2003 TOYOTA MR2 SPYDER washer fluid

712003 MR2 from Aug. ’03 Prod. (OM17511U)
Windshield wipers and washer
SB14020
To turn on the windshield wipers, move
the lever to the desired setting.
The key must be in the “ON” position.Lever position
Speed setting
Position 1Intermittent
Position 2Slow
Position 3Fast
For a single sweep of the windshield,
push the lever up and release it. The “INT TIME” band lets you adjust the
wiping time interval when the wiper lever
is in the intermittent position (position 1).
Twist the band upward to increase the
time between sweeps, and downward to
decrease it.
To squirt washer fluid, pull the lever
toward you.
If the windshield wipers are off, they will
operate a couple of times after the washer
squirts.
For instructions on adding washer fluid,
see “Adding washer fluid” on page 225 in
Section 73.
In freezing weather, warm the windshield
with the defroster before using the washer.
This will help prevent the washer fluid
from freezing on the windshield, which can
block your vision.
NOTICE
Do not operate the wipers if the wind-
shield is dry. It may scratch the
glass.
Rear window defogger
SB14023
To defog or defrost the rear window,
push the switch.
The key must be in the “ON” position.
The thin heater wires on the inside of the
rear window will quickly clear the surface.
An indicator light will illuminate to indicate
the defogger is operating.
Push the switch once again to turn the
defogger off.
The system will automatically shut off af-
ter the defogger has operated about 15
minutes.
03 07.07

1562003 MR2 from Aug. ’03 Prod. (OM17511U)
Do not drive in excess of the speed
limit. Even if the legal speed limit
permits it, do not drive over 140
km/h (85 mph) unless your vehicle
has highspeed capability tires.
Driving over 140 km/h (85 mph) may
result in tire failure, loss of control
and possible injury. Be sure to con-
sult a tire dealer to determine
whether the tires on your vehicle
are highspeed capability tires or
not before driving at such speeds.
Do not continue normal driving
when the brakes are wet. If they are
wet, your vehicle will require a lon-
ger stopping distance, and it may
pull to one side when the brakes
are applied. Also, the parking brake
will not hold the vehicle securely.
Winter driving tips
Make sure your coolant is properly pro-
tected against freezing.
Only use “Toyota Super Long Life Coolant”
or similar high quality ethylene glycol
based nonsilicate, nonamine, nonnitrite,
and nonborate coolant with longlife hy-
brid organic acid technology.
See “Checking the engine coolant level” in
Section 72 for details of coolant type
selection.
“Toyota Super Long Life Coolant” is pre-
mixed with 50% coolant and 50% deion-
ized water. This coolant provides protec-
tion down to about 35C (31 F).
NOTICE
Do not use plain water alone.
Check the condition of the battery and
cables.
Cold temperatures reduce the capacity of
any battery, so it must be in top shape
to provide enough power for winter start-
ing. Section 73 tells you how to visually
inspect the battery. Your Toyota dealer
and most service stations will be pleased
to check the level of charge. Make sure the engine oil viscosity is
suitable for the cold weather.
See page 206 in Section 72 for recom-
mended viscosity. Leaving a heavy sum-
mer oil in your vehicle during winter
months may cause harder starting. If you
are not sure about which oil to use, call
your Toyota dealer—he will be pleased to
help.
Keep the door locks from freezing.
Squirt lock deicer or glycerine into the
locks to keep them from freezing.
Use a washer fluid containing an anti-
freeze solution.
This product is available at your Toyota
dealer and most auto parts stores. Follow
the manufacturer ’s directions for how
much to mix with water.NOTICE
Do not use engine antifreeze or any
other substitute because it may dam-
age your vehicle’s paint.
03 07.07

1932003 MR2 from Aug. ’03 Prod. (OM17511U)
If you are a skilled doityourself
mechanic, the Toyota service manuals are
recommended. Please be aware that
doityourself maintenance can affect your
warranty coverage. See “Owner ’s Warranty
Information Booklet” or “Owner ’s Manual
Supplement” for the details.
General maintenance
Listed below are the general maintenance
items that should be performed as fre-
quently as specified. In addition to check-
ing the items listed, if you notice any
unusual noise, smell or vibration, you
should investigate the cause or take your
vehicle to your Toyota dealer or a quali-
fied service shop immediately. It is recom-
mended that any problem you notice be
brought to the attention of your dealer or
the qualified service shop for their advice.
CAUTION
Make these checks only with ade-
quate ventilation if you run the en-
gine.
IN THE ENGINE COMPARTMENT
Items listed below should be checked
from time to time, e.g. each time when
refueling.
Washer fluid
Make sure there is sufficient fluid in the
tank. See page 225 in Section 73 for
additional information.Engine coolant level
Make sure the coolant level is between
the “FULL” and “LOW” lines on the see
through reservoir when the engine is cold.
See page 208 in Section 72 for addition-
al information.
Radiator, condenser and hoses
Check that the front of the radiator and
condenser are clean and not blocked with
leaves, dirt, or insects. See page 209 in
Section 72 for additional information.
Battery electrolyte level
Make sure the electrolyte level of all bat-
tery cells is between upper and lower lev-
el lines on the case. Add only distilled
water when replenishing. See page 222 in
Section 73 for additional information.
Brake fluid level
Make sure the brake fluid level is correct.
See page 209 in Section 72 for addition-
al information.
Engine oil level
Check the level by the dipstick with the
engine turned off and the vehicle parked
on a level spot. See page 206 in Section
72 for additional information.
03 07.07

1992003 MR2 from Aug. ’03 Prod. (OM17511U)
1. Brake fluid reservoir
2. Fuse block
3. Power steering fluid reservoir
4. Radiator
5. Electric cooling fans
6. Condenser
7. Windshield washer fluid tank
03 07.07
Trunk room overview
SB71020b

2032003 MR2 from Aug. ’03 Prod. (OM17511U)
Parts and tools
Here is a list of parts and tools you will
need to perform doityourself mainte-
nance. Remember all Toyota parts are de-
signed in metric sizes, so your tools must
be metric.
CHECKING THE ENGINE OIL LEVEL
Parts (if level is low):
“Toyota Genuine Motor Oil” or equiva-
lent
See page 206 in Section 72 for de-
tails about engine oil selection.
Tools:
Rag or paper towel
Funnel (only for adding oil)
CHECKING THE ENGINE COOLANT
LEVEL
Parts (if level is low):
“Toyota Super Long Life Coolant” or
similar high quality ethylene glycol
based nonsilicate, nonamine, nonni-
trite, and nonborate coolant with long
life hybrid organic acid technology.
“Toyota Super Long Life Coolant” is
premixed with 50% coolant and 50%
deionized water.
Tools:
Funnel (only for adding coolant) CHECKING BRAKE FLUID
Parts (if level is low):
SAE J1703 or FMVSS No.116 DOT 3
brake fluid
Tools:
Rag or paper towel
Funnel (only for adding fluid)
CHECKING POWER STEERING FLUID
Parts (if level is low):
Toyota P.S fluid EH or equivalent
Tools:
Rag or paper towel
Funnel (only for adding fluid)
CHECKING BATTERY CONDITION
Tools:
Warm water
Baking soda
Grease
Conventional wrench (for terminal
clamp bolts)
CHECKING AND REPLACING FUSES
Parts (if replacement is necessary):
Genuine Toyota fuse or equivalent with
same amperage rating as original ADDING WASHER FLUID
Parts:
Water
Washer fluid containing antifreeze
(for winter use)
Tools:
Funnel
REPLACING LIGHT BULBS
Parts:
Bulb with same number and wattage
rating as original (See charts in
“Replacing light bulbs—” on page 226
in Section 73.)
Tools:
Screwdriver
03 07.07

2212003 MR2 from Aug. ’03 Prod. (OM17511U)
DOITYOURSELF MAINTENANCE
Electrical components
Checking battery condition222
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Battery recharging precautions 223
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking and replacing fuses 224
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Adding washer fluid 225
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . .
Replacing light bulbs 226
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . .
03 07.07
SECTION 7 3

2252003 MR2 from Aug. ’03 Prod. (OM17511U)
If you are not sure whether the fuse has
blown, try replacing the suspected fuse
with one that you know is good.
If the fuse has blown, push a new fuse
into the clip.
Only install a fuse with the amperage rat-
ing designated on the fuse box lid.
If you do not have a spare fuse, in an
emergency you can pull out the “D P/W”,
“P P/W” or “CIG” fuse, which may be
dispensable for normal driving, and use it
if its amperage rating is the same.
If you cannot use one of the same amper-
age, use one that is lower, but as close
as possible to the rating. If the amperage
is lower than that specified, the fuse
might blow out again but this does not
indicate anything wrong. Be sure to get
the correct fuse as soon as possible and
return the substitute to its original clip.
It is a good idea to purchase a set of
spare fuses and keep them in your ve-
hicle for emergencies.
If the new fuse immediately blows out,
there is a problem with the electrical sys-
tem. Have your Toyota dealer correct it as
soon as possible.CAUTION
Never use a fuse with a higher am-
perage rating, or any other object, in
place of a fuse. This may cause ex-
tensive damage and possibly a fire.
Adding washer fluid
SB73003
If any washer does not work, the wash-
er tank may be empty. Check the wash-
er fluid level on the level gauge. If the
washer fluid level is below “LOW”, add
washer fluid.
You may use plain water as washer fluid.
However, in cold areas where tempera-
tures range below freezing point, use
washer fluid containing antifreeze. This
product is available at your Toyota dealer
and most auto parts stores. Follow the
manufacturer ’s directions for how much to
mix with water.
03 07.07

2482003 MR2 from Aug. ’03 Prod. (OM17511U)
A
Adding washer fluid225
. . . . . . . . . . . . . . . .
Adjustment
Seats 30
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Seat belt 31
. . . . . . . . . . . . . . . . . . . . . . . . .
Air conditioning system 113
. . . . . . . . . . . . .
Airbags 37
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Aluminum wheel precautions 219 . . . . . . . .
Antiglare inside rear view mirror 66 . . . . .
Antilock brake system warning light 77
. . . . . . . . . . . . . . . . . . . . . .
Antitheft steering column lock 84 . . . . . . .
Appearance care Cleaning the interior 188
. . . . . . . . . . . . . .
Protecting your Toyota from
corrosion 184
. . . . . . . . . . . . . . . . . . . . . .
Washing and waxing 185
. . . . . . . . . . . . . .
Auxiliary box 124
. . . . . . . . . . . . . . . . . . . . . .
Auxiliary catch, Trunk lid 15
. . . . . . . . . . . . .
B
Battery
Checking battery condition 222 . . . . . . . .
Gas caution 222 . . . . . . . . . . . . . . . . . . . . .
Handling safety 222 . . . . . . . . . . . . . . . . . .
Recharging precautions 223 . . . . . . . . . . .
Winter driving tips 156 . . . . . . . . . . . . . . . .
Before starting the engine 154 . . . . . . . . . . .
Brake pad wear limit indicators 138 . . . . . .
Brake system 135 . . . . . . . . . . . . . . . . . . . . . .
Brake system warning light 77 . . . . . . . . . . Brakes
Fluid level 209 . . . . . . . . . . . . . . . . . . . . . . .
Pad wear limit indicators 138 . . . . . . . . . .
Parking 97 . . . . . . . . . . . . . . . . . . . . . . . . . .
Breakin tips 130 . . . . . . . . . . . . . . . . . . . . . .
Brightness control 70 . . . . . . . . . . . . . . . . . . .
C
Car audio system 101
. . . . . . . . . . . . . . . . . .
Carbon monoxide caution 133
. . . . . . . . . . .
Cargo and luggage Capacity 149
. . . . . . . . . . . . . . . . . . . . . . . .
Distribution 150
. . . . . . . . . . . . . . . . . . . . . .
Stowage precautions 149
. . . . . . . . . . . . .
Cassette player 102
. . . . . . . . . . . . . . . . . . . .
Checking and replacing fuses 224 . . . . . . . .
Checking and replacing tires 213 . . . . . . . .
Checking brake fluid 209
. . . . . . . . . . . . . . . .
Checking the engine oil level 206 . . . . . . . .
Checking power steering fluid 210 . . . . . . .
Child restraint Child restraint system 47
. . . . . . . . . . . . .
Installation with seat belt 49
. . . . . . . . . . .
Precautions 46
. . . . . . . . . . . . . . . . . . . . . .
Types of child restraint system 48 . . . . . .
Cigarette lighter and ashtray 122
. . . . . . . . .
Cleaning the interior 188
. . . . . . . . . . . . . . . .
Clock 122
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cold weather operation 156
. . . . . . . . . . . . .
Compact disc player 102
. . . . . . . . . . . . . . . .
Cooling system Coolant level 208
. . . . . . . . . . . . . . . . . . . . Engine overheating
166
. . . . . . . . . . . . . . .
Radiator and condenser 209
. . . . . . . . . . .
Radiator and reservoir 208
. . . . . . . . . . . .
Radiator cap 166
. . . . . . . . . . . . . . . . . . . . .
Winter driving tips 156
. . . . . . . . . . . . . . . .
Corrosion prevention 184
. . . . . . . . . . . . . . .
Cruise control 98
. . . . . . . . . . . . . . . . . . . . . .
Cup holders 127
. . . . . . . . . . . . . . . . . . . . . . . D
Defogger, Rear window 71
. . . . . . . . . . . . . .
Dimensions and weight 238
. . . . . . . . . . . . .
Dimmer switch, Headlight 68
. . . . . . . . . . . .
Dinghy towing 157
. . . . . . . . . . . . . . . . . . . . .
Directional signals 68
. . . . . . . . . . . . . . . . . .
Discharge warning light 77
. . . . . . . . . . . . . .
Doityourself maintenance
Parts and tools 203
. . . . . . . . . . . . . . . . . . .
Service precautions 201
. . . . . . . . . . . . . .
Does your vehicle need
repairing? 195
. . . . . . . . . . . . . . . . . . . . . . .
Driver ’s seat belt light 77
. . . . . . . . . . . . . . .
Driver ’s seat belt reminder buzzer 77 . . . . .
Driving Driving tips 155,156
. . . . . . . . . . . . . . . . . .
Manual transmission 96
. . . . . . . . . . . . . .
Sequential manual transmission 85 . . . .
Driving tips Driving tips in various
conditions 155
. . . . . . . . . . . . . . . . . . . . .
Driving with a manual transmission 96
. . . . . . . . . . . . . . . . . . . .
03 07.07