  Operate hazard warning lights
switch 1
– Hazard warning lights in oper- ation
– The left/right flashing turn indicator repeater on the tell-
tale light panel (
b 7) flashes.
 Switch off the ignition
– The hazard warning lights continue to operate
– The light in the hazard warn- ing flasher switch goes out
Switching off the hazard
warning lights
 Operate hazard warning lights
switch 1
– Hazard warning lights switch off
– Left/right flashing turn indica- tor repeater on the telltale
light panel (
b 7) off
Hazard warning flashers
10r28bkg3.book Seite 11 Dienstag, 25. Mai 2004 5:26 17

1
General information and controls
12
1
2
534
d Warning:
To prevent air from entering
the clutch system:
 Do not turn the fitting on the handlebar.
 Do not turn the handlebars
in the clamping blocks.
1 Cold start choke lever
(increased engine speed)
(
b 61)
2 Hazard warning flashers
switch (
b 11) 3
Horn button
4 Left turn indicator switch
Press
–Turn indicators flash
To switch off:
 Press turn indicator cancel
switch 9
5 Headlight
FHigh (main) beam
GLow (dipped) beam
FHeadlight flasher
Left handlebar fitting
10r28bkg3.book Seite 12 Dienstag, 25. Mai 2004 5:26 17

1
General information and controls
14
Helmet holder Turn key in helmet/seat lock to position B.
 The helmet holder 3 is open
 Close the helmet holder by pressing it lightly into the hel-
met/seat lock until it engages
Removing seats Turn key in helmet/seat lock
to position A.
 Lift off the rear seat in the
direction indicated by arrow 1
– You now have access to the
toolkit and the on-board doc-
umentation. You can also
remove the front seat
 Lift off the front seat in the direction indicated by arrow 2
– You now have access to the fuses ( b Maintenance
Instructions, Chapter 2)
A2
1
B
Seat/helmet holder
3
10r28bkg3.book Seite 14 Dienstag, 25. Mai 2004 5:26 17