2003 TOYOTA MR2 SPYDER trunk

1972003 MR2 from Aug. ’03 Prod. (OM17511U)
DOITYOURSELF MAINTENANCE
Introduction
Engine compartment overview198
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Trunk room overview 199
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . .
Fuse locations 200
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . .
Doityourself service precautions 201
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Parts and tools 203
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . .
Positioning the jack 204
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . .
03 07.07
SECTION 7 1

1992003 MR2 from Aug. ’03 Prod. (OM17511U)
1. Brake fluid reservoir
2. Fuse block
3. Power steering fluid reservoir
4. Radiator
5. Electric cooling fans
6. Condenser
7. Windshield washer fluid tank
03 07.07
Trunk room overview
SB71020b

2012003 MR2 from Aug. ’03 Prod. (OM17511U)
If you perform maintenance by yourself,
be sure to follow the correct procedure
given in this Section.
You should be aware that improper or in-
complete servicing may result in operating
problems.
Performing doityourself maintenance
during the warranty period may affect your
warranty coverage. Read the separate
Toyota Warranty statement for details and
suggestions.
This section gives instructions only for
those items that are relatively easy for an
owner to perform. As explained in Section
6, there are still a number of items that
must be done by a qualified technician
with special tools.
For information on tools and parts for do
ityourself maintenance, see “Parts and
tools” on page 203.
Utmost care should be taken when work-
ing on your vehicle to prevent accidental
injury. Here are a few precautions that
you should be especially careful to ob-
serve:CAUTION
When the engine is running, keep
hands, clothing, and tools away
from the moving fan and engine
drive belts. (Removing rings,
watches, and ties is advisable.)
Right after driving, the engine
compartment and trunk room—the
engine, radiator, exhaust manifold,
power steering fluid reservoir and
spark plug boots, etc.—will be hot.
So be careful not to touch them.
Oil, fluids and spark plugs may also
be hot.
If the engine is hot, do not remove
the coolant reservoir cap or air re-
lease valve or loosen the drain
plugs to prevent burning yourself.
Do not smoke, cause sparks or al-
low open flames around fuel or the
battery. Their fumes are flammable.
Do not get under your vehicle with
just the body jack supporting it. Al-
ways use automotive jack stands or
other solid supports.
Be sure that the ignition is off if
you work near the electric cooling
fans or radiator grille. With the
ignition on, the electric cooling fans
will automatically start to run if the
engine coolant temperature is high
and/or the air conditioning is on.
Use eye protection whenever you
work on or under your vehicle
where you may be exposed to flying
or falling material, fluid spray, etc.
Be extremely cautious when work-
ing on the battery. It contains poi-
sonous and corrosive sulfuric acid.
Warning: Battery posts, terminals
and related accessories contain lead
and lead compounds, chemicals
known to the State of California to
cause cancer and reproductive
harm. Wash hands after handling
Used engine oil contains potentially
harmful contaminants which may
cause skin disorders such as in-
flammation or skin cancer, so care
should be taken to avoid prolonged
and repeated contact with it. To re-
move used engine oil from your
skin, wash thoroughly with soap
and water.
03 07.07
Doityourself service
precautions

2022003 MR2 from Aug. ’03 Prod. (OM17511U)
Do not leave used oil within the
reach of children.
Dispose of used oil and filter only
in a safe and acceptable manner.
Do not dispose of used oil and fil-
ter in household trash, in sewers or
onto the ground. Call your dealer or
a service station for information
concerning recycling or disposal.
Take care when filling the brake and
clutch fluid reservoirs because
brake fluid can harm your eyes and
damage painted surfaces. If fluid
gets in your eyes, flush your eyes
with clean water.
When racing the engine, make sure
that the gear position is in the “N”
position. In case the accelerator is
operated with the gear in any other
positions, the vehicle may move, re-
sulting in an unexpected accident.
NOTICE
Remember that battery and ignition
cables carry high currents or volt-
ages. Be careful of accidentally
causing a short circuit.
Add only “Toyota Super Long Life
Coolant” or similar high quality eth-
ylene glycol based nonsilicate,
nonamine, nonnitrite, and nonbo-
rate coolant with longlife hybrid
organic acid technology to fill the
radiator. And if you spill some of
the coolant, be sure to wash it off
with water to prevent it from dam-
aging the parts or paint.
 Do not allow dirt or anything else
to fall through the spark plug holes.
 Do not pry the outer electrode of a
spark plug against the center elec-
trode.
 Use only spark plugs of the speci-
fied type. Using other types will
cause engine damage, loss of per-
formance or radio noise.
 Do not reuse iridiumtipped spark
plugs by cleaning or regapping.
 Do not drive with the air cleaner
filter removed, or excessive engine
wear could result. Also backfiring
could cause a fire in the engine
compartment.
 Be careful not to scratch the glass
surface with the wiper frame.When closing the engine hood or
trunk, check to see that you have
not forgotten any tools, rags, etc.
03 07.07

2102003 MR2 from Aug. ’03 Prod. (OM17511U)
If the level is low, add SAE J1703 or
FMVSS No.116 DOT 3 brake fluid to the
brake reservoir.
Remove and replace the reservoir cap by
hand. Fill the brake fluid to the dotted
line. This brings the fluid to the correct
level when you put the cap back on.
Use only newly opened brake fluid. Once
opened, brake fluid absorbs moisture from
the air, and excess moisture can cause a
dangerous loss of braking.
CAUTION
Take care when filling the reservoir
because brake fluid can harm your
eyes and damage painted surfaces. If
fluid gets in your eyes, flush your
eyes with clean water immediately. If
you still feel uncomfortable with your
eyes, go to the doctor.
NOTICE
If you spill the fluid, be sure to wash
it off with water to prevent it from
damaging the parts or paint.
SB72002
Open
Close
If hot add
If cold addIf hot
O.K.
If cold
O.K.
Check the fluid level through the reser-
voir. If necessary, add Toyota P.S fluid
EH or equivalent.
Before checking the power steering
fluid, remove the cover inside the
trunk. (See “Replacing light bulbs” on
page 226 in Section 73.)
If the vehicle has been driven around 80
km/h (50 mph) for 20 minutes (a little
more in frigid temperatures), the fluid is
hot (60
°C—80 °C or 140 °F—175 °F). You
may also check the level when the fluid
is cold (about room temperature,
10 °C—30 °C or 50 °F—85 °F) if the engine
has not been run for about five hours. Clean all dirt from outside of the reservoir
tank and look at the fluid level. If the fluid
is cold, the level should be in the “COLD”
range. Similarly, if it is hot, the fluid level
should be in the “HOT” range. If the level
is at the low side of either range, add
Toyota P.S fluid EH or equivalent to bring
the level within the range.
To remove the reservoir cap, turn it coun-
terclockwise and lift up. To reinstall it,
turn it clockwise. After replacing the reser-
voir cap, visually check the steering box
case, vane pump and hose connections
for leaks or damage.
CAUTION
The reservoir tank may be hot so be
careful not to burn yourself.
NOTICE
Avoid overfilling, or the power steer-
ing could be damaged.
03 07.07
Checking power steering fluid

2282003 MR2 from Aug. ’03 Prod. (OM17511U)
SC73006b
2. Remove the cover in the trunk.
Remove and install the cover clips as
shown in the following illustrations.
SC18005
Removing clips
SC18006
Installing clips
—Headlights (low beam)
SB73043a
1. Unplug the connector. Remove the rubber cover.
If the connector is tight, wiggle it.
03 07.07

2432003 MR2 from Aug. ’03 Prod. (OM17511U)
Fuses
SB73067
Trunk room
Fuses (type A)1. 30 A: Spare fuse
2. 15 A: Spare fuse
3. 20 A: Spare fuse
4. RDI FAN 30 A: Electric cooling fans
5. ABS1 30 A: Antilock brake system
6. CDS FAN 30 A: Electric cooling fans
7. HEAD LH UPR 10 A: Lefthand head-
light (high beam)
8. HEAD RH UPR 10 A: Righthand
headlight (high beam)
9. WASHER 10 A: Windshield wiper and
washer
SB73025a
Trunk room
10. HTR 10 A: Air conditioning system
11. WIPER 20 A: Windshield wiper and
washer
12. ECUIG 7.5 A: Power Steering system,
antilock brake system
13. FANIG 7.5 A: Electric cooling fans
14. TURN 7.5 A: Turn signal lights, emer-
gency flashers
15. GAUGE 7.5 A: Power window system,
gauges and meters, backup lights,
charging system, rear window defogger
system
16. SRS 7.5 A: SRS airbag system
SB73026b
Instrument panel
17. DEF 25 A: Rear window defogger sys-
tem
18. OBD 7.5 A: Onboard diagnosis sys-
tem
19. AM1 7.5 A: “GAUGE” “ACC” “TURN”
“ECUIG” “WIPER” “WASHER” “SRS”
“HTR 10A” “FANIG” fuses
20. ACC 25 A: “RADIO2” “CIG” fuses
21. DOOR 15 A: Power door lock system
22. FR FOG 15A: Front fog light
23. STOP 15 A: Stop lights, high mounted
stop light, sequential manual transmis-
sion system
03 07.07

2482003 MR2 from Aug. ’03 Prod. (OM17511U)
A
Adding washer fluid225
. . . . . . . . . . . . . . . .
Adjustment
Seats 30
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Seat belt 31
. . . . . . . . . . . . . . . . . . . . . . . . .
Air conditioning system 113
. . . . . . . . . . . . .
Airbags 37
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Aluminum wheel precautions 219 . . . . . . . .
Antiglare inside rear view mirror 66 . . . . .
Antilock brake system warning light 77
. . . . . . . . . . . . . . . . . . . . . .
Antitheft steering column lock 84 . . . . . . .
Appearance care Cleaning the interior 188
. . . . . . . . . . . . . .
Protecting your Toyota from
corrosion 184
. . . . . . . . . . . . . . . . . . . . . .
Washing and waxing 185
. . . . . . . . . . . . . .
Auxiliary box 124
. . . . . . . . . . . . . . . . . . . . . .
Auxiliary catch, Trunk lid 15
. . . . . . . . . . . . .
B
Battery
Checking battery condition 222 . . . . . . . .
Gas caution 222 . . . . . . . . . . . . . . . . . . . . .
Handling safety 222 . . . . . . . . . . . . . . . . . .
Recharging precautions 223 . . . . . . . . . . .
Winter driving tips 156 . . . . . . . . . . . . . . . .
Before starting the engine 154 . . . . . . . . . . .
Brake pad wear limit indicators 138 . . . . . .
Brake system 135 . . . . . . . . . . . . . . . . . . . . . .
Brake system warning light 77 . . . . . . . . . . Brakes
Fluid level 209 . . . . . . . . . . . . . . . . . . . . . . .
Pad wear limit indicators 138 . . . . . . . . . .
Parking 97 . . . . . . . . . . . . . . . . . . . . . . . . . .
Breakin tips 130 . . . . . . . . . . . . . . . . . . . . . .
Brightness control 70 . . . . . . . . . . . . . . . . . . .
C
Car audio system 101
. . . . . . . . . . . . . . . . . .
Carbon monoxide caution 133
. . . . . . . . . . .
Cargo and luggage Capacity 149
. . . . . . . . . . . . . . . . . . . . . . . .
Distribution 150
. . . . . . . . . . . . . . . . . . . . . .
Stowage precautions 149
. . . . . . . . . . . . .
Cassette player 102
. . . . . . . . . . . . . . . . . . . .
Checking and replacing fuses 224 . . . . . . . .
Checking and replacing tires 213 . . . . . . . .
Checking brake fluid 209
. . . . . . . . . . . . . . . .
Checking the engine oil level 206 . . . . . . . .
Checking power steering fluid 210 . . . . . . .
Child restraint Child restraint system 47
. . . . . . . . . . . . .
Installation with seat belt 49
. . . . . . . . . . .
Precautions 46
. . . . . . . . . . . . . . . . . . . . . .
Types of child restraint system 48 . . . . . .
Cigarette lighter and ashtray 122
. . . . . . . . .
Cleaning the interior 188
. . . . . . . . . . . . . . . .
Clock 122
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cold weather operation 156
. . . . . . . . . . . . .
Compact disc player 102
. . . . . . . . . . . . . . . .
Cooling system Coolant level 208
. . . . . . . . . . . . . . . . . . . . Engine overheating
166
. . . . . . . . . . . . . . .
Radiator and condenser 209
. . . . . . . . . . .
Radiator and reservoir 208
. . . . . . . . . . . .
Radiator cap 166
. . . . . . . . . . . . . . . . . . . . .
Winter driving tips 156
. . . . . . . . . . . . . . . .
Corrosion prevention 184
. . . . . . . . . . . . . . .
Cruise control 98
. . . . . . . . . . . . . . . . . . . . . .
Cup holders 127
. . . . . . . . . . . . . . . . . . . . . . . D
Defogger, Rear window 71
. . . . . . . . . . . . . .
Dimensions and weight 238
. . . . . . . . . . . . .
Dimmer switch, Headlight 68
. . . . . . . . . . . .
Dinghy towing 157
. . . . . . . . . . . . . . . . . . . . .
Directional signals 68
. . . . . . . . . . . . . . . . . .
Discharge warning light 77
. . . . . . . . . . . . . .
Doityourself maintenance
Parts and tools 203
. . . . . . . . . . . . . . . . . . .
Service precautions 201
. . . . . . . . . . . . . .
Does your vehicle need
repairing? 195
. . . . . . . . . . . . . . . . . . . . . . .
Driver ’s seat belt light 77
. . . . . . . . . . . . . . .
Driver ’s seat belt reminder buzzer 77 . . . . .
Driving Driving tips 155,156
. . . . . . . . . . . . . . . . . .
Manual transmission 96
. . . . . . . . . . . . . .
Sequential manual transmission 85 . . . .
Driving tips Driving tips in various
conditions 155
. . . . . . . . . . . . . . . . . . . . .
Driving with a manual transmission 96
. . . . . . . . . . . . . . . . . . . .
03 07.07